NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
13 reportsClear category filter217,000 miles · Sep 18, 2023
Engine
The contact owns a 2001 Dodge Durango. The contact stated that upon start of the vehicle; an abnormal clanking sound was coming from the vehicle. An independent mechanic was notified of the failure and informed the contact that the failure was most likely related to a defective rod bearing. Neither the dealer nor the manufacture…
Read full complaint
The contact owns a 2001 Dodge Durango. The contact stated that upon start of the vehicle; an abnormal clanking sound was coming from the vehicle. An independent mechanic was notified of the failure and informed the contact that the failure was most likely related to a defective rod bearing. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 217,000.
NHTSA ODI #11545147
195,922 miles · Dec 11, 2017
Engine
TL* THE CONTACT OWNS A 2001 DODGE DURANGO. WHILE DRIVING 5 MPH, THE VEHICLE MADE AN UNUSUAL NOISE WHEN MAKING A TURN AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 195,922.
NHTSA ODI #11053923
134,000 miles · Sep 15, 2016
EngineExterior LightingSuspension
TL* THE CONTACT OWNS A 2001 DODGE DURANGO. WHILE DRIVING VARIOUS SPEEDS AND MAKING A RIGHT TURN, THE VEHICLE PULLED TO THE RIGHT AND A CRACKING SOUND WAS HEARD FROM THE FRONT SUSPENSION. THE CONTACT INDICATED THAT THE CRACKING NOISE WAS CAUSED BY FAULTY BALL JOINTS. IN ADDITION, THE BRAKE LIGHTS WOULD NOT ILLUMINATE AND THE LIGH…
Read full complaint
TL* THE CONTACT OWNS A 2001 DODGE DURANGO. WHILE DRIVING VARIOUS SPEEDS AND MAKING A RIGHT TURN, THE VEHICLE PULLED TO THE RIGHT AND A CRACKING SOUND WAS HEARD FROM THE FRONT SUSPENSION. THE CONTACT INDICATED THAT THE CRACKING NOISE WAS CAUSED BY FAULTY BALL JOINTS. IN ADDITION, THE BRAKE LIGHTS WOULD NOT ILLUMINATE AND THE LIGHT BULB AND SOCKET WAS REPLACED ON SEVERAL DIFFERENT OCCASIONS. ALSO, THE PLENUM GASKET LEAKED OIL FROM THE ENGINE, WHICH CAUSED THE ENGINE TO LOSE POWER. THE CAUSE OF THE FAILURES WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 134,000.
NHTSA ODI #10906880
Mileage unknown · May 31, 2016
Electrical SystemEngineExterior Lighting
ONE DAY I WAS OUT SHOPPING PARKED MY CAR GOT OUT TRIED TO LOCK DOORS THEY WOULD LOCK UNLESS I MANUALLY DID IT. THE NEXT DAY I NOTICED MY HEADLIGHTS, INSIDE LIGHTS, WINDSHIELD WIPERS, AND VOLUME CONTROL ON STARING WHEEL WOULD NOT WORK. THAT SAME DAY WHEN I STARTED MY CAR IT STARTED GREAT AS ALWAYS BUT THERE WAS A CLICKING NOISE O…
Read full complaint
