1997 Dodge Grand Caravan

MY VAN WAS PARKED OUT SIDE LUCKYS ON MITALDA NEAR W MAUDE AVENUE IN SUNNYVALE CA 94086 I WAS USING THE WATER REFILLING STATION AND STARTED TO SMELL SMOKE WHEN I TURNED AROUND I IMIDEATLLY NOTICED THAT THE DRIVERS SIDE REAR TAILLIGHT WAS ON FIRE. NOT HAVING A FIRE EXTINGUISHER I TOOK THE BOTTLE OF WATER I HAD IN MY HANDS AND STARTED TO THROW WATER ON IT UNTIL THE FLAMES WENT OUT. WHAT IN THE HELL WOULD MAKE THAT HAPPEN? IS MY VAN UP FOR RECALL? I JUST PURCHASED THE VAN JUST A WEEK AGO. IT HAS BEEN A NIGHT MARE FOR ME NOT TO MENTION EXTREMELY COSTLY REPLACING EVERYTHING'S THAT'S BEEN GOING OUT. THE A/C CLUSTER THE DASH CLUSTER THE POWER WINDOW MOTOR. THE REAR VENT MOTOR. COUNTLESS BULBS AND FUSES.

TL* THE CONTACT OWNS A 1997 DODGE GRAND CARAVAN. WHILE DRIVING AT 62 MPH, THE VEHICLE STALLED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE INSTRUMENT CLUSTER AND THE BODY CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 77,000.

THIS IS ACTUALLY MY MOTHER'S VAN AND A VAN THAT I HAD PREVIOUSLY OWNED. IT SEEMS THAT THESE VEHICLES SEEM TO HAVE A PROBLEM WITH THE SECURITY SYSTEM NOT DISARMING AS YOU TRY TO ENTER THE VEHICLE. YOU CAN UNLOCK THE DOORS FROM THE OUTSIDE, BUT AS SOON AS YOU GET IN THE VEHICLE AND TRY TO START IT, IT IMMEDIATELY SHUTS BACK DOWN AS A SECURITY PRECAUTION. A SIMPLE SMACK ON THE DASH CURES IT RIGHT UP, BUT BEING AS HOW IT'S MY MOTHER'S VAN NOW; SHE DOESN'T HAVE THE STRENGTH TO SIMPLY "SMACK" THE DASH AND GET EVERYTHING WORKING AGAIN. IT SEEMS AS THOUGH, THIS IS NOT THE ONLY KNOWN ISSUE. I HAVE READ ABOUT IT THROUGH SEVERAL DIFFERENT PEOPLE AND HAVE EXPERIENCED IT MYSELF ON TWO SEPARATE VANS. I HONESTLY BELIEVE THAT DAIMLER/CHRYSLER SHOULD ADDRESS THIS ISSUE AND NOT HAVE THE CONSUMER FIX IT, SEEING AS HOW IT IS AND ISSUE THAT'S BURIED IN THE DASHBOARD AND NOT OUT IN PLAIN SIGHT, LIKE SOME MECHANICAL ISSUES. THEY FIXED THE PROBLEM WITH THE CLOCK SPRING IN THE STEERING WHEEL, BECAUSE IT COULD SET OFF THE AIRBAG AT ANY GIVEN MOMENT. WELL, WITH ME HAVING TO SMACK THE DASH SEVERAL DIFFERENT TIMES, HER SPEEDOMETER IS OFF BY 50 MPH NOW. I AM HOPING FOR A RECALL NOTICE ON THIS ISSUE, DUE TO THE FACT THAT ONE MORE GOOD WHACK COULD SET OFF THE AIRBAG AND REALLY INJURY SOMEBODY. THANK YOU. *TR

I PURCHASED MY 1997 DODGE GRAND CARAVAN FROM A PRIVATE PARTY IN 2009, AND SHORTLY AFTER THE GAUGE CLUSTER STOPPED FUNCTIONING WHILE I WAS DRIVING. CHECK ENGINE AND ABS LIGHTS CAME ON WHICH ON CHECKING WITH MY MECHANIC SAID MY ABS SYSTEM IS NON-FUNCTIONAL AS IS ALL OTHER INSTRUMENT RELATED READINGS. A SHORT TIME LATER, THE PANEL CAME BACK ON AND WORKED FOR AWHILE THAN SHUT OFF AGAIN. SOMEONE SAID HIT THE PANEL FACE AND THE GAUGES SHOULD COME BACK ON. I DID AND IT DID. FOR AWHILE. OVER TIME THE GAUGE FAILURE INTERVAL GREW SHORTER AND SHORTER, AND HITTING THE PANEL FINALLY FAILED TO RETURN THE USE OF THE GAUGES. TO REPLACE THIS GAUGE CLUSTER IS AN $800.00 PLUS REPAIR IN A SHOP WITH A REBUILD PANEL COSTING OVER $200.00 BY ITSELF. I DON'T WANT TO KNOW WHAT A DEALER WILL CHARGE. UPON FURTHER INVESTIGATION, I HAVE LEARNED THE GAUGE FAILURE CULPRIT IS COLD SOLDER JOINTS ON THE BACK SIDE OF THE CIRCUIT BOARD OF THE GAUGE CLUSTER AND IS AN ALL TOO COMMON PROBLEM WITH THIS CLASS OF VEHICLE. THIS DEFICIENCY CAN EASILY BE AVOIDED BY BETTER QUALITY CONTROL FROM THE MANUFACTURER. *TR

