← New search

2012 Chrysler Town And Country

Owner reports · Recalls · Investigations

More warning signs than most Town And Country years

Owner complaints for the 2012 Chrysler Town And Country are substantially higher than the model-year median of 216.5.

About this comparison →

When problems were reported

Mileage at the reported incident

372 reports with mileage · 262 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 395 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

7 crash reports16 fire reports19 injury reports

What owners actually said

634 reports
97,000 miles · Nov 14, 2019
Fuel/propulsion System

CAR WON'T START AT TIMES, AFTER AWHILE FINALLY STARTS, FUEL PUMP WILL CONTINUOUSLY RUN AFTER CAR IS OFF. GETS WORSE WITH COLD WEATHER. IT DID IT A FEW TIMES AFTER WE BOUGHT IT BUT WE LIVED IN FLORIDA AND DIDN'T HAPPEN AGAIN. WE MOVED TO TENNESSEE AND NOW ITS CONSTANTLY MESSING UP. WE REPLACED THE BATTERY AND ALSO THE ELECTRICAL…

Read full complaint

CAR WON'T START AT TIMES, AFTER AWHILE FINALLY STARTS, FUEL PUMP WILL CONTINUOUSLY RUN AFTER CAR IS OFF. GETS WORSE WITH COLD WEATHER. IT DID IT A FEW TIMES AFTER WE BOUGHT IT BUT WE LIVED IN FLORIDA AND DIDN'T HAPPEN AGAIN. WE MOVED TO TENNESSEE AND NOW ITS CONSTANTLY MESSING UP. WE REPLACED THE BATTERY AND ALSO THE ELECTRICAL BODY CONTROL THROTTLE. THINKING THAT WAS IT. LATER TO FIND OUT THAT IT MAYBE THE FUEL RELAY. AND THAT DODGE DURANGO AND JEEP AND ANOTHER VEHICLE WAS RECALLED FOR THIS SAME ISSUE AND YET CHRYSLER HAS NOT RECALLED THE TOWN AND COUNTRY.

NHTSA ODI #11280213

70,000 miles · Nov 13, 2019
Structure

GATE POPS OPEN DUE TO PROBLEM WITH LOCK.

NHTSA ODI #11279770

Mileage unknown · Nov 7, 2019
Seats

FRONT PASSENGER SEAT BELT KEEPS JAMMING AND NOW CAN'T EVEN CONNECT BELT INTO THE LOCKING PART

NHTSA ODI #11278782

Mileage unknown · Nov 7, 2019
Electrical System

SOMETIMES THE VAN WILL START SOMETIMES IT WON'T. YOU GET IN PRESS BRAKE AND PUSH THE PUSH START AND IT WON'T START.

NHTSA ODI #11278616

130,000 miles · Nov 5, 2019
Engine

TL* THE CONTACT OWNS A 2012 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT THE FRONT END OF THE VEHICLE MADE A LOT OF NOISE WHEN AT A STOP. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED AND REPLACED THE FLYWHEEL THAT WAS CRACKED. THE CONTACT WAS UNCERTAIN IF THE DEALER WAS CONTACTED. THE MANUFACTURER WAS MAD…

Read full complaint

TL* THE CONTACT OWNS A 2012 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT THE FRONT END OF THE VEHICLE MADE A LOT OF NOISE WHEN AT A STOP. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED AND REPLACED THE FLYWHEEL THAT WAS CRACKED. THE CONTACT WAS UNCERTAIN IF THE DEALER WAS CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.

NHTSA ODI #11278270

168,000 miles · Oct 31, 2019
Engine

TL* THE CONTACT OWNS A 2012 CHRYSLER TOWN AND COUNTRY. WHILE OPERATING THE VEHICLE, THE CHECK ENGINE SENSOR ILLUMINATED AND SMOKE WAS PRESENT COMING FROM THE ENGINE COMPARTMENT. THE CONTACT STATED THAT THE ENGINE OVERHEATED AND THE VEHICLE BEGAN TO SHAKE AND VIBRATE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIS…

Read full complaint

TL* THE CONTACT OWNS A 2012 CHRYSLER TOWN AND COUNTRY. WHILE OPERATING THE VEHICLE, THE CHECK ENGINE SENSOR ILLUMINATED AND SMOKE WAS PRESENT COMING FROM THE ENGINE COMPARTMENT. THE CONTACT STATED THAT THE ENGINE OVERHEATED AND THE VEHICLE BEGAN TO SHAKE AND VIBRATE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 168,000. THE VIN WAS INVALID.

