Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
550–25K
6225–50K
6750–75K
4375–100K
34100–150K
13150K+
274 reports with mileage · 130 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Steering. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports12 fire reports20 injury reports
What owners actually said
404 reports
139,000 miles · Nov 22, 2017
Steering
THE POWER STEERING QUITS WORKING AT TIMES WHEN ITS RAINING. IT WILL NOT WORK MANY TIMES WHEN I CRANK IT UP IF ITS BEEN RAINING. ITS HAS STOPPED WORKING WHILE ON THE INTERSTATE, CITY STREETS, WHILE TURNING ONTO ANOTHER STREET OR ROAD, AND AT STOP SIGNS. I HAVE HAD THE DRIVE BELT, POWER STEERING PUMP, TENSION IDLER REPLACED AND NO…
Read full complaint
THE POWER STEERING QUITS WORKING AT TIMES WHEN ITS RAINING. IT WILL NOT WORK MANY TIMES WHEN I CRANK IT UP IF ITS BEEN RAINING. ITS HAS STOPPED WORKING WHILE ON THE INTERSTATE, CITY STREETS, WHILE TURNING ONTO ANOTHER STREET OR ROAD, AND AT STOP SIGNS. I HAVE HAD THE DRIVE BELT, POWER STEERING PUMP, TENSION IDLER REPLACED AND NOTHING HELPS. I HAVE TAKEN IT TO JOHN GREENE CHRYSLER DODGE IN MORGANTON NC, AND OTHER REPAIR CENTERS. NO ONE HAS BEEN ABLE TO FIX THE PROBLEM.
NHTSA ODI #11047992
264,000 miles · Nov 20, 2017
Electrical SystemFuel/propulsion System
THE FUEL INJECTION WIRING HARNESS LENGTH IS APPARENTLY TOO LONG AND IT CAN DROP DOWN NEAR THE EXHAUST MANIFOLD WHERE THE HEAT WILL MELT THE INSULATION ON THE WIRES CAUSING THEM TO SHORT TOGETHER CAUSING SEVERE MISFIRE AND POSSIBLE DAMAGE TO THE CATALYTIC CONVERTER. THE VEHICLE HAD RUN FINE A COUPLE OF DAYS PREVIOUSLY AND ON…
Read full complaint
THE FUEL INJECTION WIRING HARNESS LENGTH IS APPARENTLY TOO LONG AND IT CAN DROP DOWN NEAR THE EXHAUST MANIFOLD WHERE THE HEAT WILL MELT THE INSULATION ON THE WIRES CAUSING THEM TO SHORT TOGETHER CAUSING SEVERE MISFIRE AND POSSIBLE DAMAGE TO THE CATALYTIC CONVERTER. THE VEHICLE HAD RUN FINE A COUPLE OF DAYS PREVIOUSLY AND ON STARTING THE VEHICLE IT SEEMED TO IDLE A LITTLE ROUGH. DRIVING ON THE ROAD IT RAN VERY ROUGH AND WAS RANDOMLY MISFIRING ON MULTIPLE CYLINDERS. THE MIL LIGHT BEGAN TO FLASH ON AND OFF ON ACCELERATION. ON INVESTIGATION THE WIRES IN THE FUEL INJECTION WIRING HARNESS WERE FOUND TO BE MELTED AND SHORTING TOGETHER. I SUSPECT IN THE ENSUING TWO DAYS THAT THE TEMPERATURE CHANGES EXACERBATED THE PROBLEM AND TEMPERATURE CHANGE INDUCED MOVEMENT CAUSED THE WIRES TO SHORT TOGETHER. FROM RESEARCHING THIS PROBLEM IT AFFECTS MANY VEHICLES. I'M SURPRISED THAT A RECALL HAS NOT YET BEEN ISSUED FOR IT.
NHTSA ODI #11047537
Mileage unknown · Jul 13, 2017
Fuel/propulsion System
DEFECT # 1951- ENGINE FAMILIES-2CRXT0382D0. EMISSION PROBLEM- DUE TO AN OVER- TEMPERATURE WELD CONDITION THE CONTROL SYSTEM MAY SEPARATE FROM THE TANK ASSEMBLY. THIS COULD RESULT IN A POSSIBLE FUEL LEAK. CURRENTLY, ENGINE LIGHT IS ON.