CAR HAS FAULTY GAS GAUGE AND DESPITE HOW MUCH GAS I PUT IN, WILL TOGGLE BETWEEN HAVING GAS TO EMPTY AND SITS ON EMPTY, HAS RUN OUT OF GAS AS A RESULT, HARD TO START AND NOW WILL NOT START. ALSO HAS MANY ELECTRICAL QUIRKS, TURN HEADLIGHTS ON INBOARD DASH LIGHT GOES OFF AND VICE VERSA. HAD SOMEONE FIX FAN TO GO ON WHEN PLUGGED INTO BATTERY SINCE CANNOT GET INTO COMPUTER DASHBOARD AND INTERNAL HEAT FAN STOPPED WORKING, ALSO INDICATORS WORK SPORADICALLY (SO EVIDENTLY AN ELECTRICAL COMMUNICATIONS ISSUE). I'VE READ THAT THIS YEAR HAS HAD RECALLS DUE TO FAULTY FUEL HOSES/LINES AND WHEN USING AFTER MARKET FUEL FILTERS EVEN FROM NAPA WHICH WILL CAUSE FUEL LINES TO BECOME FAULTY. MY VAN FALLS WITHIN THIS YEAR, BUT I WAS TOLD MY SPECIFIC VIN # DIDN'T APPLY. VAN IS 3.3 LITER ENGINE, V6. *TR

TL* THE CONTACT OWNS A 1997 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING AT THE SPEEDS OF 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A LOCAL AUTOMOTIVE STORE, WHERE IT WAS DIAGNOSED THAT THE COIL PACK MALFUNCTIONED. THE DEALER WAS NOTIFIED AND THEY COULD NOT ASSIST THE CONTACT WITH THE FAILURE OF THE COIL PACK. THE VEHICLE EXPERIENCED THIS FAILURE A TOTAL OF SIX TIMES AND IT WAS REPAIRED. THE FAILURE MILEAGE WAS 122,000 AND THE CURRENT MILEAGE WAS 130,000. UPDATED 03/05/12*LJ UPDATED 03/08/12

MY VAN WILL SHUT OFF AND COME BACK ON WITHOUT WARNING SO LONG AS YOUR FOOT IS ON THE GAS. IF YOU ARE COMING TO A STOP IT WILL SHUT DOWN COMPLETELY BUT WILL RESTART. THE CHECK ENGINE LIGHT WILL COME ON AND IMMEDIATELY GO BACK OUT WITH NO CODES STORED. THE CRANK AND CAM SENSOR HAVE BOTH BEEN REPLACE BY THE DEALER BUT DIDN'T SOLVE THE PROBLEM. THIS IS DANGEROUS WHEN GOING INTO A CORNER OR THROUGH AN INTERSECTION WHEN IT COMPLETELY SHUTS DOWN. THIS STARTED IN 2006 AND IS STILL GOING ON. *TR

TL*THE CONTACT OWNS A 1997 DODGE GRAND CARAVAN. WHENEVER THE CONTACT SHIFTS, THE VEHICLE MAKES AN UNFAMILIAR NOISE. WHEN THE VEHICLE IS PARKED, IT OPERATES NORMALLY. THE TRANSMISSION STALLS AND WILL START BACK UP, BUT IT IS UNRELIABLE. THE VEHICLE WOULD REV AND HAVE TO BE RESTARTED IN ORDER FOR THE REVVING TO STOP. IF THERE IS A POWER FLUCTUATION, THE REAR WIPERS WILL TURN ON AND OFF AT RANDOM. THE HIGH BEAMS ON THE HEADLIGHTS DO NOT WORK, BUT THE FAILURE WAS REPAIRED. THE PARKING LIGHT ON THE FRONT DRIVER'S SIDE FAILED. HE REPLACED THE BULB, BUT IT STILL DOES NOT WORK. THE CONTACT STATED THAT HE IS CONSTANTLY REPLACING THE LOW BEAM LIGHTS. THE SERPENTINE BELT SLIPS OFF; HOWEVER, IT HAS BEEN REPAIRED. THE CHECK ENGINE LIGHT FLASHES ON AND OFF AND THERE IS A BURNING ELECTRICAL SMELL COMING FROM THE VEHICLE. THE FRONT STRUT ASSEMBLY IS RUSTING AND ROTTING. THE ROCKER PANEL ON THE DRIVER'S SIDE IS RUSTED COMPLETELY. THE CURRENT MILEAGE WAS 186,000 AND FAILURE MILEAGE WAS 149,766. UPDATED 09/10/08 *BF UPDATED 09/11/08.*JB

1997 GRAND CARAVAN SE - REPEATED INTERMITTENT FAILURE OF DASH GAUGES. WHEN THIS OCCURS, NO FEEDBACK FROM CAR ON SPEED OR GAS LEVEL. THIS IS A DANGEROUS CONDITION. ADDITIONALLY, THERE IS OCCASIONAL STALLING. MULTIPLE OTHER CONSUMERS APPEAR TO HAVE SAME PROBLEMS. SEE HTTP://WWW.AUTOMOTIVEFORUMS.COM/T220421.HTML FOR POSTINGS. THE MECHANIC DID NOT FIX, WOULD APPARENTLY HAVE TO THROW PARTS AT IT (LIKE MANY OF THE CONSUMERS DESCRIBED IN THE ABOVE POSTING WITHOUT SUCCESS). THANK YOU. *TR