IllustrationRECALL PROBLEMS WITH EXHAUST AND AIR BAGS. *MR THERE WAS NO BACK UP LIGHTS, HORN, OR CLOCKSPRING. *SC
1997 Dodge Grand Caravan
Owner reports · Recalls · Investigations
More warning signs than most Grand Caravan years
Owner complaints for the 1997 Dodge Grand Caravan are substantially higher than the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 132 of 583 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 107 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 102 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
29 crash reports39 fire reports22 injury reports
What owners actually said
583 reportsWHILE DRIVING FRONT WINDSHIELD WIPERS CAME ON WITHOUT WARNING. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
THE WIPERS OCCASIONALLY COMES ON WHEN TURN SIGNAL IS ON. THE WIPERS CAME ON WHILE I WAS TURNING - CHANGING LANES AND PARTIALLY BLINDING MY VIEW OF THE ROAD. I ALMOST CRASHED WHILE MAKING THE TURN AND IN THE SAME TIME TRYING TO TURN OFF THE WIPER. SINCE THE WIPERS WENT ON WHEN THE WINDSHIELD IS DRY, IT CAUSES THE WIPERS TO STREAK…
Read full complaint
THE WIPERS OCCASIONALLY COMES ON WHEN TURN SIGNAL IS ON. THE WIPERS CAME ON WHILE I WAS TURNING - CHANGING LANES AND PARTIALLY BLINDING MY VIEW OF THE ROAD. I ALMOST CRASHED WHILE MAKING THE TURN AND IN THE SAME TIME TRYING TO TURN OFF THE WIPER. SINCE THE WIPERS WENT ON WHEN THE WINDSHIELD IS DRY, IT CAUSES THE WIPERS TO STREAK LOUDLY AND SCRATCH THE GLASS. ALSO, THE WIPERS CROSSED EACH OTHER AND CAUSE IT TO SUDDENLY BACK AGAINST THE GLASS. LUCKILY, THE WIPERS DIDN'T SMASH THE WINDSHIELD. HAVING THE WIPERS TURN ON A DRY WINDSHIELD GLASS WHILE TURNING IS VERY DANGEROUS. WE WERE LUCKY THAT MY CHILDREN AND I WEREN'T HURT BY THIS INCIDENT. *JB
REPORTED PROBLEM TO DODGE CORP. SEVERAL YEARS AGO ABOUT WIPERS COMING ON BY THEMSELVES. WAS ADVISED THAT SINCE NO RECALL, NO REMEDY. ON THIS ISSUE, MY RESEARCH SHOWS THAT THERE HAVE BEEN ENOUGH COMPLAINTS AND THIS ISSUE SHOULD BE HANDLED BY A RECALL. SECONDLY, AND MOST RECENTLY. BOTH DRIVER AND PASSENGER WINDOWS FAILED. DODGE R…
Read full complaint
REPORTED PROBLEM TO DODGE CORP. SEVERAL YEARS AGO ABOUT WIPERS COMING ON BY THEMSELVES. WAS ADVISED THAT SINCE NO RECALL, NO REMEDY. ON THIS ISSUE, MY RESEARCH SHOWS THAT THERE HAVE BEEN ENOUGH COMPLAINTS AND THIS ISSUE SHOULD BE HANDLED BY A RECALL. SECONDLY, AND MOST RECENTLY. BOTH DRIVER AND PASSENGER WINDOWS FAILED. DODGE REPRESENTS THAT TIME/MILEAGE PRECLUDES REPAIR AT THEIR COST. REAR WING VENT WINDOW QUIT WORKING APPROX. A WEEK AGO (MAR. 2004). VEHICLE SEEMS TO BE FALLING APART ELECTRONICALLY. MILEAGE/WARRANTY SHOULD NOT BE AN ISSUE. DEFECTS ARE DEFECTS. RECALL REQUESTED. *JB *NM
WHILE BACKING OUT OF THE DRIVEWAY, THE CONSUMER HEARD A LOUD BANG. THE VEHICLE WOULD NOT STEER. THE PULLEY BROKE OFF, CAUSING THE DRIVE BELT TO FALL ONTO THE STREET. *AK THERE WAS ANOTHER INCIDENT WHERE THE CONSUMER WAS MAKING A TURN AND LOST ALL POWER STEERING. THE CONSUMER WITNESSED ANOTHER VEHICLE WITH THE SAME MAKE AND…
Read full complaint
WHILE BACKING OUT OF THE DRIVEWAY, THE CONSUMER HEARD A LOUD BANG. THE VEHICLE WOULD NOT STEER. THE PULLEY BROKE OFF, CAUSING THE DRIVE BELT TO FALL ONTO THE STREET. *AK THERE WAS ANOTHER INCIDENT WHERE THE CONSUMER WAS MAKING A TURN AND LOST ALL POWER STEERING. THE CONSUMER WITNESSED ANOTHER VEHICLE WITH THE SAME MAKE AND MODEL EXPERIENCING THE EXACT SAME PROBLEM. (THE CONSUMER'S ALTERNATE ADDRESS: P.O. BOX 585 ZIP 03825) *SC *JB
SUDDEN ACCELERATION. *JB