NHTSA ODI #11005203
149,500 miles · Jul 10, 2017
Service Brakes
OVER THE LAST FOUR YEARS I HAVE EXPERIENCED SEVERAL INSTANCES OF PARTIAL FRONT BRAKE APPLICATION WHEN NO DRIVER INPUT IS INITIATED. THIS RESULTS IN THE FEELING OF THE CAR DRAGGING. IT IS SUBTLE BUT IF THE CAR IS PUT INTO NEUTRAL THE CAR COMES TO A STOP EVEN WITH NO DRIVER BRAKE INPUT. IN SEVERAL INSTANCES THE FRONT BRAKES GET…
Read full complaint
OVER THE LAST FOUR YEARS I HAVE EXPERIENCED SEVERAL INSTANCES OF PARTIAL FRONT BRAKE APPLICATION WHEN NO DRIVER INPUT IS INITIATED. THIS RESULTS IN THE FEELING OF THE CAR DRAGGING. IT IS SUBTLE BUT IF THE CAR IS PUT INTO NEUTRAL THE CAR COMES TO A STOP EVEN WITH NO DRIVER BRAKE INPUT. IN SEVERAL INSTANCES THE FRONT BRAKES GET EXTREMELY HOT AND BEGIN TO SMOKE. THIS IS A SERIOUS FIRE HAZARD. AFTER ALLOWING THE BRAKES TO COOL FOR ABOUT AN HOUR THE BRAKES RETURN TO NORMAL AND DRIVING CAN RESUME. I HAVE TAKEN THE CAR SEVERAL TIMES TO THE CHRYSLER DEALER AND OTHER MECHANICS. THEY CAN FIND NOTHING WRONG. THERE DOES NOT SEEM TO BE ANY RECALLS OR ALERTS CONCERNING THIS PROBLEM. I WOULD ESTIMATE THAT THIS PROBLEM HAS OCCURRED ABOUT SEVEN OR EIGHT TIMES, THE MOST RECENT ONE ON JULY 8, 2017. WEATHER DOES NOT SEEM TO BE A FACTOR NOR DOES HIGHWAY OR LOCAL DRIVING.
NHTSA ODI #11004050
158,000 miles · Oct 18, 2016
Fuel/propulsion System
SEVERE GASOLINE ODOR FROM UNDER THE WHOLE CAR. NOTICED THE GASOLINE LEAK FROM THE SIDE OF THE GASOLINE TANK WHERE THE WHITE PLASTIC CONNECTOR WAS WELDED TO A BLACK PLASTIC GAS TANK.. WE NOTICED THE GASOLINE ODOR WHILE WE ARE IN A HOUSE. GASOLINE WAS LEAKING FROM THE GASKET BETWEEN THE GAS TANK AND WHITE PLASTIC ATTACHMENT ASSEMB…
Read full complaint
SEVERE GASOLINE ODOR FROM UNDER THE WHOLE CAR. NOTICED THE GASOLINE LEAK FROM THE SIDE OF THE GASOLINE TANK WHERE THE WHITE PLASTIC CONNECTOR WAS WELDED TO A BLACK PLASTIC GAS TANK.. WE NOTICED THE GASOLINE ODOR WHILE WE ARE IN A HOUSE. GASOLINE WAS LEAKING FROM THE GASKET BETWEEN THE GAS TANK AND WHITE PLASTIC ATTACHMENT ASSEMBLY.
