NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
40 reportsClear category filter9,346 miles · Nov 3, 2021
Electrical SystemPower TrainService Brakes
The contact owns a 2002 Chrysler Town and Country. The contact stated that while driving at various speeds, the vehicle would suddenly jerk and hesitate. Also, the speedometer failed to operate as needed. Additionally, while depressing the brake pedal, the vehicle failed to immediately stop with the pedal extended to the floor. …
Read full complaint
The contact owns a 2002 Chrysler Town and Country. The contact stated that while driving at various speeds, the vehicle would suddenly jerk and hesitate. Also, the speedometer failed to operate as needed. Additionally, while depressing the brake pedal, the vehicle failed to immediately stop with the pedal extended to the floor. The cause of the failure was not determined. The local dealer and manufacturer were not yet notified of the failure. The failure mileage was 9,346.
NHTSA ODI #11439153
Mileage unknown · Apr 14, 2019
Fuel/propulsion SystemPower TrainUnknown Or Other
TIPM FUEL ISSUES. WHY IS THERE NOT A RECALL ON THIS ISSUE? THIS ISSUE HAS LEFT MY FAMILY WITHOUT A VEHICLE. WHY HAS BEEN ADDRESSED AND REPAIRED? I DONT HAVE 1000. FOR A NEW FUSE BOX. AND JUST ABOUT EVERY THING TO KEEP THE VEHICLE RUNNING IS NEW. THE FUEL PUMP, THE FUEL FILTER, THE POWER STEERING PUMP WATER PUMP TCM , THE C…
Read full complaint
TIPM FUEL ISSUES. WHY IS THERE NOT A RECALL ON THIS ISSUE? THIS ISSUE HAS LEFT MY FAMILY WITHOUT A VEHICLE. WHY HAS BEEN ADDRESSED AND REPAIRED? I DONT HAVE 1000. FOR A NEW FUSE BOX. AND JUST ABOUT EVERY THING TO KEEP THE VEHICLE RUNNING IS NEW. THE FUEL PUMP, THE FUEL FILTER, THE POWER STEERING PUMP WATER PUMP TCM , THE CRANKSHAFT SENSOR ALL ARE NEW WITH SPARK PLUGS WIRES AND TUNE UP. SO WHY WON'T MY 2002 CHRYSLER TOWN & COUNTRY START? I AM ASK YOU TO REPLACE THIS FOR FREE OR GIVE ME ANOTHER VEHICLE AT NO COST. MY VEHICLE IS FULLY PAID FOR AND I DON'T WANT TO HEAR THAT IT IS DUE TO AGE. THERE ARE MANY VEHICLES WITH THIS SAME ISSUE WITH LESS MILE.
NHTSA ODI #11196099
120,000 miles · May 15, 2013
Electrical SystemEnginePower Train
GIVEN THE NEWS (MAY 14/15 2013) OF THE FEDERAL PROP FOR NOTICE OF RECALL FOR CHRYSLER VEHICLES PROBLEMS CUTTING OFF WHILE DRIVING WITH NO WARNING OR INDICATION OF ANY PROBLEM I REQUEST OTHER VEHICLES (IE CHRYSLER VANS) FOR THIS PARTICULAR ISSUE BE SERIOUSLY CONSIDERED AND SUBMIT THE FOLLOWING: (NOTE: I CAN PROVIDE ALL EXACT DATE…
Read full complaint
GIVEN THE NEWS (MAY 14/15 2013) OF THE FEDERAL PROP FOR NOTICE OF RECALL FOR CHRYSLER VEHICLES PROBLEMS CUTTING OFF WHILE DRIVING WITH NO WARNING OR INDICATION OF ANY PROBLEM I REQUEST OTHER VEHICLES (IE CHRYSLER VANS) FOR THIS PARTICULAR ISSUE BE SERIOUSLY CONSIDERED AND SUBMIT THE FOLLOWING: (NOTE: I CAN PROVIDE ALL EXACT DATES/MILES DOCUMENTATION AS THE VEHICLE WAS SERVICED BY CHRYSLER, WOODBRIDGE, VA. I'M ORIGINAL OWNER OF THE VEHICLE.) I WAS DRIVING MY 2002 CHRYSLER TOWN & COUNTRY (VIN CAN BE PROVIDED ON REQUEST) APPROXIMATELY 50 MILES AN HOUR ON ROUTE 50 ABOUT 20 MILES EAST OF WINCHESTER, VA AND MY VEHICLE JUST SHUT OFF. NO INDICATIONS, NO WARNING LIGHT, NO OTHER UNUSUAL NOISES. IT JUST SHUT OFF. LUCKILY THERE WAS LITTLE TRAFFIC AND I COASTED TO THE