Fuel/propulsion System. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports5 fire reports7 injury reports

Equipment complaints

4 reports

Clear category filter

30,000 miles · Jul 26, 2010

EquipmentTires

Read full complaint

PURCHASED 4 TIRES (TOYO OBSERVE GP4, 215/65R16 980, DOT: CXHB 7EM219<) IN FALL 2003 (FROM LES SCHWAB TIRE COMPANY) TO BE USED ON A 2002 CHRYSLER T&C AND LATER A 2004 CHRYSLER T&C (THE 2002 CHRYSLER T&C WAS REPLACED IN APRIL 2004 WITH A 2004 CHRYSLER T&C). NOTE THE TIRES WERE OVER 4 YEARS OLD WHEN PURCHASED NEW FROM THE DEALER. THE TIRES ARE WINTER TRACTION TIRES AND WERE MOUNTED ON THEIR OWN RIMS AND USED EACH YEAR DURING THE PERIOD NOVEMBER - MARCH. THE TIRES WERE STORED (MOUNTED) DURING THE PERIOD APRIL - OCTOBER AND WERE NOT USED DURING THAT PERIOD. ONE TIRE WAS DAMAGED AND REPLACED IN NOV 2005 BY A TIRE WITH DOT: CXHB 95K1304). THE LAST TIME THE TIRES WERE USED WAS THE PERIOD NOVEMBER 2008 - MARCH 2009. THE TIRES WERE USED EACH YEAR FOR ABOUT 5000 MILES. THE SUGGESTED MAXIMUM INFLATION PRESSURE FOR THESE TIRES IS 44 PSI; THE TIRES WERE USED WITH AN INFLATION PRESSURE OF 40 PSI. THIS REPORT CONCERNS THE REMAINING THREE DOT: CXHB 7EM219< TIRES (PHOTOS ARE AVAILABLE). ON JULY 25, 2010, THE FOLLOWING WAS DISCOVERED WHILE THE TIRES WERE IN STORAGE: A. TIRE #1 TIRE HAD A MASSIVE TREAD SEPARATION ( TREAD SPLIT APART) WHICH COVERED OVER 1/3 OF THE CIRCUMFERENCE, PLUS ADDITIONAL PORTIONS OF THE TREAD WERE STARTING TO SEPARATE. B. TIRE #2 HAS VERY NOTICEABLE DELAMINATION OF THE TREAD, BUT NO TEARING. C. TIRE #3 HAS A FEW DETECTABLE INDICATIONS THAT TREAD SEPARATION IS IN VERY EARLY STAGES. THE TIRES HAVE NOT YET BEEN RETURNED TO THE DEALER UNDER THEIR WARRANTY, BUT WILL BE RETURNED IN EARLY FALL. THERE WAS NO ACCIDENT BECAUSE THE TIRES WERE IN SUMMER STORAGE WHEN THE TREAD SEPARATION WAS FOUND. IF THE TIRES HAD BEEN MOUNTED ON THE CAR WHEN THE TREAD SEPARATION OCCURRED THERE COULD HAVE BEEN UNFORTUNATE CONSEQUENCES. TIRE DOT: CXHB 95K1304 IS NOT PART OF THIS COMPLAINT. *TR

NHTSA ODI #10345359

6,000 miles · Sep 7, 2005

EquipmentService Brakes, Hydraulic

RECURRING BRAKE PROBLEMS VEHICLE HAS 40000 MILES ON IT AND LEFT FRONT BRAKE ROTOR HAS BEEN REPLACED 3 TIMES. BRAKE PADS HAVE BEEN REPLACED 6 TIMES. LAST TIME ROTOR WAS REPLACED AT 34000 MILES AND ONCE AGAIN THE ROTOR NEEDS TO BE REPLACED. DEALERS CAN NOT FIND ANY PROBLEM. *JB

NHTSA ODI #10135758

3,000 miles · Aug 11, 2004

Electrical SystemEquipmentService Brakes, Hydraulic

MY TOWN AND COUNTRY HAS BEEN IN THE REPAIR SHOP APPROX. 11 TIMES NOW. IT HAS 20,000 MILES ON IT. THE FIRST INCIDENT HAPPENED AT ABOUT APPROX 3,000 MILES INTO IT, ABOUT 1 MONTH OLD, IT SHUTS OFF BY ITSELF. THIS PROGRESSIVLY GOT WORSE, IT RUNS VERY ROUGH AND LOSES POWER WHILE DRIVING. THE STEERING FLUID HAS LEAKED TWICE, FIRST…

