IllustrationSOMETHING WRONG WITH MY GAS TANK, IT ALWAYS STOPS ME EVEN IF IT'S HALFWAY. THE DRIVER SEAT BELT DOESN'T STAY WELL. THE HOLES WHERE THE ENGINE ALWAYS COMES OFF AND THERE'S A LOT OF SMOKE COMING OUT. THE HEADLINER IS COMING OFF AND THERE'S LIKE A SAND FALLING TO MY KIDS. THE BREAK IS NOT THAT STRONG
2002 Dodge Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Dodge Caravan do not stand out strongly from the model-year median of 182.
About this comparison →How this year compares
Owner complaints by model year
Compare all Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
310–25K
4025–50K
4350–75K
1975–100K
16100–150K
6150K+
155 reports with mileage · 90 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
13 crash reports11 fire reports6 injury reports
Seat Belts complaints
15 reports2002 DODGE CARAVAN. CONSUMER WRITES IN REGARDS TO AIR BAGS MALFUNCTION. *SMD THE CONSUMER STATED HE WAS INVOLVED IN AN ACCIDENT ON AUGUST 9, 2013. THE AIR BAGS FAILED TO DEPLOY EVEN AFTER THE IMPACT, AND THERE WERE POSSIBLE SEAT BELT ISSUES, AS WELL. BECAUSE OF THE FAILURE, HIS WIFE WAS EJECTED FROM THE PASSENGER SIDE OF THE …
Read full complaint
2002 DODGE CARAVAN. CONSUMER WRITES IN REGARDS TO AIR BAGS MALFUNCTION. *SMD THE CONSUMER STATED HE WAS INVOLVED IN AN ACCIDENT ON AUGUST 9, 2013. THE AIR BAGS FAILED TO DEPLOY EVEN AFTER THE IMPACT, AND THERE WERE POSSIBLE SEAT BELT ISSUES, AS WELL. BECAUSE OF THE FAILURE, HIS WIFE WAS EJECTED FROM THE PASSENGER SIDE OF THE VEHICLE, AND DIED TWO DAYS LATER. HAD THE AIR BAGS DEPLOYED, SHE WOULD HAVE REMAINED IN THE VEHICLE AND HAD A GREATER CHANCE OF LIVING. *JB
TL* THE CONTACT OWNS A 2002 DODGE CARAVAN. THE CONTACT STATED THAT THE REAR SEAT BELT WAS SHREDDING AND SHE HAD THEM REPLACED. SEVERAL MONTHS LATER, THE FAILURE WAS EXHIBITED ON THE FRONT SEAT BELTS. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THE DEALER ADVISED THAT THEY NEEDED TO REPLACE ALL OF THE SEAT BELTS AND …
Read full complaint
TL* THE CONTACT OWNS A 2002 DODGE CARAVAN. THE CONTACT STATED THAT THE REAR SEAT BELT WAS SHREDDING AND SHE HAD THEM REPLACED. SEVERAL MONTHS LATER, THE FAILURE WAS EXHIBITED ON THE FRONT SEAT BELTS. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THE DEALER ADVISED THAT THEY NEEDED TO REPLACE ALL OF THE SEAT BELTS AND THE RETRACTORS. THE MANUFACTURER WAS CONTACTED BUT PROVIDED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED.THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 130,000.
THE REAR SEAT BELTS IN OUR 2002 DODGE CARAVAN HAVE STOPPED FUNCTIONING AGAIN. THEY WERE REPLACED IN FEBRUARY 2003, JANUARY 2007 AND ARE GOING IN TO BE REPLACE AGAIN TODAY JULY 2007. THEY DO NOT ENGAGE WHEN PULLED AND THEY DO NOT RETRACT AFTER USE. *TR
DT: THE CONSUMER'S VEHICLE HIT A SEMI TRAILER AT ABOUT 20 MPH AND THE FRONTAL AIRBAGS DID NOT DEPLOY. THE DRIVER TRIED TO BRAKE, AND THE IMPACT WAS IN THE FRONT OF THE VEHICLE. THE BUMPER WAS MOVED BACK 8 INCHES, THE TRANSMISSION, THE COOLER AND RADIATOR WERE BENT OVER THE MOTOR. CONSUMER HAS FILED A COMPLAINT WITH CHRYSLER,…
Read full complaint
DT: THE CONSUMER'S VEHICLE HIT A SEMI TRAILER AT ABOUT 20 MPH AND THE FRONTAL AIRBAGS DID NOT DEPLOY. THE DRIVER TRIED TO BRAKE, AND THE IMPACT WAS IN THE FRONT OF THE VEHICLE. THE BUMPER WAS MOVED BACK 8 INCHES, THE TRANSMISSION, THE COOLER AND RADIATOR WERE BENT OVER THE MOTOR. CONSUMER HAS FILED A COMPLAINT WITH CHRYSLER, AND THEY SENT AN INVESTIGATOR TO SEE THE DAMAGE AND TAKE PICTURES. THE VAN WAS TOTALED. THERE WAS 1 INJURY, THE INJURY WOULD NOT HAD BEEN AS BAD IF THE AIRBAGS WOULD HAVE DEPLOYED. THE PASSENGER SUFFERED INTERNAL INJURIES, BLEEDING, AND BRUISING DUE TO SEAT BELT FAILURE. *AK
VEHICLE AIR BAG LIGHT WOULD STAY ILLUMINATED WHILE DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER INFORMED THE CONSUMER THAT THE PASSENGER'S SEAT BELT TENSION NEEDED REPLACED. *NM *SC
I HAD PURCHASED A 2002 DODGE CARAVAN SE AND IMMEDIATELY AFTER IT WAS BACK IN THE SHOP FOR REPAIRS. I HEARD A NOISE IN THE WINDOW AND THE DODGE PLACE TOLD ME IT WAS NOTHING NOT TO WORRY ABOUT IT. ALSO I HAVE MADE SEVERAL TRIPS TO THE DODGE PLACE FOR THE BRAKES (REPLACED 6 TIMES ) , SLIDING DOOR DOESN'T STAY LATCHED AND ALWAYS S…
Read full complaint
