NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
302 reports83,530 miles · Aug 23, 2014
Electrical System
WE TURNED THE CAR ON AND THE WINDSHIELD WIPERS, CAR HORN, AND LIGHTS ALL STARTED GOING OFF. WE COULD NOT PUT THE CAR IN DRIVE OR REVERSE. EVEN WHEN WE TURNED THE KEYS TO THE IGNITION OFF POSITION THE WIPERS, HORN, AND LIGHTS CONTINUED TO MOVE AND FLASH AND SOUND. ONLY ONCE WE TOOK THE KEYS OUT OF THE IGNITION DID IT STOP. WH…
Read full complaint
WE TURNED THE CAR ON AND THE WINDSHIELD WIPERS, CAR HORN, AND LIGHTS ALL STARTED GOING OFF. WE COULD NOT PUT THE CAR IN DRIVE OR REVERSE. EVEN WHEN WE TURNED THE KEYS TO THE IGNITION OFF POSITION THE WIPERS, HORN, AND LIGHTS CONTINUED TO MOVE AND FLASH AND SOUND. ONLY ONCE WE TOOK THE KEYS OUT OF THE IGNITION DID IT STOP. WHEN TRIED TO START THE CAR AGAIN BUT THE PROBLEM PERSISTED. WE COULD NOT GET OUR CAR TO DRIVE. *TR
NHTSA ODI #10627663
87,598 miles · Aug 20, 2014
Electrical SystemEngine
THE VAN STOPPED RUNNING LEAVING THE CAR WITH NO POWER TO ANY SYSTEM AND HAD TO TURN THE KEY BACK TO THE ON POSITION TO REGAIN POWER. THIS HAS HAPPENED 3 TIMES IN THE PAST MONTH.
NHTSA ODI #10626538
38,000 miles · Aug 18, 2014
Electrical SystemExterior Lighting
HEAD LIGHTS FLICKERED SEVERAL TIMES AND THEN STAYED OFF. THIS HAS CONTINUED INTERMITTENTLY SINCE NOVEMBER. SOMETIMES THE HEADLIGHTS STAY ON, SOMETIMES THEY DON'T. 8/1/2014-HEADLIGHTS DON'T WORK AT ALL. I HAVE TAKEN TO A DODGE DEALER IN DECEMBER WHO TOLD ME IT WOULD COST $700 BUT COULDN'T GUARANTEE IT WOULDN,T CONTINUE TO HAPPEN.…
Read full complaint
HEAD LIGHTS FLICKERED SEVERAL TIMES AND THEN STAYED OFF. THIS HAS CONTINUED INTERMITTENTLY SINCE NOVEMBER. SOMETIMES THE HEADLIGHTS STAY ON, SOMETIMES THEY DON'T. 8/1/2014-HEADLIGHTS DON'T WORK AT ALL. I HAVE TAKEN TO A DODGE DEALER IN DECEMBER WHO TOLD ME IT WOULD COST $700 BUT COULDN'T GUARANTEE IT WOULDN,T CONTINUE TO HAPPEN. I HAVE TAKEN IT TO 2 PRIVATE GARAGES WHO HAVE TOLD ME THE SAME THING. IT'S NOT THE BULBS. THEY BELIEVE IT IS A PROBLEM IN THE ELECTRICAL SYSTEM. *TR
NHTSA ODI #10626040
168,000 miles · Jul 31, 2014
Engine
TL* THE CONTACT OWNS A 2008 DODGE CARAVAN. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 168,000.
NHTSA ODI #10617964
55,000 miles · Jul 30, 2014
Engine
TL* THE CONTACT OWNS A 2008 DODGE CARAVAN. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE RESTARTED AND PERFORMED NORMALLY. THE FAILURE OCCURRED FIFTEEN TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. …
Read full complaint
TL* THE CONTACT OWNS A 2008 DODGE CARAVAN. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE RESTARTED AND PERFORMED NORMALLY. THE FAILURE OCCURRED FIFTEEN TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.
NHTSA ODI #10617723
131,000 miles · Jul 13, 2014
Engine And Engine Cooling
THE CAR STARTS THEN STALLS, WHEN DRIVING ON 7/6/14 ON 3 SEPARATE OCCASIONS IT STALLED ON INTERSTATE 390 SOUTH. CAUSING COMPLETE POWER FAILURE. *TR
NHTSA ODI #10610185
Mileage unknown · Jul 9, 2014
Electrical SystemEngine And Engine Cooling
2008 DODGE CARAVAN. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH ISSUES. *SMD THE CONSUMER STATED THE VEHICLE WOULD NOT SHUT OFF, WHEN THE KEY WAS REMOVED. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE THEY INSTALLED A TIPM PART AT A COST OF $897. THE DEALER CLAIMED THE PART WOULD MAKE THE ENGINE SHUT OFF. A DAY LATER, THE ENG…
Read full complaint
2008 DODGE CARAVAN. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH ISSUES. *SMD THE CONSUMER STATED THE VEHICLE WOULD NOT SHUT OFF, WHEN THE KEY WAS REMOVED. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE THEY INSTALLED A TIPM PART AT A COST OF $897. THE DEALER CLAIMED THE PART WOULD MAKE THE ENGINE SHUT OFF. A DAY LATER, THE ENGINE WOULD NOT SHUT OFF. HOWEVER, WHEN IT DIDN'T SHUT OFF, THE ENGINE BLEW UP DESTROYING THE ENGINE IN THE PROCESS. THE DEALER ADMITTED THE MISTAKE, OF INSTALLING THE WRONG PART, AND THEY STATED THEY DID NOT KNOW THE ENGINE WOULD NOT SHUT OFF, BUT THEY WERE CERTAIN THAT THE FAILURE, WAS NOT LINKED TO ENGINE BLOWING UP. SOMEHOW THE ENGINE, AND RADIATOR BLOWING UP WAS SIMPLY A COINCIDENCE.*JB
NHTSA ODI #10609371
70,000 miles · Jun 20, 2014
Electrical System
TL *THE CONTACT OWNS A 2008 DODGE CARAVAN. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE IGNITION SWITCH WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE…
Read full complaint
TL *THE CONTACT OWNS A 2008 DODGE CARAVAN. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE IGNITION SWITCH WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 70,000. THE CURRENT MILEAGE WAS 75,000.