NHTSA ODI #10917157
105,000 miles · Aug 14, 2016
Service Brakes
LOSS OF BRAK POWER, PEDAL TRAVELS TO FLOOR. ; AFTER REPLACING MASTER CYLINDER, CALIPER ON THE LEFT FRONT.. MUST RE-BLEED LEFT FRONT** ONLY . MUST PERFORME THIS PROCEDURE EVERY 2 WEEKS...AND THIS IS A FREQUENT OCCURENCE ON LEFT FRONT WHEEL.THE ONLY OPTION IS TO REPLACE THE ORIGINAL ABS HYDRAULIC UNIT? WHY WAS THIS NOT A R…
Read full complaint
LOSS OF BRAK POWER, PEDAL TRAVELS TO FLOOR. ; AFTER REPLACING MASTER CYLINDER, CALIPER ON THE LEFT FRONT.. MUST RE-BLEED LEFT FRONT** ONLY . MUST PERFORME THIS PROCEDURE EVERY 2 WEEKS...AND THIS IS A FREQUENT OCCURENCE ON LEFT FRONT WHEEL.THE ONLY OPTION IS TO REPLACE THE ORIGINAL ABS HYDRAULIC UNIT? WHY WAS THIS NOT A RECALL, IT SEEMS LOT OF OWNERS OF 2002 HAVE HAD THIS PROBLEM..,IT'S ONLY THE LEFT FRONT WHEEL THAT HAS THIS PROBLEM, AFTER BLEEDING, THE BRAKES LAST ONLY FEW WEEKS AND SAME THING, BRAKE PEDAL IS SPONGY AND TRAVELS TO THE FLOOR. AND MUST RE-BLEED LEFT FRONT WHEEL. IT SEEMS THAT THERE IS A LOT OF VERY MINUTE BOUBLES. ## VIN PASSED ## CHRYSLER TRUCK 2002, TOWN & CONTRY,2002 3.3 L ##
NHTSA ODI #10895732
Mileage unknown · Jul 20, 2016
Electrical SystemEngineUnknown Or Other
N/A
NHTSA ODI #10886039
146,000 miles · May 21, 2016
Fuel/propulsion System
STRONG SMELL OF GAS FILLING UP VEHICLE WHILE DRIVING. STRONG SMELL OF GAS ALSO OCCURS OUTSIDE OF VEHICLE FILLING UP PARKED ENCLOSURE WHEN VEHICLE WAS RUNNING. INSPECTION DETERMINED FUEL RAIL LEAK. REPAIRS INCLUDED REPLACEMENT RAIL AND FUEL INJECTOR O-RINGS. SIMILAR COMPLAINTS ON FILE.
NHTSA ODI #10870172
90,500 miles · Oct 9, 2015
Electrical SystemEngine
CAR RANDOMLY STALLS AND HAS NO POWER BRAKES, STEERING OR CONTROL.
NHTSA ODI #10781186
134,721 miles · Jun 21, 2015
Fuel/propulsion System
REAR FUEL TANK RETENTION STRAP BROKE AND NOTICED FRONT STRAP HAS IMMINENT FAILURE DUE TO RUSTING. IF THE FRONT STRAP BROKE THE PLASTIC TANK WOULD DRAG ON THE GROUND CAUSING A HOLE IN THE FUEL TANK AND IGNITION OF FUEL TANK AND VEHICLE AND LOSS OF LIFE. ALL VEHICLES LIKE THIS NEED INSPECTION AND REPAIR AS SOON AS POSSIBLE.
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.
Remedy: DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINI VANS, THE FUEL TANK CONTROL VALVE WELD JOINT COULD SEPARATE RESULTING IN A POSSIBLE FUEL LEAK.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERBODY FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY. OWNER NOTIFICATION BEGAN OCTOBER 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: CERTAIN MINI VANS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER MANUALS SUPPLIED WITH THESE VEHICLES DO NOT INDICATE WHICH SEATING POSITIONS ARE EQUIPPED WITH TETHER ANCHORAGES AND CHILD RESTRAINT ANCHORAGE SYSTEMS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH THE NECESSARY CHILD RESTRAINT SYSTEM INFORMATION. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 8, 2001. OWNERS WHO DO NOT RECEIVE THE FREE INFORMATION WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
EA04031 · Power Liftgate Latch
Opened Nov 22, 2004 · Closed Apr 7, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Additional source detail variants (2)
Latches/locks/linkages
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
PE04049 · Speaker Fire In The Rear Of The Vehicle
Opened Jul 7, 2004 · Closed Nov 5, 2004
Status: closed (inferred from source dates) · Electrical System:wiring: Rear Compartment/trunk; Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System:wiring: Rear Compartment/trunk
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE03012 · Power Steering Hose Failure
Opened Apr 9, 2003 · Closed May 29, 2003
Status: closed (inferred from source dates) · Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid; Steering:hydraulic Power Assist:pump; Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
Additional source detail variants (5)
Steering:hydraulic Power Assist:hose, Piping, And Connections
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:power Steering Fluid
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:pump
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist System
PLEASE SEE ATTACHED REPORT.
Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
PE02068 · Fuel Tank Leak
Opened Sep 24, 2002 · Closed Oct 9, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
2002 Chrysler Town And Country Problems, Complaints & Recalls | Skip That Year
Illustration