NHTSA ODI #11277250

123,000 miles · Oct 23, 2019
Electrical SystemEngineFuel/propulsion System

MULTIPLE TIMES THE VEHICLE HAS STALLED AND COMPLETELY SHUT DOWN WHILE IN USE. MY FATHER HAD IT STALL TWICE WHILE ON THE FREEWAY AT FREEWAY SPEEDS. I HAVE RECENTLY HAD THE VEHICLE STALL WHILE IDLING AT STOP LIGHTS AND STOP SIGNS WHEN TRYING TO PROCEED FORWARD. WE ALSO HAD AN ISSUE WHERE WE TOOK THE VEHICLE OUT OF PARK AND INTO…

Read full complaint

MULTIPLE TIMES THE VEHICLE HAS STALLED AND COMPLETELY SHUT DOWN WHILE IN USE. MY FATHER HAD IT STALL TWICE WHILE ON THE FREEWAY AT FREEWAY SPEEDS. I HAVE RECENTLY HAD THE VEHICLE STALL WHILE IDLING AT STOP LIGHTS AND STOP SIGNS WHEN TRYING TO PROCEED FORWARD. WE ALSO HAD AN ISSUE WHERE WE TOOK THE VEHICLE OUT OF PARK AND INTO REVERSE AND USING THE GAS PEDAL WAS NOT PROPELLING THE VEHICLE AT A PROPORTIONAL RATE - AND THEN WHEN PUT BACK IN DRIVE THE SAME THING OCCURRED - THE VEHICLE WAS STILL RUNNING. WE HAD TO PARK, TURN IT OFF, AND RESTART THE VEHICLE WHICH CLEARED THE ISSUE IN THAT MOMENT. THIS IS EXTREMELY DANGEROUS AS THE VEHICLE COMPLETELY TURNS OFF WHILE YOU ARE IN THE MIDDLE OF USING IT! WE HAVE OUR BABIES IN THESE VEHICLES WHILE WE ARE USING THEM! I HAVE READ TOO MANY OTHER ACCOUNTS OF THIS HAPPENING TO OTHER OWNERS WHO ALSO ARE SPENDING THOUSANDS OF DOLLARS FOR MECHANICS TO GO HUNTING FOR SOLUTIONS - MOST OF WHICH DO NOT WORK. THIS IS UNSAFE AND NEEDS TO BE INVESTIGATED AS A LARGER ISSUE WITH THIS VEHICLE. I'M LISTING MY SPEED BELOW AS 5 MPH BECAUSE THAT HAS BEEN A FREQUENT CASE; HOWEVER, ANOTHER DRIVER OF THE VEHICLE HAS EXPERIENCED THIS AT HIGH SPEEDS PREVIOUSLY ON MY VEHICLE.

NHTSA ODI #11270457

Mileage unknown · Oct 20, 2019
Electrical SystemEngineUnknown Or Other

ON OUR 2012 TOWN AND COUNTRY , WE HAD REPLACED TIPM ON 2/18. AFTER REPLACEMENT , VEHICLE WOULD STILL TURN OFF IN MID-DRIVE , NOT TURN ON AT ALL NOR TURNOVER MANY TIMES . I BELIEVE IT'S A HUGE SAFETY ISSUE TO NOT HAVE ANY CODES SHOW UP, THE DEALER AFTER REPLACING TIPM ( PARTS AND LABOR $1400), THEY CAN'T FIND ISSUE WHICH…

Read full complaint

ON OUR 2012 TOWN AND COUNTRY , WE HAD REPLACED TIPM ON 2/18. AFTER REPLACEMENT , VEHICLE WOULD STILL TURN OFF IN MID-DRIVE , NOT TURN ON AT ALL NOR TURNOVER MANY TIMES . I BELIEVE IT'S A HUGE SAFETY ISSUE TO NOT HAVE ANY CODES SHOW UP, THE DEALER AFTER REPLACING TIPM ( PARTS AND LABOR $1400), THEY CAN'T FIND ISSUE WHICH CAUSES A LARGE SAFETY CONCERN AS MY GIRLFRIEND AND CHILDREN ARE LEFT TO DRIVE A VEHICLE THAT CAN INTERMITTENTLY TURN OFF MID DRIVE . IT SEEMS MANUFACTURERS KNOW OF THIS PROBLEM BUT NO RECALLS HAVE BEEN ISSUED NOR A FIX .

NHTSA ODI #11269773

Mileage unknown · Oct 14, 2019
Electrical System

AT FIRST IT USED TO KILL THE BATTERY OVERNIGHT. NOW FAILS TO START. NO WARNING LIGHTS. NO CHECK ENGINE LIGHT ON.