SHOULDER. I ATTEMPTED TO START THE VEHICLE SEVERAL OCCASION AND IT WOULD NOT TURN ON. ALL VEHICLE LIGHTS (INTERIOR/EXTERIOR) RADIO, FANS ETC WERE OPERATIONAL. I RECALL THE ROADS WERE CLEAR, WEATHER COOL AND IT WAS ALMOST NOON. ULTIMATELY I HAD MY VEHICLE TOWED AND SERVICED BY A CHRYSLER DEALER SERVICE CENTER IN WOODBRIDGE, VA. I DID REPORT THAT THE VEHICLE JUST SHUT OFF AND GAVE FURTHER INFORMATION. AFTER LEAVING THE VEHICLE, IT TOOK THE SERVICE CENTER CLOSE TO APPROXIMATELY A WEEK OR MORE TO DETERMINE WHAT THE PROBLEM COULD BE. ULTIMATELY THE ENGINE COMPUTER MODULE (ECM) WAS REPLACED AND SOME ELECTRICAL WIRING HARNESSES. I ALSO RECALL THE CHRYSLER REP SAYING THEY NEEDED THEIR ELECTRICIAN TO COME AND LOOK AT THE VEHICLE AS THEIR MECHANICS COULD NOT FIND THE PROBLEM. I CAN PROVIDE FURTHER COMMENTS AND RECORDS. I DO BELIEVE THE ECM IN MY VEHICLE WAS CHANGED OUT ONCE BEFORE BY CHRYSLER (POSSIBLE PREVIOUS RECALL (?). I MAY HAVE A PICTURE/INFO ON THE OLDER ECM WITH SERIAL NUMBER/DATE (POSSIBLE 2005). VAN IS RUNNING FINE SINCE NEW ECM AND OTHER ITEMS THAT REPLACED..SO FAR. *TR
NHTSA ODI #10512232
170,000 miles · Nov 13, 2012
Electrical SystemPower TrainVehicle Speed Control
MY 2002 TOWN AND COUNTRY HAD TO HAVE A NEW TRANSMISSION IN 11/12. IN JUNE OF THIS YEAR, MY SPEEDOMETER QUIT WORKING CAUSING THE TRANSMISSION TO SHIFT HARD. I TOOK IT TO THE TRANSMISSION GUY WHO REPLACED THE SPEED SENSOR. IT WORKED FINE FOR A COUPLE OF WEEKS. THEN MY BATTERY LIGHT CAME ON SUDDENLY. I HAD MY BATTERY CHECKED AND TH…
Read full complaint
MY 2002 TOWN AND COUNTRY HAD TO HAVE A NEW TRANSMISSION IN 11/12. IN JUNE OF THIS YEAR, MY SPEEDOMETER QUIT WORKING CAUSING THE TRANSMISSION TO SHIFT HARD. I TOOK IT TO THE TRANSMISSION GUY WHO REPLACED THE SPEED SENSOR. IT WORKED FINE FOR A COUPLE OF WEEKS. THEN MY BATTERY LIGHT CAME ON SUDDENLY. I HAD MY BATTERY CHECKED AND THEY SAID IT WAS FINE. THEY SAID I MIGHT NEED A NEW ALTERNATOR. SO I HAD A NEW ALTERNATOR PUT IN. THE CAR DID OK FOR ABOUT A COUPLE OF WEEKS, THEN THE SPEEDOMETER STARTED JUMPING ERRATICALLY. I TOOK BACK TO MY TRANSMISSION GUY WHO SAID THE SPEED SENSOR WAS FINE. HE THINKS IT MAY BE DUE TO A LOOSE WIRE OR A POSSIBLY DAMAGED WIRE OR CORROSION. SO FAR, NO ANSWERS AND MY CAR IS STILL UNDRIVABLE. IT JUMPS WHEN I AM STOPPED. IT ACTS LIKE ITS ALREADY IN SECOND GEAR OR SOMETHING. I AM AFRAID TO TRY TO DRIVE IT AS IT IS DANGEROUS. HELP! I CAN NOT AFFORD TO PUT MORE MONEY INTO THIS. IT COST TOO MUCH TO START WITH. 3.8L V6 LIMITED. I AM A SINGLE MOM WITH A CHILD WHO HAS HEART DEFECTS. I NEED RELIABLE TRANSPORTATION! *TR
NHTSA ODI #10484568
68,000 miles · Jul 6, 2011
Electrical SystemEngine And Engine CoolingPower Train
TL* THE CONTACT OWNS A 2002 CHRYSLER TOWN AND COUNTRY. WHILE THE CONTACT WAS AT DRIVING VARIOUS SPEEDS THE ENGINE STALLED WITHOUT PRIOR WARNING. THE ENGINE RESTARTED AND THE CONTACT RESUMED NORMALLY. THE FAILURE RECURRED SPORADICALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THEY WERE UNABLE TO LOCATE THE PROBLEM. TH…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHRYSLER TOWN AND COUNTRY. WHILE THE CONTACT WAS AT DRIVING VARIOUS SPEEDS THE ENGINE STALLED WITHOUT PRIOR WARNING. THE ENGINE RESTARTED AND THE CONTACT RESUMED NORMALLY. THE FAILURE RECURRED SPORADICALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THEY WERE UNABLE TO LOCATE THE PROBLEM. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 68,000. UPDATED 8/29/11 *CN THE CONSUMER ALSO STATED THE VEHICLE HAD ELECTRICAL PROBLEMS AND THE PCM FAILED. UPDATED 10/05/11
