← New search

2012 Chrysler Town And Country

Owner reports · Recalls · Investigations

More warning signs than most Town And Country years

Owner complaints for the 2012 Chrysler Town And Country are substantially higher than the model-year median of 216.5.

About this comparison →

When problems were reported

Mileage at the reported incident

372 reports with mileage · 262 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 395 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

7 crash reports16 fire reports19 injury reports

Seats complaints

12 reports
Clear category filter
135,000 miles · Mar 31, 2025
Air BagsSeats

The contact owns a 2012 Chrysler Town and Country. The contact stated while the vehicle was parked, the front driver's side head restraint deployed. No warning light was illuminated. The contact stated that the failure had occurred immediately after the vehicle was parked. The vehicle was not diagnosed or repaired by an independ…

Read full complaint

The contact owns a 2012 Chrysler Town and Country. The contact stated while the vehicle was parked, the front driver's side head restraint deployed. No warning light was illuminated. The contact stated that the failure had occurred immediately after the vehicle was parked. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact was informed of an unknown recall repair with a similar failure; however, the contact was informed that the recall had expired. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 135,000.

NHTSA ODI #11651734

Mileage unknown · Jun 21, 2024
Seats

Driver's seat active headrest deployed while vehicle was in motion with cruise control set at 35 MPH. Loud bang accompanied by the headrest hitting the driver in the back of the head causing the driver to jerk the steering wheel.

NHTSA ODI #11595807

Mileage unknown · Sep 24, 2023
Seats

Passenger side head rest deployed while the vehicle was sitting in my driveway.

NHTSA ODI #11546261

132,600 miles · Sep 1, 2020
EnginePower TrainSeats

OIL COOLER HOUSING DEFECTIVE CRACKS UNDER PRESSURE OR OVERHEATING. DRIVER SIDE POWER SEAT FAILURE MAJOR SAFETY ISSUES. POWER TRAIN ROUGH SHIFTING.

NHTSA ODI #11352446

132,800 miles · Aug 27, 2020
Electrical SystemEngineSeats

UPPER TOP ENGINE CAMSHAFT ROLLERS ARE DEFECTIVE ALSO ELECTRONICA FUEL INJECTION PROBLEMS FOLLOWED BY FAULTY DASH TEMPERATURE GAUGE ALSO DRIVER SIDE SEAT HAS A DEFECTIVE LEFT SIDE MOTOR WITH FAULTY SEAT BELT HOLDER

NHTSA ODI #11351527

Mileage unknown · Nov 7, 2019
Seats

FRONT PASSENGER SEAT BELT KEEPS JAMMING AND NOW CAN'T EVEN CONNECT BELT INTO THE LOCKING PART

NHTSA ODI #11278782

35,000 miles · Jun 6, 2019
Electronic Stability Control (esc)Seats

1) THE THIRD ROW PIER FOLDING SEATS HAVE TWICE BEEN INADVERTENTLY ACTIVATED BY A CHILD TOUCHING THE BUTTON, AND NARROWLY ESCAPING BEING CRUSHED BY THE FOLDING SEAT. ALSO, THE SEAT JAMMED IN THE HALF FOLDED POSITION AND THE DEALERSHIP WANTED $2600+ TO FIX IT. THE POWER FOLDING SEATS ARE A DEATH TRAP IF SOMEONE CANNOT GET OUT OF…

Read full complaint

1) THE THIRD ROW PIER FOLDING SEATS HAVE TWICE BEEN INADVERTENTLY ACTIVATED BY A CHILD TOUCHING THE BUTTON, AND NARROWLY ESCAPING BEING CRUSHED BY THE FOLDING SEAT. ALSO, THE SEAT JAMMED IN THE HALF FOLDED POSITION AND THE DEALERSHIP WANTED $2600+ TO FIX IT. THE POWER FOLDING SEATS ARE A DEATH TRAP IF SOMEONE CANNOT GET OUT OF THE WAY WHEN THE BUTTON HAS BEEN ACTIVATED. 2) TWICE NOW, THE ELECTRICAL SYSTEM HAS BEEN FLASHING RANDOM CODES- THE TIRE PRESSURE GAUGE WHEN THE TIRE PRESSURE IS FINE, THE ABS AND TRACTION LIGHT, AND ALSO WEIRD MINI ROUGH IDLES AT VERY LOW SPEEDS IN HEAVY TRAFFIC. IT IS A REPEAT PROBLEM THAT THE SHOP SEEMS TO ONLY TEMPORARILY FIX.