ONE DAY I WAS OUT SHOPPING PARKED MY CAR GOT OUT TRIED TO LOCK DOORS THEY WOULD LOCK UNLESS I MANUALLY DID IT. THE NEXT DAY I NOTICED MY HEADLIGHTS, INSIDE LIGHTS, WINDSHIELD WIPERS, AND VOLUME CONTROL ON STARING WHEEL WOULD NOT WORK. THAT SAME DAY WHEN I STARTED MY CAR IT STARTED GREAT AS ALWAYS BUT THERE WAS A CLICKING NOISE ON THE DRIVER SIDE BY THE FRONT WHEEL. I TOOK IT TO MIDAS THEY DIAGNOSED IT AND FIXED IT, 3 DAYS LATER MY CAR DID THE SAME THING HE TOLD ME TO TAKE IT TO THE DODGE DEALER. I'VE TRIED THEY WONT CALL BACK! NOW THERE IS A RED SECURITY LIGHT THAT CAME ON AND WONT GO OFF EVEN WHEN THE CAR ENGINE IS OFF. AFTER 4 DAYS OF MY CAR BEING PARKED WITH THE SECURITY LIGHT ON MY CAR IS NOW DEAD. I'VE READ ONLINE THAT ITS A ALARM SYSTEM AND I NEED A KEY TO PROGRAM IT. I BOUGHT MY CAR USED FROM THE DEALER AND DID NOT RECEIVE AN ALARM KEY, ALARM KEY PAD OR EVEN A SPARE KEY FIR MY CAR. I SEE A LOT OF REVIEWS ONLINE ABOUT THIS ISSUE, THIS HAS BEEN GOING ON FOR 1 MONTH OR LONGER NOW. I BELIEVE ITS A FACTORY ISSUE. IM STILL GOING TO CONTACT THE DEALER AND GET AN APPOINTMENT TO GET Y CAR FIXED.
NHTSA ODI #10871558
212,282 miles · Mar 30, 2016
Engine
TL* THE CONTACT OWNS A 2001 DODGE DURANGO. WHILE DRIVING 55 MPH, AN UNKNOWN LIQUID SPLASHED ONTO THE WINDSHIELD BEFORE THE THERMOSTAT GAUGE INDICATED THAT THE VEHICLE WAS OVERHEATING. THE CONTACT PULLED OVER AND OBSERVED UNDER THE HOOD THAT THE COOLANT WAS LOW. THE COOLANT WAS REFILLED, BUT THE FAILURE RECURRED INTERMITTENTLY. T…
Read full complaint
TL* THE CONTACT OWNS A 2001 DODGE DURANGO. WHILE DRIVING 55 MPH, AN UNKNOWN LIQUID SPLASHED ONTO THE WINDSHIELD BEFORE THE THERMOSTAT GAUGE INDICATED THAT THE VEHICLE WAS OVERHEATING. THE CONTACT PULLED OVER AND OBSERVED UNDER THE HOOD THAT THE COOLANT WAS LOW. THE COOLANT WAS REFILLED, BUT THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FAN CLUTCH, ELECTRIC FAN, RADIATOR CAP, SERPENTINE BELT, AND THERMOSTAT WERE REPLACED. THE REMEDY FAILED TO REPAIR THE VEHICLE. THE CAUSE OF THE FAILURE WAS NOT FOUND. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 212,282.
NHTSA ODI #10852579
156,000 miles · Sep 24, 2015
Engine
INTAKE OR EXHAUST VALVE FELL OUT OF # 2 CYLINDER .FAULTY VALVE SEATS ACCORDING TO THE ENGINE COMPANY, THE ORIGINAL CHRYSLER DESIGN PRESSES THE VALVE SEATS INTO THE CYLINDER HEADS. THE PROBLEM RESULTS WHEN THE POWDERED METAL THE VALVE SEATS ARE MADE OF EXPANDS, CAUSING IT TO DROP INTO CONTACT WITH THE VALVE AND PISTONS, WHI…
Read full complaint