NHTSA ODI #10410735
96,000 miles · Jun 9, 2010
Power Train
TL* THE CONTACT OWNS A 2002 CHRYSLER TOWN & COUNTRY. WHILE DRIVING AT 55 MPH, THE CONTACT NOTICED THAT THE VEHICLE WOULD NO LONGER ACCELERATE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALERSHIP WHERE THE TRANSMISSION WAS REPLACED. HOWEVER, 6 MILES AFTER THE REPAIR THE SAME FAILURE OCCURRED. PRIOR TO THE FAILURE, THE CONTACT HAD …
Read full complaint
TL* THE CONTACT OWNS A 2002 CHRYSLER TOWN & COUNTRY. WHILE DRIVING AT 55 MPH, THE CONTACT NOTICED THAT THE VEHICLE WOULD NO LONGER ACCELERATE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALERSHIP WHERE THE TRANSMISSION WAS REPLACED. HOWEVER, 6 MILES AFTER THE REPAIR THE SAME FAILURE OCCURRED. PRIOR TO THE FAILURE, THE CONTACT HAD THE TRANSMISSION FLUSHED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 96,000.
NHTSA ODI #10335566
90,380 miles · Jun 3, 2009
Power Train
PLANETARIES DESTROYED IN TRANSMISSION AND REQUIRED REPLACEMENT REPLACED TRANSMISSION ASSEMBLY WITH REMANUFACTURED UNIT TOTAL COST: $2582.70 LEFT US STRANDED APPROXIMATELY FORTY MILES FROM HOME. *TR
NHTSA ODI #10272804
97,000 miles · Jul 9, 2008
Power Train
TRANSMISSION ISSUES SINCE WE BOUGHT IT. LAST ISSUE CURRENTLY HAS NOT BEEN RESOLVED. *TR
NHTSA ODI #10233667
68,000 miles · Jul 3, 2008
Power Train
I BOUGHT A CHRYSLER TOWN AND COUNTRY AND THE TRANSMISSION SHIFTS HARD INTO 2ND GEAR. AFTER THE 4TH TIME TO THE DEALER AND TRANSMISSION SPECIALIST THE TRANSMISSION SPECIALIST FINALLY TOOK THE VAN TO AUTO WEST DODGE. AUTO WEST DODGE SAID THEY HAVE A HISTORY ON THE VEHICLE FROM THE PREVIOUS OWNER AND AS OF NOW THERE IS NO FIX FOR…
Read full complaint
I BOUGHT A CHRYSLER TOWN AND COUNTRY AND THE TRANSMISSION SHIFTS HARD INTO 2ND GEAR. AFTER THE 4TH TIME TO THE DEALER AND TRANSMISSION SPECIALIST THE TRANSMISSION SPECIALIST FINALLY TOOK THE VAN TO AUTO WEST DODGE. AUTO WEST DODGE SAID THEY HAVE A HISTORY ON THE VEHICLE FROM THE PREVIOUS OWNER AND AS OF NOW THERE IS NO FIX FOR THE TRANSMISSION, BECAUSE IT IS A COMPUTER PROBLEM NOT A MECHANICAL PROBLEM. I STILL HAVE THE PROBLEM AND THEY SAY I AM GOING TO HAVE TO WAIT FOR A FIX. THE SHIFTING OCCURS EVERY TIME I DRIVE THE CAR. THE TRANSMISSION SPECIALIST HAS REBUILD THE TRANSMISSION, BUT CAN NOT FIX THE COMPUTER AND AUTO WEST DODGE SAID THEY CAN NOT FIX THE COMPUTER AT THIS TIME EITHER. *TR
NHTSA ODI #10233150
81,500 miles · Dec 13, 2007
Power Train
BOUGHT 2002 T&C EX USED FROM CHRYSLER DEALER IN XENIA, OHIO. ALL MAINTENANCE DONE BY SAME DEALERSHIP. CAR HAS 52,000 MILES ON IT. AFTER GETTING HOME FROM VACATION TRANSMISSION SUDDENLY DIED - NO WARNING. MECHANIC FOUND 9 CODES AND ONE THAT REFERENCED NO HYDRAULIC PRESSURE. THEY CHECKED THE TRANSMISSION FILTER AND FOUND IT T…
Read full complaint
