THE VAN WAS PROFESSIONALLY MODIFIED STRAIGHT FROM FACTORY BY INDEPENDENT MOBILITY SYSTEMS, INC (IMS) A COMPANY OUT OF BUSINESS THAT SPECIALIZED IN THESE MODIFICATIONS. I PREVIOUSLY REPORTED BACK AROUND EARLY 2006 ABOUT A SAFETY PROBLEM THAT I HAD EXPERIENCED WITH THE VEHICLES REAR SHOCK-ABSORBER LOWER TIE-DOWN BRACKETS. IN MY…
Read full complaint
THE VAN WAS PROFESSIONALLY MODIFIED STRAIGHT FROM FACTORY BY INDEPENDENT MOBILITY SYSTEMS, INC (IMS) A COMPANY OUT OF BUSINESS THAT SPECIALIZED IN THESE MODIFICATIONS. I PREVIOUSLY REPORTED BACK AROUND EARLY 2006 ABOUT A SAFETY PROBLEM THAT I HAD EXPERIENCED WITH THE VEHICLES REAR SHOCK-ABSORBER LOWER TIE-DOWN BRACKETS. IN MY COMPLAINT I EXPLAINED THAT I HAD EXPERIENCED A TERRIFYING INCIDENT WHILE TRAVELING AT 50 MPH THE LEFT BRACKET BROKE AT THE WELD THAT CONNECTED IT TO THE REAR AXLE, CAUSING THE HIGHLY PRESSURIZED SHOCK-ABSORBER TO EXTEND AND JAMMED AGAINST THE PAVEMENT AND THE AXLE. THIS CAUSED THE REAR OF THE VEHICLE TO JUMP AND SHUTTER VIOLENTLY AND MAKING ME STOP RAPIDLY. REPAIRED AT THE COST OF $100.00. ON THIS OCCASION I WAS IN A PARKING LOT AND DRIVING OVER A SPEED BUMP WHEN THE WELD ON THE RIGHT SIDE BRACKET BROKE OFF. AGAIN I TOWED IT TO A MIDAS AT DIFFERENT LOCATION AND SPENT $45.00 ON THE REPAIR. WELL THIS WAS REPORTED TO BRAUN ENTERPRISES , A COMPANY THAT SPECIALIZED IN THESE MODIFICATIONS THAT HAS TAKEN UP WARRANTY AND PARTS ISSUES FROM IMS. THEIR RESPONSE WAS THAT SINCE THE VEHICLE WAS PAST ITS WARRANTY PERIOD THEY WOULD NOT BE WILLING TO COVER THE REPAIRS. THIS RESULTED IN MY FIRST REPORT TO DOT. THE REASON FOR MY REPEATING THIS REPORT WAS THAT IT HAS HAPPENED AGAIN TO ONE OF THE SAME BRACKETS. THIS HAPPENED THREE TIMES. IN MY INITIAL REPORT I STATED THAT THE REASON I SUSPECTED THIS HAPPENED WAS DUE TO FAULTY ENGINEERING. SINCE THE BRACKETS WHERE LOCATED LOWER THAN ANY OTHER PARTS IN THE BOTTOM OF THE VEHICLE IT WAS PROBABLY SUSCEPTIBLE TO ROAD OBSTACLES. I FURTHER SUGGESTED THAT ANOTHER CAUSE MIGHT BE DUE TO WHERE THE BRACKETS WERE PLACED AND THE MANNER IN WHICH THEY WERE MOUNTED THAT WAS NOT SUFFICIENT TO WITHSTAND THE PRESSURES OF EVERYDAY DRIVING. REMEMBER THESE MODIFICATIONS WERE DONE ON VEHICLES THAT TRANSPORT PEOPLE WITH MOBILITY EFFECTED CHALLENGES. *AK
WE BOUGHT A USED 2002 CHRYSLER TOWN AND COUNTRY MINIVAN FROM A CAR RENTAL COMPANY HERE IN SACRAMENTO CALIFORNIA. THE VIN # IS [XXX]. THE VEHICLE WAS IN EXCELLENT CONDITION WITH ABOUT 24,000 MILES ON IT WE BOUGHT IT. A COUPLE OF MONTHS AFTER WE BOUGHT THE VEHICLE, THE ABS LIGHT WENT ON INDICATING THAT THE ABS BRAKE SYSTEM AND…
Read full complaint
WE BOUGHT A USED 2002 CHRYSLER TOWN AND COUNTRY MINIVAN FROM A CAR RENTAL COMPANY HERE IN SACRAMENTO CALIFORNIA. THE VIN # IS [XXX]. THE VEHICLE WAS IN EXCELLENT CONDITION WITH ABOUT 24,000 MILES ON IT WE BOUGHT IT. A COUPLE OF MONTHS AFTER WE BOUGHT THE VEHICLE, THE ABS LIGHT WENT ON INDICATING THAT THE ABS BRAKE SYSTEM AND THE TRACTION CONTROL SYSTEMS WERE MALFUNCTIONING. WE TOOK IT INTO A DEALER HERE IN TOWN AND THEY REPLACED A REAR WHEEL SPEED SENSOR. A FEW MONTHS LATER THE ABS LIGHT CAME ON AGAIN AND WE TOOK IT BACK TO THE DEALER. THEY CHECKED IT OUT AND SAID THE WHEEL SENSOR WAS SHOWING BAD AGAIN. THEY REPLACED THE WHEEL