Read full complaint

NHTSA ODI #10086605

Mileage unknown · Jul 23, 2004

Engine And Engine CoolingEquipmentFuel System, Gasoline

Read full complaint

MECHANICAL PROBLEMS INVOLVING 2004 CHRYSLER TOWN AND COUNTRY.*MR THE VEHICLES MALFUNCTION INDICATOR LAMP ILLUMINATED WHILE DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER AND RETURNED THE NEXT DAY. AFTER DRIVING THE VEHICLE 10 MILES THE LIGHT ILLUMINATED AGAIN. THE VEHICLE WAS RETURNED TO THE DEALER TWICE AFTER THE INITIAL VISIT FOR THE SAME PROBLEM. THE VEHICLE ALSO BEGAN TO MALFUNCTION IN OTHER WAYS. THE SPEEDOMETER WOULD INDICATOR THE INCORRECT SPEED. THE ENGINE MADE NOISE WHEN THE GEAR SHIFT WAS MOVED. THE ENGINE VIBRATED WHEN ACCELERATING. THE BRAKES MALFUNCTIONED. THE AIR CONDITIONING FAILED INTERMITTENTLY. THE DEALER HAS NOT BEEN ABLE TO PERMANENTLY RESOLVE THE PROBLEMS. *NM *JB

NHTSA ODI #10083735

Official recalls

04V386000 · Steering:hydraulic Power Assist:hose, Piping, And Connections

Aug 5, 2004

ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.

Consequence & remedy

Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.

Remedy: DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP14002 · Engine Stall After Refueling

Opened Sep 5, 2014 · Closed Apr 6, 2015

Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly

This defect petition evaluates July 7, 2014 allegations from an owner of a model year (MY) 2007 Dodge Grand Caravan minivan that engine stall occurs in these vehicles without warning after refueling.The petitioner's vehicle is a Chrysler RS platform minivan.The RS platform includes MY 2003 through 2007 Dodge Grand Caravan, Dodge Caravan, Chrysler Town and Country and Chrysler Voyager minivans.NHTSA evaluated the petition by analyzing consumer complaints submitted to the Agency, analyzing field data, reviewing technical information provided in Chrysler's response to an Agency information request and testing an RS minivan identified by its owner as experiencing post-refuel engine stalls.After completing this evaluation, NHTSA has concluded that further investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists.The stalls occurring in these vehicles only occur immediately after filling up the fuel tank and happen at low engine speeds. The failure rate is low, even after 8 to 13 years of the vehicles being in service, and there are no reports of crashes or injuries resulting from the stall condition.In the Agency's view, additional investigation is unlikely to result in finding the existence of a safety-related defect in the subject vehicles.Given the need to allocate and prioritize NHTSA's limited resources to best accomplish the Agency's safety mission, the petition is denied.This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will take further action if warranted by future circumstances. More details concerning our review can be found in the Federal Register Notice for this action.The following 161 VOQs are included in the petition evaluation: 10209242, 10229468, 10240708, 10260923, 10275939, 10276532, 10296487, 10298175, 10328669, 10330144, 10346517, 10349789, 10354758, 10363689, 10372112, 10372368, 10372514, 10378031, 10379764, 10382938, 10387448, 10394063, 10398877, 10413918, 10418652, 10420924, 10427063, 10437525, 10445392, 10446902, 10470028, 10471249, 10473733, 10502231, 10503114, 10504260, 10509862, 10511988, 10512120, 10512385, 10512650, 10513147, 10538154, 10549841, 10551763, 10555188, 10555418, 10556754, 10565367, 10574012, 10574398, 10586555, 10587212, 10587559, 10593433, 10607841, 10607913, 10608922, 10615810, 10622468, 10628141, 10632112, 10632128, 10632172, 10632175, 10632231, 10632262, 10632266, 10632270, 10632305, 10632316, 10632326, 10632370, 10632385, 10632399, 10632492, 10632542, 10632765, 10632833, 10632928, 10633197, 10633281, 10633409, 10633421, 10633483, 10633507, 10637752, 10637804, 10637950, 10637975, 10638032, 10638289, 10638290, 10638401, 10638968, 10639218, 10639623, 10641157, 10641603, 10641614, 10641836, 10644339, 10644705, 10649713, 10649895, 10649932, 10650313, 10652590, 10653147, 10653783, 10654533, 10655226, 10658900, 10659679, 10660320, 10662588, 10662645, 10662662, 10663473, 10667056, 10667437, 10668081, 10668094, 10668131, 10668612, 10668969, 10668970, 10669584, 10669678, 10669729, 10669775, 10669866, 10669895, 10669992, 10670422, 10670506, 10676348, 10676732, 10677120, 10679795, 10679934, 10680057, 10680290, 10680342, 10680714, 10681512, 10682584, 10682906, 10683022, 10683114, 10683549, 10683620, 10683697, 10683743, 10689898, 10690761, 10691284, 10691556, 10691751, 10693061, 10694300