BOUGHT 2002 T&C EX USED FROM CHRYSLER DEALER IN XENIA, OHIO. ALL MAINTENANCE DONE BY SAME DEALERSHIP. CAR HAS 52,000 MILES ON IT. AFTER GETTING HOME FROM VACATION TRANSMISSION SUDDENLY DIED - NO WARNING. MECHANIC FOUND 9 CODES AND ONE THAT REFERENCED NO HYDRAULIC PRESSURE. THEY CHECKED THE TRANSMISSION FILTER AND FOUND IT TO BE CLEAN - TRANSMISSION FAILED WITH LESS THAN 65K MILES ON IT. TRANSMISSION FLUID WAS A PROPER LEVELS AND WAS NOT BURNT IN ANY WAY - STILL A NICE RED COLOR. REPLACED TRANSMISSION WITH A JASPER REMAN WITH 3 YR/75K MILES WARRANTY AND THAT TRANSMISSION JUST FAILED WITH LESS THAN 20,000 MILES ON IT WHILE 60+ MILES FORM HOME WITH BOTH OF OUR KIDS IN THE CAR. LUCKILY WE WERE ABLE TO GET THE CAR TO OUR DESTINATION AND NOT STRANDED ON THE HIGHWAY. THIS TIME 3RD GEAR APPARENTLY DIED AND OUR MECHANIC MENTIONED THAT THIS IS A POPULAR TRANSMISSION AND VERY POPULAR FOR FAILING. *TR
NHTSA ODI #10211784
Official recalls
4Nov 2, 2004
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 5, 2004
ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.
Remedy: DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Oct 8, 2002
ON CERTAIN MINI VANS, THE FUEL TANK CONTROL VALVE WELD JOINT COULD SEPARATE RESULTING IN A POSSIBLE FUEL LEAK.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERBODY FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY. OWNER NOTIFICATION BEGAN OCTOBER 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Oct 4, 2001
VEHICLE DESCRIPTION: CERTAIN MINI VANS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER MANUALS SUPPLIED WITH THESE VEHICLES DO NOT INDICATE WHICH SEATING POSITIONS ARE EQUIPPED WITH TETHER ANCHORAGES AND CHILD RESTRAINT ANCHORAGE SYSTEMS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH THE NECESSARY CHILD RESTRAINT SYSTEM INFORMATION. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 8, 2001. OWNERS WHO DO NOT RECEIVE THE FREE INFORMATION WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA05009 · Headlight Malfunction
Opened Jun 1, 2005 · Closed May 2, 2006
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
PE05004 · Headlight Malfunction
Opened Feb 2, 2005 · Closed Jun 1, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
EA04031 · Power Liftgate Latch
Opened Nov 22, 2004 · Closed Apr 7, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Additional source detail variants (2)
Latches/locks/linkages
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
PE04049 · Speaker Fire In The Rear Of The Vehicle
Opened Jul 7, 2004 · Closed Nov 5, 2004
Status: closed (inferred from source dates) · Electrical System:wiring: Rear Compartment/trunk; Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System:wiring: Rear Compartment/trunk
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE03012 · Power Steering Hose Failure
Opened Apr 9, 2003 · Closed May 29, 2003
Status: closed (inferred from source dates) · Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid; Steering:hydraulic Power Assist:pump; Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
Additional source detail variants (5)
Steering:hydraulic Power Assist:hose, Piping, And Connections
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:power Steering Fluid
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:pump
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist System
PLEASE SEE ATTACHED REPORT.
Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
PE02068 · Fuel Tank Leak
Opened Sep 24, 2002 · Closed Oct 9, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
Illustration