I HAD PURCHASED A 2002 DODGE CARAVAN SE AND IMMEDIATELY AFTER IT WAS BACK IN THE SHOP FOR REPAIRS. I HEARD A NOISE IN THE WINDOW AND THE DODGE PLACE TOLD ME IT WAS NOTHING NOT TO WORRY ABOUT IT. ALSO I HAVE MADE SEVERAL TRIPS TO THE DODGE PLACE FOR THE BRAKES (REPLACED 6 TIMES ) , SLIDING DOOR DOESN'T STAY LATCHED AND ALWAYS SLIDES AND HITS MY CHILDREN WHILE GETTING IN OR OUT OF THE VEHICLE, THE DRIVERS SIDE SEAT BELT COMES UNDONE FOR NO REASON (IT WONT STAY LATCHED), I HAD A FLAT AND THE TIRE JACK BROKE WHILE JACKING UP THE VAN, I WAS STOPPED AT A RED LIGHT AND ALL OF A SUDDEN MY VAN JUST PROCEEDED TO GO AND I NO CONTROL OTHER THAN RUNNING IN A DITCH TO STOP, THE VAN ALWAYS DRIFTS TO THE RIGHT WHEN DRIVING AND DEALER SAID IT NOT FAULTY THAT'S HOW ITS MADE TO DO, I HAD 7 SETS OF TIRES AND THE DEALERSHIP SAID THEY COULDN'T FIND ANYTHING WRONG WITH THIS VEHICLE , I HAD AN ALIGNMENT DONE 4 TIMES BECAUSE OF THE DRIFTING AND TIRES WEARING OUT SO OFTEN, I HAVE HAD THE BALL BEARINGS REPLACED 2 TIMES, I HAD THE AC RECHARGED WITH FREON 2 TIMES IT JUST WOULDN'T KEEP COOL, THE BACK DEFROSTER SOMETIMES DOESN'T DEFROST MAKING IT IMPOSSIBLE TO SEE WHILE DRIVING, BAD SMELL COMING FROM VAN IT SMELLS LIKE A SKUNK AND IT MAKES IT HARD TO BREATHE. *NM
REAR SHOULDER SEAT BELTS DID NOT WORK PROPERLY. THE AUTOMATIC LOCKING RETRACTOR FOR THE SHOULDER BELTS DID NOT LOCK PROPERLY. DEALER EXAMINED THE BELTS AND COULD NOT EXPLAIN WHY THE RETRACTOR DID NOT LOCK. *AK REAR SEAT BELTS DOESN'T LOCK WHEN BRAKES ARE ACTIVATED. *LA
IWOULD LIKE TO PLACE A COMPLAINT ABOUT THE GEN3 SEATBELTS. I JUST READ AN ARTICLE ON THE POSSIBLE DANGER THAT THESE BELTS POSE. WE HAVE A 2002 DODGE CARAVAN AND A 2004 CHRYSLER TOWN & COUNTRY AND IT'S VERY UPSETTING THAT DAIMLER CHRYSLER IS NOT TAKING ACTION. *AK
THE REAR SEAT BELT BUCKLES DO NOT LATCH. *AK THE CONSUMER STATED WHILE DRIVING, THE REAR SEAT BELT WHICH WAS HOLDING A CHILD SAFETY SEAT BECAME UNBUCKLED. *JB *NM
Official recalls
404V531000 · Equipment:electrical:radio/tape Deck/cd Etc.
Nov 2, 2004
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
04V386000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Aug 5, 2004
ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.
Remedy: DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V094000 · Structure
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
01V310000 · Child Seat
Oct 4, 2001
VEHICLE DESCRIPTION: CERTAIN MINI VANS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER MANUALS SUPPLIED WITH THESE VEHICLES DO NOT INDICATE WHICH SEATING POSITIONS ARE EQUIPPED WITH TETHER ANCHORAGES AND CHILD RESTRAINT ANCHORAGE SYSTEMS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH THE NECESSARY CHILD RESTRAINT SYSTEM INFORMATION. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 8, 2001. OWNERS WHO DO NOT RECEIVE THE FREE INFORMATION WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA05009 · Headlight Malfunction
Opened Jun 1, 2005 · Closed May 2, 2006
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
PE05004 · Headlight Malfunction
Opened Feb 2, 2005 · Closed Jun 1, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
PE04049 · Speaker Fire In The Rear Of The Vehicle
Opened Jul 7, 2004 · Closed Nov 5, 2004
Status: closed (inferred from source dates) · Electrical System:wiring: Rear Compartment/trunk; Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System:wiring: Rear Compartment/trunk
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE03012 · Power Steering Hose Failure
Opened Apr 9, 2003 · Closed May 29, 2003
Status: closed (inferred from source dates) · Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid; Steering:hydraulic Power Assist:pump; Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
Additional source detail variants (5)
Steering:hydraulic Power Assist:hose, Piping, And Connections
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:power Steering Fluid
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:pump
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist System
PLEASE SEE ATTACHED REPORT.
Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
PE02068 · Fuel Tank Leak
Opened Sep 24, 2002 · Closed Oct 9, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.