NHTSA ODI #11218225

110,731 miles · May 5, 2018
Seats

MIDDLE FOLD & STORE SEAT DOES NOT RELEASE TO COLLAPSE INTO THE FLOOR BEHIND DRIVER. THE RELEASE WON'T WORK. PRIOR TO CURRENT PROBLEM SEAT DIDN'T GO INTO STORE POSITION WITH OUT A FIGHT. THE 3RD ROW FOLD DOWN SEAT, (DOUBLE SEAT), RETRACTABLE LEG LOCKS WON'T FOLD DOWN IN THE FLOOR POSITION. THEY STICK UP IN THE AIR. THE CABLE M…

Read full complaint

MIDDLE FOLD & STORE SEAT DOES NOT RELEASE TO COLLAPSE INTO THE FLOOR BEHIND DRIVER. THE RELEASE WON'T WORK. PRIOR TO CURRENT PROBLEM SEAT DIDN'T GO INTO STORE POSITION WITH OUT A FIGHT. THE 3RD ROW FOLD DOWN SEAT, (DOUBLE SEAT), RETRACTABLE LEG LOCKS WON'T FOLD DOWN IN THE FLOOR POSITION. THEY STICK UP IN THE AIR. THE CABLE MECHANIZE ATTACHED TO A PLASTIC PIECE THAT HOLDS CABLE IN PLACE CAME APART WHILE FOLDING SEAT DOWN FOR STORAGE. THE PLASTIC PART HAS A CRACK IN IT WHERE CABLE BROKE THROUGH. THE CAR WAS STATIONARY IN THE DRIVEWAY AND WE WERE CLEANING THE CAR.

NHTSA ODI #11092035

63,424 miles · May 11, 2016
Air BagsElectrical SystemSeats

I RECENTLY PURCHASED A USED 2012 (09/11 PRODUCTION DATE) CHRYSLER TOWN 7 COUNTRY TOURING, VAN, IT HAD 063,200.0 MILES WHEN RECEIVED. PURCHASED FROM A HONEST AND REPUTABLE LOCAL USED CAR DEALER. (IT WAS A NEW CAR TRADE IN FROM A DEALER 45 MILES AWAY) AFTER DRIVING THE VAN FOR APROX. 300 MILES THE AIR BAG LIGHT IN THE DASH CAME ON…

Read full complaint

I RECENTLY PURCHASED A USED 2012 (09/11 PRODUCTION DATE) CHRYSLER TOWN 7 COUNTRY TOURING, VAN, IT HAD 063,200.0 MILES WHEN RECEIVED. PURCHASED FROM A HONEST AND REPUTABLE LOCAL USED CAR DEALER. (IT WAS A NEW CAR TRADE IN FROM A DEALER 45 MILES AWAY) AFTER DRIVING THE VAN FOR APROX. 300 MILES THE AIR BAG LIGHT IN THE DASH CAME ON AND WOULD NOT RESET OR GO OUT. THE DEALER TRIED TO CLEAR THE CODE BUT COULD NOT. THEY DETERMINED THAT IT WAS SOMETHING RELATED TO THE DRIVERS SEAT. AT THEIR RECOMMENDATION I TOOK THE VAN TO THE LOCAL CHRYSLER/JEEP/RAM DEALER TO BE CHECKED. THE DEALER CHARGED $95.00 TO CHECK IT AND SAID THAT THERE IS A SHORT IN THE DRIVERS HEAD REST WHICH IS NON-REPAIRABLE AND WILL COST $725.00 (PLUS THE $95.00 CHARGE) TO REPLACE THE HEAD REST. THIS SAFETY SYSTEM FAILURE IS NOT COVERED BY THE FACTORY AFTER THE 36/36 IS EXPIRED. I CALLED THE CHRYSLER FACTORY INFORMATION LINE AND WAS AGAIN TOLD THAT THIS SAFETY SYSTEM FAILURE IS NOT COVERED BY CHRYSLER. IN RESEARCHING THIS ISSUE I HAVE SEEN THAT CHRYSLER HAS HAD AT LEAST 840,000 RECALLS INVOLVING HEAD RESTS. HOW CAN I GET CHRYSLER TO REPAIR THIS SERIOUS PROBLEM. THE DEALER AND CHRYSLER SAID THAT THE SRS/AIR BAGS WILL NOT WORK IF THE LIGHT IS ON. THIS MEANS I HAVE NO AIR BAG FUNCTION SHOULD I BE INVOLVED IN AN ACCIDENT. I AM VERY CONCERNED AND FEEL THAT A SERIOUS SAFETY SYSTEM FAILURE LIKE THIS SHOULD BE A FACTORY COVERED REPAIR FOR AT LEAST 150,000 MILES. I HAVE BEEN DENIED THE REPAIR BY CHRYSLER, REGARDLESS OF THE POTENTIAL FOR SERIOUS INJURY OR DEATH IF INVOLVED IN AN ACCIDENT WHEN THE SRS SYSTEM WILL NOT WORK. I AM A DISABLED VETERAN AND NEED THIS VAN FOR TRANSPORTATION.