INTAKE OR EXHAUST VALVE FELL OUT OF # 2 CYLINDER .FAULTY VALVE SEATS ACCORDING TO THE ENGINE COMPANY, THE ORIGINAL CHRYSLER DESIGN PRESSES THE VALVE SEATS INTO THE CYLINDER HEADS. THE PROBLEM RESULTS WHEN THE POWDERED METAL THE VALVE SEATS ARE MADE OF EXPANDS, CAUSING IT TO DROP INTO CONTACT WITH THE VALVE AND PISTONS, WHICH LEADS TO CATASTROPHIC FAILURE. IN THIS PROCESS THE SEAT BREAKS INTO MANY PIECES CAUSING DETERIORATION OF THE PISTON, CYLINDER WALL, VALVE AND CYLINDER HEAD. HTTP://WWW.TORQUENEWS.COM/397/TWO-FATAL-FLAWS-RUINING-CHRYSLER-ENGINES-CATASTROPHIC-BREAKDOWNS
NHTSA ODI #10776473
123,000 miles · Apr 9, 2015
EnginePower Train
CAR IDLES FAST WHEN IN PARK. RPM NEEDLES ALSO REACTS. WHEN DRIVING CAR APPEARS AS IF TRANSMISSION ISN'T WORKING. UPON ACCELERATION THE CAR APPEARS AS IF IT'S ABOUT TO STOP. WHEN IT DOES ACCELERATE IT REACTS VERY SLUGGISH.. THOUGHT TRANNY WAS BAD, BUT WAS INFORMED TRANNY. TOOK IN FOR A TUNE-UP, WAS TOLD ONLY SPARK PLUGS MAY NEED…
Read full complaint
CAR IDLES FAST WHEN IN PARK. RPM NEEDLES ALSO REACTS. WHEN DRIVING CAR APPEARS AS IF TRANSMISSION ISN'T WORKING. UPON ACCELERATION THE CAR APPEARS AS IF IT'S ABOUT TO STOP. WHEN IT DOES ACCELERATE IT REACTS VERY SLUGGISH.. THOUGHT TRANNY WAS BAD, BUT WAS INFORMED TRANNY. TOOK IN FOR A TUNE-UP, WAS TOLD ONLY SPARK PLUGS MAY NEED REPLACED. DID ONLINE RESEARCH TO DISCOVER SEVERAL OTHERS HAVING SAME TROUBLE. ON-LINE FEEDBACK SUGGESTED POSSIBLE TPS PROBLEM OR NEEDED TO REPLACE IDLE SPEED CONTROL MODULE. MY HUSBAND AND I ARE BOTH ON FIXED INCOMES AND DON'T HAVE MONEY TO PAY FOR "IT COULD BE". WE NEED A DEFINITE ANSWER TO OUR TROUBLE SO WE CAN PROPERLY REPAIR IT. WE USE THIS VEHICLE TO TRANSPORT OUR GRANDKIDS IN AS WELL AS USE IT FOR VACATIONS. PLEASE HELP!!! WE NEED AN ANSWER ASAP. *TR
NHTSA ODI #10704676
180,000 miles · Jan 27, 2015
Engine
THE ENGINE CONTINUE TO LEAK OIL NEAR THE HEAD GASKET AND THERE IS WATER COMING OUT OF THE TAIL PIPE AND CONTINUE TO LEAK COOLANT. CAN NOT DRIVE LONG DISTANCE WITHOUT LOOSING THE COOLANT. HAD TO BE TOWED OFF THE FREEWAY DUE TO THIS HAPPENING. I WAS TOLD NEED POSSIBLE NEW ENGINE AND THIS IS PROBLEM WITH DODGE ENGINE. *TR
NHTSA ODI #10679134
215,905 miles · Nov 13, 2014
Air BagsEnginePower TrainCrashInjury
THE OTHER DRIVER WAS AT A STOP AND I WAS DRIVING BETWEEN 50 AND 55 MPH ON THE HIGHWAY. THE OTHER DRIVER PULLED OUT INFRONT OF ME FROM MY LEFT TO RIGHT. AS WE IMPACTED MY AIR BAG DID NOT DEPLOY BUT THE PASSENGER'S AIR BAG DID DEPLOY. I WAS THE ONLY PERSON IN MY CAR. I STRUCK HIM WITH SUCH FORCE THAT THE VEHICLE I W…
Read full complaint
