Illustration02 CHRYSLER TOWN AND COUNTRY WAS REAR-ENDED BY ANOTHER VEHICLE. DRIVE SEAT BACK COMPLAPSED, EJECTING DRIVER OF TOWN & COUNTRY TO REAR OF VAN.
2002 Chrysler Town And Country
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Chrysler Town And Country do not stand out strongly from the model-year median of 216.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Town And Country years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
550–25K
6225–50K
6750–75K
4375–100K
34100–150K
13150K+
274 reports with mileage · 130 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports12 fire reports20 injury reports
Seats complaints
7 reportsDT: THE CONTACT STATED ON 5-7-05 VEHICLE WAS REAR-ENDED BY ANOTHER VEHICLE GOING APPROXIMATELY 50 MPH. THE CONTACT WAS SITTING STILL IN HIS VEHICLE AT THIS TIME. THE VEHICLE WAS TOTALED BY THE ACCIDENT. THE PASSENGER'S SIDE AND DRIVER'S SIDE SEATS FELL BACKWARD. HE DID NOT HAVE PICTURES OF THE SEATS. HIS WIFE, A PASSENGER IN…
Read full complaint
DT: THE CONTACT STATED ON 5-7-05 VEHICLE WAS REAR-ENDED BY ANOTHER VEHICLE GOING APPROXIMATELY 50 MPH. THE CONTACT WAS SITTING STILL IN HIS VEHICLE AT THIS TIME. THE VEHICLE WAS TOTALED BY THE ACCIDENT. THE PASSENGER'S SIDE AND DRIVER'S SIDE SEATS FELL BACKWARD. HE DID NOT HAVE PICTURES OF THE SEATS. HIS WIFE, A PASSENGER IN THE VEHICLE, HIT HER RIGHT SHOULDER AND ARM ON THE DOOR POST OF THE VAN. THE DAY AFTER THE ACCIDENT HER ARM WAS BLACK. ALSO, THE CONTACT HIT HIS HEAD ON A COOLER, AND HIS HANDS WERE TIGHTLY GRIPPING THE STEERING WHEEL. HE HAD A COMPRESSION INJURY BETWEEN HIS THUMB AND FINGERS ON HIS LEFT AND RIGHT HANDS. THE CONTACT CALLED CHRYSLER ON 5-15-05. SOMEONE CAME OUT TO INSPECT THE VAN. ON THIS SAME DAY CHRYSLER WROTE HIM A LETTER STATING THAT THE SEATS DID WHAT THEY WERE DESIGNED TO DO , AND THEY WERE NOT RESPONSIBLE. THE CONTACT STATED THAT IF HIS GRAND CHILD WAS IN THE BACK SEAT AT THIS TIME HE WOULD HAVE BEEN A FATALITY. *AK
THE MID ROW PASSENGER SIDE SEAT FLIPPED FORWARD WHILE OCCUPIED. AS A RESULT, THE OCCUPANT SMASHED HIS HEAD ON THE BACK OF ANOTHER SEAT. *AK
I OWN A 2002 CHRYSLER TOWN & COUNTRY LXI MINI VAN. THE PROBLEM I HAVE NOTICED IS WITH THE PASSENGER SEATS (SECOND ROW). THEY ARE BUCKETS (NOT BENCH) AND CAN SWIVEL FORWARD TO ALLOW ACCESS TO THE THIRD ROW. IN ORDER TO PLACE THE SEAT BACK INTO POSITION AFTER A PERSON HAS ENTERED OR EXITED THE VEHICLE, YOU MUST SLAM THE SEAT BA…
Read full complaint
I OWN A 2002 CHRYSLER TOWN & COUNTRY LXI MINI VAN. THE PROBLEM I HAVE NOTICED IS WITH THE PASSENGER SEATS (SECOND ROW). THEY ARE BUCKETS (NOT BENCH) AND CAN SWIVEL FORWARD TO ALLOW ACCESS TO THE THIRD ROW. IN ORDER TO PLACE THE SEAT BACK INTO POSITION AFTER A PERSON HAS ENTERED OR EXITED THE VEHICLE, YOU MUST SLAM THE SEAT BACK INTO THE FLOOR. IF THIS IS NOT DONE HOWEVER, THE SEAT APPEARS TO GO BACK INTO PLACE. IF YOU ARE NOT EXPERIENCED WITH THIS, THE SEAT DOES NOT LOCK BACK INTO THE FLOOR. APPROXIMATELY ONE AND A HALF YEARS AGO, MY MOTHER ENTERED THE BACK SEAT AND THEN PULLED THE SECOND ROW SEAT BACK, TO WHERE SHE THOUGHT IT WAS IN PLACE. MY 2 YEAR OLD DAUGHTER WAS THEN PLACED INTO THE CAR SEAT IN THAT SECOND ROW SEAT. WE DROVE AWAY IN THE PARKING LOT BUT AT THE FIRST STOP WITH BRAKES THAT SEAT SLAMMED FORWARD, CRUSHING MY DAUGHTER'S FACE INTO THE HARD PLASTIC SEAT IN FRONT OF HER. THERE IS ALSO A SORT OF HARD PLASTIC HANDLE ON THAT FRONT SEAT THAT IS RIGHT AT CHEEK LEVEL. MY DAUGHTER FORTUNATELY CAME AWAY WITH A BRUISED CHEEK AND BLACK EYE, BUT I FELT VERY LUCKY THAT SHE DID NOT FRACTURE ANY OF HER FACIAL BONES. WE HAVE BEEN VERY CAREFUL SINCE, BUT JUST 2 WEEKS AGO, THIS HAPPENED AGAIN, THIS TIME WITH MY TWO YEAR OLD SON. AGAIN, SOMEONE WHO DID NOT REALIZE HOW HARD YOU MUST SLAM THE SEAT DOWN TO GET IT TO LOCK INTO PLACE GOT INTO THE BACK SEAT. AGAIN, AT THE FIRST STOP, MY SON SLAMMED FORWARD IN HIS CAR SEAT, CRUSHING HIS FACE INTO THE FRONT SEAT. HE TOO CAME AWAY WITH A BLACK EYE AND AGAIN WE FELT FORTUNATE THAT THERE WAS NO OTHER INJURY. I SIMPLY WANTED TO REPORT THIS HAZARD, HOPING THAT CHRYSLER WILL THINK ABOUT THE DESIGN OF THESE SEATS. THE SEATS SHOULD NOT BE ABLE TO APPEAR IN NORMAL POSITION WITHOUT BEING LOCKED.*AK