NHTSA ODI #10604684
30,000 miles · Jun 18, 2014
Electrical SystemEngine And Engine Cooling
WHILE DRIVING APPROXIMATELY 40 MPH THE VAN HIT A SMALL POTHOLE AND LOST TOTAL POWER. AFTER STEERING TO THE SIDE OF THE ROAD I DETERMINE THE IGNITION KEY WAS NOW IN THE ACCESSORY POSITION. THE SAME ISSUE OCCURRED MULTIPLE TIMES OVER THE COURSE OF THE 7 YEARS I OWNED THE VEHICLE TO THE POINT THAT WHEN MY TEENAGE SONS LEARNED TO DR…
Read full complaint
WHILE DRIVING APPROXIMATELY 40 MPH THE VAN HIT A SMALL POTHOLE AND LOST TOTAL POWER. AFTER STEERING TO THE SIDE OF THE ROAD I DETERMINE THE IGNITION KEY WAS NOW IN THE ACCESSORY POSITION. THE SAME ISSUE OCCURRED MULTIPLE TIMES OVER THE COURSE OF THE 7 YEARS I OWNED THE VEHICLE TO THE POINT THAT WHEN MY TEENAGE SONS LEARNED TO DRIVE I COACHED THEM ON WHAT TO DO WHEN THE CAR TURNED OFF WHILE DRIVING. *TR
NHTSA ODI #10604272
65,000 miles · Jun 16, 2014
Electrical System
REPEATING PROBLEM WITH CAR JUST SHUTTING OFF. HAPPENS MOST OFTEN WHEN MAKING A TURN. DID NOT HAPPEN DURING THE COLD WINTER MONTHS BUT STARTED HAPPENING AGAIN THIS YEAR ONCE SPRING STARTED. *TR
NHTSA ODI #10598520
Official recalls
2Apr 23, 2010
THE BRAUN CORPORATION IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 CHRYSLER TOWN & COUNTRY AND DODGE CARAVAN MOBILITY CONVERSIONS WHICH WERE ALTERED BY BRAUN BETWEEN JANUARY 21, 2009 AND MARCH 19, 2010. DURING CONVERSION, THE CHASSIS WAS RAISED AND THE FLOOR WAS LOWERED TO ACCOMMODATE WHEELCHAIR ACCESSIBILITY FEATURES. IN RAISING THE CHASSIS, THE REAR SPRING HATS COME INTO CLOSER PROXIMITY TO THE REAR TIRES. IN ROUGH OR AGGRESSIVE DRIVING SITUATIONS THE TIRES MAY INTERMITTENTLY CONTACT THE REAR SPRING HATS.
Consequence & remedy
Consequence: CONTACT BETWEEN THE TIRE SPRING HAT MAY WEAR A HOLE IN THE TIRE OVER TIME. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL IN THE EVENT OF TIRE PRESSURE LOSS INCREASING THE RISK OF A CRASH.
Remedy: BRAUN WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN TOLL-FREE AT 1-800-488-0359.
Apr 13, 2010
THE BRAUN CORPORATION IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 CHRYSLER TOWN & COUNTRY AND DODGE CARAVAN COMMERCIAL ENTERVANS WHICH WERE ALTERED BY BRAUN BETWEEN JANUARY 21, 2009 AND MARCH 19, 2010. DURING CONVERSION, THE CHASSIS WAS RAISED AND THE FLOOR WAS LOWERED TO ACCOMMODATE WHEELCHAIR ACCESSIBILITY FEATURES. IN RAISING THE CHASSIS, THE FUEL FILL PIPE COMES INTO CLOSER PROXIMITY TO THE LEFT REAR TIRE. IN ROUGH OR AGGRESSIVE DRIVING SITUATIONS, THE TIRE MAY INTERMITTENTLY CONTACT THE FUEL FILL PIPE.
Consequence & remedy
Consequence: CONTACT BETWEEN THE TIRE AND FUEL FILL PIPE MAY WEAR A HOLE IN ONE OR THE OTHER COMPONENTS OVER TIME. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL IN THE EVENT OF TIRE PRESSURE LOSS, OR A VEHICLE FIRE IN THE EVENT THE FUEL PIPE IS COMPROMISED.
Remedy: BRAUN WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN TOLL-FREE AT 1-800-488-0359.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
Illustration