THE OTHER DRIVER WAS AT A STOP AND I WAS DRIVING BETWEEN 50 AND 55 MPH ON THE HIGHWAY. THE OTHER DRIVER PULLED OUT INFRONT OF ME FROM MY LEFT TO RIGHT. AS WE IMPACTED MY AIR BAG DID NOT DEPLOY BUT THE PASSENGER'S AIR BAG DID DEPLOY. I WAS THE ONLY PERSON IN MY CAR. I STRUCK HIM WITH SUCH FORCE THAT THE VEHICLE I WAS DRIVING WAS FORCED OFF THE ROAD AND THEN WAS STOPPED BY A TREE. AFTER 2 HITS THE DRIVER'S SIDE AIR BAG STILL DID NOT DEPLOY. THE VEHICLE WAS DEEMED A TOTAL LOSS. *TR
NHTSA ODI #10654748
160,000 miles · Jun 17, 2014
Engine
TL* THE CONTACT OWNS A 2001 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING 40MPH, A LOUD KNOCKING AND METAL SOUND EMITTED AS THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE ENGINE TO FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. TH…
Read full complaint
TL* THE CONTACT OWNS A 2001 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING 40MPH, A LOUD KNOCKING AND METAL SOUND EMITTED AS THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE ENGINE TO FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 160,000. .... UPDATED 08/05/14 *BF UPDATED 08/18/2014 *JS
NHTSA ODI #10598782
Official recalls
5Dec 4, 2007
ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK" POSITION). THIS CAN ALSO ALLOW THE IGNITION KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE "PARK" POSITION.
Consequence & remedy
Consequence: EITHER OF THESE CONDITIONS COULD ALLOW THE VEHICLE TO ROLL AWAY CAUSING A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE GEARSHIFT BLOCKER AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Sep 7, 2006
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH FRONT BENCH SEATS ONLY, IF FLUID IS SPILLED FROM THE FLOOR MOUNTED CUP HOLDER, AN UNUSED CONSOLE POWER OUTLET CONNECTOR LOCATED UNDER THE SEAT MAY BECOME CONTAMINATED.
Consequence & remedy
Consequence: THIS MAY ALLOW DEVELOPMENT OF A HIGH RESISTIVE SHORT CIRCUIT IN THE CONNECTOR, WHICH COULD EVENTUALLY LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT THE CONSOLE WIRING CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT ADDITIONAL FLUID FROM CONTAMINATING THE CONNECTOR FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 30, 2006. OWNERS MAY CONTACT DAIMLER CHRYSLER AT 1-800-853-1403.
Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Mar 7, 2001
VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH 4-WHEEL DRIVE. THE ELECTRIC SHIFT TRANSFER CASE MAY NOT FULLY ENGAGE INTO GEAR WHEN THE OPERATOR MOVES THE TRANSFER CASE SELECTOR SWITCH.
Consequence & remedy
Consequence: THIS COULD CAUSE THE TRANSFER CASE TO END UP IN THE NEUTRAL POSITION UNEXPECTEDLY AND ALLOW THE VEHICLE TO ROLL AWAY IF THE PARKING BRAKE IS NOT APPLIED.