NHTSA ODI #10864374

Mileage unknown · Apr 9, 2014
SeatsStructureInjury

2012 CHRYSLER TOWN & COUNTRY (RENTAL). CONSUMER WRITES IN REGARDS TO RENTAL VEHICLE SLIDING DOOR & PASSENGER SEATS MALFUNCTION. *SMD THE CONSUMER STATED THE SLIDING DOORS JUST BEHIND THE FRONT DOORS WERE ELECTRONICALLY OPERATED. THERE WERE 2 OCCASIONS WHERE THE CONSUMER'S HUSBAND AND A TEEN-AGED DRIVER INADVERTENTLY HAD THEIR…

Read full complaint

2012 CHRYSLER TOWN & COUNTRY (RENTAL). CONSUMER WRITES IN REGARDS TO RENTAL VEHICLE SLIDING DOOR & PASSENGER SEATS MALFUNCTION. *SMD THE CONSUMER STATED THE SLIDING DOORS JUST BEHIND THE FRONT DOORS WERE ELECTRONICALLY OPERATED. THERE WERE 2 OCCASIONS WHERE THE CONSUMER'S HUSBAND AND A TEEN-AGED DRIVER INADVERTENTLY HAD THEIR HAND ON THE CAR FRAME, AND WHEN THE BUTTON WAS PUSHED TO CLOSE THE DOOR, IT DID NOT STOP, WHEN IT HIT THEIR HANDS. IT KEPT MOVING AND MASHED THEIR HANDS BETWEEN THE MOVING DOOR AND DOOR FRAME. THE INJURIES WERE NOT SEVERE. HOWEVER, A SAFETY SWITCH IS NEEDED TO STOP THE DOOR. A MUCH BIGGER PROBLEM, HOWEVER, WAS FOUND IN THE SECOND ROW OF THE SEAT, JUST BEHIND THE FRONT SEAT. THE CONSUMER STATED SHE AND HER HUSBAND WERE SITTING IN THE SEATS, AND DECIDED TO TAKE A NAP. WHEN SHE WENT TO RE-POSITION THE SEAT, TO ITS UPRIGHT POSITION, SHE TURNED SIDEWAYS TO PULL THE LEVER ON THE SIDE, BUT WHEN SHE PULLED IT, THE ENTIRE BACK REST ASSEMBLY SLAMMED HER FORWARD WITH CONSIDERABLE IMPACT. AT THE SAME TIME, THE HEAD REST ATOP THE BACK REST SLAMMED FORWARD WITH MUCH MORE IMPACT AND IT HIT HER IN THE BACK OF THE HEAD. *JB

NHTSA ODI #10577689

Official recalls

5

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

14V234000 · Electrical System

May 7, 2014

Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.

Consequence & remedy

Consequence: An overheated switch may result in a vehicle fire.

Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.

12V191000 · Equipment

May 2, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES, MANUFACTURED FROM MARCH 9, 2012 THROUGH MARCH 12, 2012. SOME VEHICLES MAY BE EQUIPPED WITH A RIGHT SIDE LIFTGATE PINCH SENSOR THAT DOES NOT FUNCTION PROPERLY. AS A RESULT, INCREASED FORCE MAY BE REQUIRED IN ORDER TO STOP THE POWER LIFTGATE DURING FINAL CLOSING STAGES.

Consequence & remedy

Consequence: THE POWER LIFTGATE DOOR MAY CLOSE ON AN APPENDAGE, INCREASING THE RISK OF INJURY.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE RIGHT SIDE LIFTGATE PINCH SENSORS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

12V141000 · Suspension:rear

Apr 3, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM NOVEMBER 15, 2011, THROUGH NOVEMBER 21, 2011. SOME VEHICLES MAY BE EQUIPPED WITH RIGHT REAR HUB AND BEARING ASSEMBLIES THAT WERE NOT FULLY MACHINED.

Consequence & remedy

Consequence: THIS COULD RESULT IN A DECREASE IN DURABILITY, WHICH MAY LEAD TO WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE RIGHT REAR HUB AND BEARING ASSEMBLY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

11V487000 · Engine And Engine Cooling

Sep 29, 2011

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 CHRYSLER VEHICLES, INCLUDING 200 AND TOWN AND COUNTRY MODELS, DODGE VEHICLES, INCLUDING CHARGER, DURANGO, GRAND CARAVAN AND JOURNEY MODELS AND JEEP GRAND CHEROKEE VEHICLES MANUFACTURED FROM AUGUST 31, 2011, THROUGH SEPTEMBER 13, 2011, THAT ARE EQUIPPED WITH 3.6L ENGINES. THESE ENGINES MAY EXPERIENCE CONNECTING ROD BEARING FAILURE DUE TO DEBRIS INSIDE THE ENGINE BLOCK.

Consequence & remedy

Consequence: CONNECTING ROD FAILURE MAY LEAD TO ENGINE SEIZURE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE ENGINE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den