POWER STEERING RACK OPERATES POORLY. WHEN THIS OCCURS THERE IS NO POWER STEERING WHEN TURNING RIGHT. THE STERING FLUID LEAKS OUT. DEALERSHIP REPLACED THE STEERING RACK, BUT THE FAILURE RECCURED WITHIN 38,000 MILES. *AK
DRIVER SEATBACK FAILURE. WHILE THE VEHICLE WAS STATIONARY IN A PARKING LOT, THE DRIVER CLIMBED INTO THE DRIVER SEAT, AND THE SEAT BACK SPONTANEOUSLY FAILED. THE SEAT BACK COLLAPSED ONTO THE CHILD PASSENGER SEATED BEHIND THE DRIVER, CAUSING SLIGHT SUPERFICIAL INJURY. EXAMINATION SHOWED THAT THE SEAT BACK SUFFERED METAL SHEER AN…
Read full complaint
DRIVER SEATBACK FAILURE. WHILE THE VEHICLE WAS STATIONARY IN A PARKING LOT, THE DRIVER CLIMBED INTO THE DRIVER SEAT, AND THE SEAT BACK SPONTANEOUSLY FAILED. THE SEAT BACK COLLAPSED ONTO THE CHILD PASSENGER SEATED BEHIND THE DRIVER, CAUSING SLIGHT SUPERFICIAL INJURY. EXAMINATION SHOWED THAT THE SEAT BACK SUFFERED METAL SHEER AND SPOT WELD FAILURE. VEHICLE WAS STATIONARY AT THE TIME OF THE SEAT BACK FAILURE, AND HAD NOT BEEN IN ANY PREVIOUS ACCIDENT, NOR HAD THE SEAT EVER BEEN REPLACED. THIS WAS THE ORIGINAL MANUFACTURER'S SEAT.*AK
THE AIR BAG LIGHT IN OUR '97 DODGE CARAVAN HAS STARTED COMING ON INTERMITTENTLY. INDICATIONS ARE THAT IT IS DUE TO AN INTERMITTENT CLOCKSPRING WIRING HARNESS IN THE STEERING COLUMN, MEANING THAT THE HORN AND CRUISE CONTROL WOULD NOT WORK AS WELL AS THE DRIVER'S SIDE AIRBAG. IT APPEARS THIS CLOCKSPRING FAILURE MODE IS BEING INV…
Read full complaint
THE AIR BAG LIGHT IN OUR '97 DODGE CARAVAN HAS STARTED COMING ON INTERMITTENTLY. INDICATIONS ARE THAT IT IS DUE TO AN INTERMITTENT CLOCKSPRING WIRING HARNESS IN THE STEERING COLUMN, MEANING THAT THE HORN AND CRUISE CONTROL WOULD NOT WORK AS WELL AS THE DRIVER'S SIDE AIRBAG. IT APPEARS THIS CLOCKSPRING FAILURE MODE IS BEING INVESTIGATED BY THE NHTSA, BUT THERE IS NO RECALL. I WILL PROBABLY HAVE TO PAY THE DEALER TO FIX IT (AROUND $200). *JB
WAS HIT FROM BEHIND IN 1997 DODGE CARAVAN AND PUSHED INTO VEHICLE IN FRONT, AIRBAGS DEPLOYED, FRONT SEAT RECLINER ASSEMBLY WENT BACK, THROWING DRIVER TO BACK, CAUSING HEAD, NECK AND BACK INJURY.*AK
Official recalls
502V293000 · Air Bags:frontal
Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
98V185000 · Child Seat
Aug 6, 1998
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
97V200000 · Tires:bead
Nov 13, 1997
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEEL. THE TIRES CAN EXPERIENCE A SUDDEN AIR PRESSURE LOSS WITHOUT WARNING.
Consequence & remedy
Consequence: SUDDEN TIRE FAILURE COULD RESULT IN A LOSS OF DRIVER CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIRES THAT WERE MOUNTED ON STEEL WHEELS.
96V215000 · Service Brakes, Hydraulic:foundation Components:master Cylinder
Oct 29, 1996
THE MASTER CYLINDER REAR SEAL, BETWEEN THE HYDRAULIC FLUID AND THE VACUUM RESERVOIR, MAY NOT SEAL ADEQUATELY ALLOWING HYDRAULIC FLUID TO BE DRAWN INTO THE POWER ASSIST VACUUM RESERVOIR.
Consequence & remedy
Consequence: AS THE HYDRAULIC FLUID IN THE MASTER CYLINDER RESERVOIR DECREASES, THE LEVEL SENSOR WILL DETECT THE LOSS OF FLUID AND ILLUMINATE THE INSTRUMENT PANEL BRAKE WARNING LAMP. CONTINUED OPERATION OF THE VEHICLE WITH THE WARNING LAMP ILLUMINATED CAN RESULT IN EXTENDED STOPPING DISTANCES.
Remedy: DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER ON ALL AFFECTED VEHICLES. ADDENDUM (4-14-97): VEHICLES INSPECTED PER CHRYSLER RECALL NO. 707 AND FOUND TO BE OUTSIDE THE LISTED SUSPECT MASTER CYLINDER DATE CODE RANGE, MUST NOW HAVE THE MASTER CYLINDER PRIMARY PISTON REPLACED (CHRYSLER RECALL NO. 714).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.