Remedy: DEALERS WILL REPROGRAM THE TRANSFER CASE CONTROL MODULE. OWNER NOTIFICATION BEGAN APRIL 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Nov 9, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA06011 · Vehicle UNDER-SEAT Fire
Opened Jun 19, 2006 · Closed Sep 22, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring
DAIMLERCHRYLSER CORPORATION (DCC) WILL RECALL 35,103 MY 2001-2003 DODGE DURANGO VEHICLES EQUIPPED WITH FRONT BENCH SEATS (RECALL # 06V339, SEE DEFECT REPORT FOR DETAILS).THE SUBJECT VEHICLES ARE EQUIPPED WITH EITHER FRONT BUCKET SEATS OR A 40-20-40 SPLIT FRONT BENCH SEAT.VEHICLES EQUIPPED WITH FRONT BENCH SEAT CONTAIN AN UNCAPPED, UNUSED CONNECTOR LOCATED UNDER THE FRONT EDGE OF THE SEAT.THE CONNECTOR PROVIDES POWER TO THE CENTER CONSOLE POWER OUTLET FOR VEHICLES WITH BUCKET SEATS, BUT IT IS UNUSED IN VEHICLES EQUIPPED WITH BENCH SEATS.THE CONNECTOR IS LOCATED REARWARD OF THE CUP HOLDER ON THE TUNNEL FOR VEHICLES EQUIPPED WITH THE BENCH SEAT.THIS CONNECTOR CONTAINS A FUSED B+ CIRCUIT WIRE (THAT IS CONTINUOUSLY POWERED WITH THE KEY OFF) AND A GROUND WIRE. DCC DETERMINED THAT IF LIQUID IS SPILLED FROM THE CUP HOLDER ONTO THE TUNNEL, THE UNCAPPED CONNECTOR MAY BECOME CONTAMINATED.THIS CONTAMINATION MAY ALLOW DEVELOPMENT OF A HIGH RESISTANCE SHORT CIRCUIT IN THE CONNECTOR, CAUSING LOCALIZED HEATING, WHICH COULD EVENTUALLY LEAD TO A FIRE.DCC WILL INSPECT THE UNCAPPED CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT LIQUID CONTAMINATION.ALL OF THE REPORTED UNDER-SEAT FIRES WERE ON SUBJECT VEHICLES WITH A 40-20-40 BENCH SEAT.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System
DAIMLERCHRYLSER CORPORATION (DCC) WILL RECALL 35,103 MY 2001-2003 DODGE DURANGO VEHICLES EQUIPPED WITH FRONT BENCH SEATS (RECALL # 06V339, SEE DEFECT REPORT FOR DETAILS).THE SUBJECT VEHICLES ARE EQUIPPED WITH EITHER FRONT BUCKET SEATS OR A 40-20-40 SPLIT FRONT BENCH SEAT.VEHICLES EQUIPPED WITH FRONT BENCH SEAT CONTAIN AN UNCAPPED, UNUSED CONNECTOR LOCATED UNDER THE FRONT EDGE OF THE SEAT.THE CONNECTOR PROVIDES POWER TO THE CENTER CONSOLE POWER OUTLET FOR VEHICLES WITH BUCKET SEATS, BUT IT IS UNUSED IN VEHICLES EQUIPPED WITH BENCH SEATS.THE CONNECTOR IS LOCATED REARWARD OF THE CUP HOLDER ON THE TUNNEL FOR VEHICLES EQUIPPED WITH THE BENCH SEAT.THIS CONNECTOR CONTAINS A FUSED B+ CIRCUIT WIRE (THAT IS CONTINUOUSLY POWERED WITH THE KEY OFF) AND A GROUND WIRE. DCC DETERMINED THAT IF LIQUID IS SPILLED FROM THE CUP HOLDER ONTO THE TUNNEL, THE UNCAPPED CONNECTOR MAY BECOME CONTAMINATED.THIS CONTAMINATION MAY ALLOW DEVELOPMENT OF A HIGH RESISTANCE SHORT CIRCUIT IN THE CONNECTOR, CAUSING LOCALIZED HEATING, WHICH COULD EVENTUALLY LEAD TO A FIRE.DCC WILL INSPECT THE UNCAPPED CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT LIQUID CONTAMINATION.ALL OF THE REPORTED UNDER-SEAT FIRES WERE ON SUBJECT VEHICLES WITH A 40-20-40 BENCH SEAT.THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