WHEN THE VEHICLE HIT A BUMP THE 2ND ROW CAPTAINS CHAIR BECAME UNLATCHED FROM THE TRACK AND CAME FORWARD. ON ONE OCCASION THE SEAT WAS OCCUPIED BY A CHILD WHEN THIS OCCURRED AND THE CHILD SUSTAINED MINOR FACIAL INJURIES THE CHILD'S FACE. *JB *NLM
2002 CHRYSLER TOWN AND COUNTRY IS SUPPOSED TO BE EQUIPPED WITH THE LATCH SYSTEM IN "ALL REAR SEATING POSITIONS". THIS SYSTEM (INCLUDING THE TETHERS) ARE NOT PRESENT ON THE 3-PASSENGER SEAT IN THIS VEHICLE. THE SAME IS TRUE FOR MOST OF THE 2003 TOWN AND COUNTRY VANS IN THE LOT OF MY CAR DEALER.
DRIVER'S MOTORIZED POWER SEAT WILL POP ON BOTTOM, POSSIBLY WHERE THE SEAT BACK JOINS SEAT BOTTOM. SEAT BOTTOM HAS A SLIGHT MOVEMENT.MANUFACTURER HAS ISSUED A TSB AND VAN HAS BEEN IN THE DEALERSHIP 7 TIMES WITH PROBLEM NOT REMEDIED. PLEASE DESCRIBE DETAILS.AK
Official recalls
404V531000 · Equipment:electrical:radio/tape Deck/cd Etc.
Nov 2, 2004
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
04V386000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Aug 5, 2004
ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.
Remedy: DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
02V274000 · Fuel System, Gasoline:storage:tank Assembly
Oct 8, 2002
ON CERTAIN MINI VANS, THE FUEL TANK CONTROL VALVE WELD JOINT COULD SEPARATE RESULTING IN A POSSIBLE FUEL LEAK.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERBODY FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY. OWNER NOTIFICATION BEGAN OCTOBER 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
01V310000 · Child Seat
Oct 4, 2001
VEHICLE DESCRIPTION: CERTAIN MINI VANS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER MANUALS SUPPLIED WITH THESE VEHICLES DO NOT INDICATE WHICH SEATING POSITIONS ARE EQUIPPED WITH TETHER ANCHORAGES AND CHILD RESTRAINT ANCHORAGE SYSTEMS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH THE NECESSARY CHILD RESTRAINT SYSTEM INFORMATION. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 8, 2001. OWNERS WHO DO NOT RECEIVE THE FREE INFORMATION WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA05009 · Headlight Malfunction
Opened Jun 1, 2005 · Closed May 2, 2006
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
PE05004 · Headlight Malfunction
Opened Feb 2, 2005 · Closed Jun 1, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
EA04031 · Power Liftgate Latch
Opened Nov 22, 2004 · Closed Apr 7, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Additional source detail variants (2)
Latches/locks/linkages
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
PE04049 · Speaker Fire In The Rear Of The Vehicle
Opened Jul 7, 2004 · Closed Nov 5, 2004
Status: closed (inferred from source dates) · Electrical System:wiring: Rear Compartment/trunk; Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System:wiring: Rear Compartment/trunk
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE03012 · Power Steering Hose Failure
Opened Apr 9, 2003 · Closed May 29, 2003
Status: closed (inferred from source dates) · Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid; Steering:hydraulic Power Assist:pump; Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
Additional source detail variants (5)
Steering:hydraulic Power Assist:hose, Piping, And Connections
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:power Steering Fluid
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:pump
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist System
PLEASE SEE ATTACHED REPORT.
Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
PE02068 · Fuel Tank Leak
Opened Sep 24, 2002 · Closed Oct 9, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.