SPEED SENSOR AGAIN. NOW IT IS ABOUT 3 WEEKS AFTER THAT MOST RECENT REPAIR AND THE ABS LIGHT CAME ON AGAIN. WE WERE ON VACATION AT THE TIME AND DROVE ABOUT 1000 MILES WITHOUT ABS BRAKES OR TRACTION CONTROL AS IT WAS INCONVENIENT TO TAKE IT IN WHILE ON VACATION. I DID NOT RECEIVE THE OLD PART EITHER TIME BEFORE BUT I WILL GET IT THIS TIME. BY THE WAY THE VEHICLE IS OUTSIDE OF WARRANTY NOW AND CHRYSLER HAS DECLINED TO REPAIR IT WITHOUT CHARGE. WE FEEL THIS IS A SAFETY ISSUE AS WE ARE DRIVING FOR CONSIDERABLE PERIODS OF TIME WITHOUT 2 IMPORTANT SAFETY FEATURES THAT CAME WITH THE VEHICLE; ANTILOCK BRAKES AND TRACTION CONTROL. WE ARE CONCERNED THAT THEY CAN'T SEEM TO GET THIS PROBLEM RESOLVED. WE ARE ALSO CONCERNED THAT OTHERS MAY BE EXPERIENCING THE SAME PROBLEM AND IT IS NOT GETTING RESOLVED. THIS SEEMS TO BE A DEFECT WITH THE ABS SYSTEM OR PARTS WITHIN THE ABS SYSTEM OF THIS CHRYLSER MODEL.*AK UPDATED 07/25/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.
Remedy: DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINI VANS, THE FUEL TANK CONTROL VALVE WELD JOINT COULD SEPARATE RESULTING IN A POSSIBLE FUEL LEAK.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERBODY FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY. OWNER NOTIFICATION BEGAN OCTOBER 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: CERTAIN MINI VANS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER MANUALS SUPPLIED WITH THESE VEHICLES DO NOT INDICATE WHICH SEATING POSITIONS ARE EQUIPPED WITH TETHER ANCHORAGES AND CHILD RESTRAINT ANCHORAGE SYSTEMS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH THE NECESSARY CHILD RESTRAINT SYSTEM INFORMATION. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 8, 2001. OWNERS WHO DO NOT RECEIVE THE FREE INFORMATION WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
EA04031 · Power Liftgate Latch
Opened Nov 22, 2004 · Closed Apr 7, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Additional source detail variants (2)
Latches/locks/linkages
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
PE04049 · Speaker Fire In The Rear Of The Vehicle
Opened Jul 7, 2004 · Closed Nov 5, 2004
Status: closed (inferred from source dates) · Electrical System:wiring: Rear Compartment/trunk; Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System:wiring: Rear Compartment/trunk
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE03012 · Power Steering Hose Failure
Opened Apr 9, 2003 · Closed May 29, 2003
Status: closed (inferred from source dates) · Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid; Steering:hydraulic Power Assist:pump; Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
Additional source detail variants (5)
Steering:hydraulic Power Assist:hose, Piping, And Connections
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:power Steering Fluid
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:pump
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist System
PLEASE SEE ATTACHED REPORT.
Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
PE02068 · Fuel Tank Leak
Opened Sep 24, 2002 · Closed Oct 9, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
2002 Chrysler Town And Country Problems, Complaints & Recalls | Skip That Year
Illustration