NHTSA ODI #11268272

96,000 miles · Oct 12, 2019
Electrical SystemFuel/propulsion SystemUnknown Or Other

I HAVE BEEN HAVING YEARS OF PROBLEMS WITH THIS VEHICLE. SHORTLY AFTER PURCHING IT IN 2015, THE CLIMATE CONTROL UNIT STARTED (AND CONTINUES) TO TURN ON RANDOMLY WHENEVER IT WANTS TO, THE A/C STOPPED WORKING COMPLETELY, AND THE BLIND SPOT SENSORS ARE ON 100% OF THE TIME. MORE RECENTLY, THE VEHICLE KEPT HAVING TO GET JUMP STARTED E…

Read full complaint

I HAVE BEEN HAVING YEARS OF PROBLEMS WITH THIS VEHICLE. SHORTLY AFTER PURCHING IT IN 2015, THE CLIMATE CONTROL UNIT STARTED (AND CONTINUES) TO TURN ON RANDOMLY WHENEVER IT WANTS TO, THE A/C STOPPED WORKING COMPLETELY, AND THE BLIND SPOT SENSORS ARE ON 100% OF THE TIME. MORE RECENTLY, THE VEHICLE KEPT HAVING TO GET JUMP STARTED EVERY MORNING FOR ABOUT 2 WEEKS UNTIL FINALLY IT WOULDN'T TURN OVER AT ALL. I HAVE REPLACED THE BATTERY 3 TIMES, THE ALTERNATOR TWICE (THE FIRST TIME AFTER THE VEHICLE STALLING OUT ON A MAJOR HIGHWAY A LONG WAY FROM HOME), THE FUEL PUMP WAS JUST REPLACED, AND THEN I FIND OUT FROM THE GARAGE THAT CHANGED THE FUEL PUMP THAT THE TIPM NEEDS TO BE REPLACED. I AM NOW CURRENTLY WAITING FOR A NEW TIPM FROM THE DEALERSHIP. I HAVE BEEN WITHOUT A VEHICLE FOR 3 WEEKS NOW AS THIS PART IS ON BACK ORDER. THIS VEHICLE HAS COST ME THOUSANDS OF DOLLARS IN THE SHORT TIME I HAVE OWNED IT AND HAS BEEN VERY UNRELIABLE FOR ME AND MY FAMILY, INCLUDING 3 CHILDREN.

NHTSA ODI #11268073

Official recalls

5

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

14V234000 · Electrical System

May 7, 2014

Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.

Consequence & remedy

Consequence: An overheated switch may result in a vehicle fire.

Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.

12V191000 · Equipment

May 2, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES, MANUFACTURED FROM MARCH 9, 2012 THROUGH MARCH 12, 2012. SOME VEHICLES MAY BE EQUIPPED WITH A RIGHT SIDE LIFTGATE PINCH SENSOR THAT DOES NOT FUNCTION PROPERLY. AS A RESULT, INCREASED FORCE MAY BE REQUIRED IN ORDER TO STOP THE POWER LIFTGATE DURING FINAL CLOSING STAGES.

Consequence & remedy

Consequence: THE POWER LIFTGATE DOOR MAY CLOSE ON AN APPENDAGE, INCREASING THE RISK OF INJURY.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE RIGHT SIDE LIFTGATE PINCH SENSORS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

12V141000 · Suspension:rear

Apr 3, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM NOVEMBER 15, 2011, THROUGH NOVEMBER 21, 2011. SOME VEHICLES MAY BE EQUIPPED WITH RIGHT REAR HUB AND BEARING ASSEMBLIES THAT WERE NOT FULLY MACHINED.

Consequence & remedy

Consequence: THIS COULD RESULT IN A DECREASE IN DURABILITY, WHICH MAY LEAD TO WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE RIGHT REAR HUB AND BEARING ASSEMBLY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

11V487000 · Engine And Engine Cooling

Sep 29, 2011

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 CHRYSLER VEHICLES, INCLUDING 200 AND TOWN AND COUNTRY MODELS, DODGE VEHICLES, INCLUDING CHARGER, DURANGO, GRAND CARAVAN AND JOURNEY MODELS AND JEEP GRAND CHEROKEE VEHICLES MANUFACTURED FROM AUGUST 31, 2011, THROUGH SEPTEMBER 13, 2011, THAT ARE EQUIPPED WITH 3.6L ENGINES. THESE ENGINES MAY EXPERIENCE CONNECTING ROD BEARING FAILURE DUE TO DEBRIS INSIDE THE ENGINE BLOCK.

Consequence & remedy

Consequence: CONNECTING ROD FAILURE MAY LEAD TO ENGINE SEIZURE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE ENGINE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den