DAIMLERCHRYLSER CORPORATION (DCC) WILL RECALL 35,103 MY 2001-2003 DODGE DURANGO VEHICLES EQUIPPED WITH FRONT BENCH SEATS (RECALL # 06V339, SEE DEFECT REPORT FOR DETAILS).THE SUBJECT VEHICLES ARE EQUIPPED WITH EITHER FRONT BUCKET SEATS OR A 40-20-40 SPLIT FRONT BENCH SEAT.VEHICLES EQUIPPED WITH FRONT BENCH SEAT CONTAIN AN UNCAPPED, UNUSED CONNECTOR LOCATED UNDER THE FRONT EDGE OF THE SEAT.THE CONNECTOR PROVIDES POWER TO THE CENTER CONSOLE POWER OUTLET FOR VEHICLES WITH BUCKET SEATS, BUT IT IS UNUSED IN VEHICLES EQUIPPED WITH BENCH SEATS.THE CONNECTOR IS LOCATED REARWARD OF THE CUP HOLDER ON THE TUNNEL FOR VEHICLES EQUIPPED WITH THE BENCH SEAT.THIS CONNECTOR CONTAINS A FUSED B+ CIRCUIT WIRE (THAT IS CONTINUOUSLY POWERED WITH THE KEY OFF) AND A GROUND WIRE. DCC DETERMINED THAT IF LIQUID IS SPILLED FROM THE CUP HOLDER ONTO THE TUNNEL, THE UNCAPPED CONNECTOR MAY BECOME CONTAMINATED.THIS CONTAMINATION MAY ALLOW DEVELOPMENT OF A HIGH RESISTANCE SHORT CIRCUIT IN THE CONNECTOR, CAUSING LOCALIZED HEATING, WHICH COULD EVENTUALLY LEAD TO A FIRE.DCC WILL INSPECT THE UNCAPPED CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT LIQUID CONTAMINATION.ALL OF THE REPORTED UNDER-SEAT FIRES WERE ON SUBJECT VEHICLES WITH A 40-20-40 BENCH SEAT.THIS INVESTIGATION IS CLOSED.
PE06008 · Fire Under The Driver's Seat
Opened Feb 2, 2006 · Closed Jun 19, 2006
Status: closed (inferred from source dates) · Electrical System:wiring:interior/under Dash; Seats
ODI IS AWARE OF 10 REPORTS ALLEGING THAT A FIRE ORIGINATES UNDERNEATH THE DRIVER'S SEAT.SIX OF THEFIRES OCCURRED WHILE THE VEHICLE WAS PARKED WITH THE IGNITION SWITCH TURNED OFF (KEY NOT IN THE IGNITION).THE SUBJECT VEHICLES ARE EQUIPPED WITH MANUAL SEATS. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, (EA06-011), TO ALLOW FURTHER INVESTIGATION OF THE ISSUE.
Additional source detail variants (2)
Electrical System:wiring:interior/under Dash
ODI IS AWARE OF 10 REPORTS ALLEGING THAT A FIRE ORIGINATES UNDERNEATH THE DRIVER'S SEAT.SIX OF THEFIRES OCCURRED WHILE THE VEHICLE WAS PARKED WITH THE IGNITION SWITCH TURNED OFF (KEY NOT IN THE IGNITION).THE SUBJECT VEHICLES ARE EQUIPPED WITH MANUAL SEATS. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, (EA06-011), TO ALLOW FURTHER INVESTIGATION OF THE ISSUE.
Seats
ODI IS AWARE OF 10 REPORTS ALLEGING THAT A FIRE ORIGINATES UNDERNEATH THE DRIVER'S SEAT.SIX OF THEFIRES OCCURRED WHILE THE VEHICLE WAS PARKED WITH THE IGNITION SWITCH TURNED OFF (KEY NOT IN THE IGNITION).THE SUBJECT VEHICLES ARE EQUIPPED WITH MANUAL SEATS. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, (EA06-011), TO ALLOW FURTHER INVESTIGATION OF THE ISSUE.
EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE03032 · Front Susp. Upper Ball Joint Failure
Opened Jul 16, 2003 · Closed Nov 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Additional source detail variants (4)
Suspension:front
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
Illustration