Engine And Engine CoolingPower TrainService Brakes, Hydraulic
THE TRANSMISSION DOES NOT SHIFT GEARS IF THE AIR CONDITIONER IS ON. THE AIR CONDITIONER TURNED ALL THE WAY UP WILL BLOW OUT AIR AS IF IT WAS ON MID WAY. THE WIND SHIELD WIPERS COME ON WHEN THE TURN SIGNAL IS ACTIVATED, WHICH CAUSES ME TO BUY BLADES MORE OFTEN. THE BRAKES SEEM TO LOCK UP WHEN THE GROUND IS WET. YOU CAN HEAR META…
Read full complaint
THE TRANSMISSION DOES NOT SHIFT GEARS IF THE AIR CONDITIONER IS ON. THE AIR CONDITIONER TURNED ALL THE WAY UP WILL BLOW OUT AIR AS IF IT WAS ON MID WAY. THE WIND SHIELD WIPERS COME ON WHEN THE TURN SIGNAL IS ACTIVATED, WHICH CAUSES ME TO BUY BLADES MORE OFTEN. THE BRAKES SEEM TO LOCK UP WHEN THE GROUND IS WET. YOU CAN HEAR METAL HITTING TOGETHER, AND THE CAR CONTINUES TO ROLL. MY SISTER-IN-LAW, AND ONE OF MY DAYCARE MOMS HAD THE SAME PROBLEM, BUT THEY WERE NOT AS LUCKY AS I WAS IT CAUSED THEM TO REAR END ANOTHER VEHICLE.
NHTSA ODI #10070637
Mileage unknown · Oct 4, 2002
Unknown Or Other
FUEL GAUGE READING EMPTY WHEN VEHICLE IS ACTUALLY FULL OF FUEL. *MR
NHTSA ODI #8020213
Mileage unknown · Jul 18, 2002
Unknown Or Other
ENGINE CHECK LIGHT HAS COME ON,.VEHICLE HAS NOT BEEN EXAMINED BY DEALER.*AK
NHTSA ODI #8014223
Mileage unknown · Jun 17, 2000
Power TrainUnknown Or Other
WHILE TRAVELING UP THE INTERSTATE EXPERIENCED SUDDEN TRANSMISION SLIPPAGE,AND ENGINE CHECK LIGHT CAME ON.AFTER MANUEVERING TO THE SHOULDER OF THE ROAD I CHECKED THE TRANSMISION FLUID LEVEL WHICH WAS GOOD AND ALSO CHECKED THE DIAGNOSTIC TROUBLE CODE(MIL CODE 45).TRIED TO START OFF AND THE TRANSISSION SLIPPED VERY BAD BUT FINALLY…
Read full complaint
WHILE TRAVELING UP THE INTERSTATE EXPERIENCED SUDDEN TRANSMISION SLIPPAGE,AND ENGINE CHECK LIGHT CAME ON.AFTER MANUEVERING TO THE SHOULDER OF THE ROAD I CHECKED THE TRANSMISION FLUID LEVEL WHICH WAS GOOD AND ALSO CHECKED THE DIAGNOSTIC TROUBLE CODE(MIL CODE 45).TRIED TO START OFF AND THE TRANSISSION SLIPPED VERY BAD BUT FINALLY STAYED IN SECOND GEAR ALLOWING ME TO RETURN HOME.I UNDERSTAND THAT THIS IS NOT AN ISOLATED ISSUE,THERE HAVE BEEN MANY DODGE CARAVAN OWNERS WHO HAVE EXPERIENCED SIMILAR TRANSMISSION PROBLEMS. I AM CURRENTLY TRYING TO SEE IF THIS IS A CURRENT RECALL ISSUE OR IF THERE ARE ANY PARTICULAR STEPS THAT I COULD TAKE TO TRY TO HELP IT BECOME A RECALL ISSUE. *AK
NHTSA ODI #724134
Mileage unknown · Sep 13, 1998
Power TrainUnknown Or Other
AUTOMATIC TRANSMISSION SHIFTING PROBLEMS.
NHTSA ODI #540844
Mileage unknown · Sep 13, 1998
Power TrainUnknown Or Other
UNSPECIFIED.
NHTSA ODI #540843
Mileage unknown · Feb 12, 1998
Unknown Or Other
UNSPECIFIED.
NHTSA ODI #530774
Mileage unknown · Jul 25, 1997
Fuel System, GasolineUnknown Or Other
FUEL TANK: FUEL TANK LEAKS WHEN IT IS FULL, IT DOES NOT LEAK WHEN IT IS NOT COMPLETELY FULL. CHECK ENGINE LIGHT COMES ON AND STAYS. DEALER HAS REPLACED FUEL PUMP ON GAS TANK, AND THE THEY ALSO REPLACED THE FUEL INJECTOR PUMP ON THE ENGINE . THE PROBLEM IS STILL THERE.THE ARE GOING TO REPLACE THE ENTIRE TANK ASSEMBLY. *AK
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEEL. THE TIRES CAN EXPERIENCE A SUDDEN AIR PRESSURE LOSS WITHOUT WARNING.
Consequence & remedy
Consequence: SUDDEN TIRE FAILURE COULD RESULT IN A LOSS OF DRIVER CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIRES THAT WERE MOUNTED ON STEEL WHEELS.
THE MASTER CYLINDER REAR SEAL, BETWEEN THE HYDRAULIC FLUID AND THE VACUUM RESERVOIR, MAY NOT SEAL ADEQUATELY ALLOWING HYDRAULIC FLUID TO BE DRAWN INTO THE POWER ASSIST VACUUM RESERVOIR.
Consequence & remedy
Consequence: AS THE HYDRAULIC FLUID IN THE MASTER CYLINDER RESERVOIR DECREASES, THE LEVEL SENSOR WILL DETECT THE LOSS OF FLUID AND ILLUMINATE THE INSTRUMENT PANEL BRAKE WARNING LAMP. CONTINUED OPERATION OF THE VEHICLE WITH THE WARNING LAMP ILLUMINATED CAN RESULT IN EXTENDED STOPPING DISTANCES.
Remedy: DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER ON ALL AFFECTED VEHICLES. ADDENDUM (4-14-97): VEHICLES INSPECTED PER CHRYSLER RECALL NO. 707 AND FOUND TO BE OUTSIDE THE LISTED SUSPECT MASTER CYLINDER DATE CODE RANGE, MUST NOW HAVE THE MASTER CYLINDER PRIMARY PISTON REPLACED (CHRYSLER RECALL NO. 714).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
1997 Dodge Grand Caravan Problems, Complaints & Recalls | Skip That Year
Illustration