Electrical SystemEngine And Engine CoolingFuel System, Gasoline
THE VEHICLE MADE A KNOCKING NOISE IN THE FRONT END. THE DEALER REPLACED THE FRONT SUSPENSION STRUT, STRUT MOUNT, FRONT SWAY BAR AND SWAY BAR LINK. THE REAR END OF THE VEHICLE ALSO MADE NOISE. THE DEALER REPLACED THE TRANSFER GEAR SET. THE VEHICLE ALSO EXPERIENCED A WHINING NOISE IN THE STEERING WHEEL. THE DEALER REPLACED TH…
Read full complaint
THE VEHICLE MADE A KNOCKING NOISE IN THE FRONT END. THE DEALER REPLACED THE FRONT SUSPENSION STRUT, STRUT MOUNT, FRONT SWAY BAR AND SWAY BAR LINK. THE REAR END OF THE VEHICLE ALSO MADE NOISE. THE DEALER REPLACED THE TRANSFER GEAR SET. THE VEHICLE ALSO EXPERIENCED A WHINING NOISE IN THE STEERING WHEEL. THE DEALER REPLACED THE SPRING CLOCK ALONG WITH THE SHROUD STABILIZER. POWER STEERING FLUID DUE IT BEING CLOG AND CAUSED THE STEERING TO WHINE WHEN TURNED. THE REAR LIFT GATE WOULD NOT OPEN WITH THE REMOTE. FAULTY FRONT ROTORS SQUEAKED WHEN APPLIED. THE DRIVERS SIDE WINDOW WOULD NOT GO UP DUE TO A FAULTY REGULATOR. THE CRUISE CONTROL WOULD NOT DISABLE WHEN THE BRAKES WERE APPLIED AND THE BRAKES WOULD NOT WORK WHEN THE CRUISE CONTROL WAS ENGAGED. THE REAR WINDSHIELD WIPERS WERE INOPERATIVE. THE ENGINE MADE NOISE WHEN STARTED. THE TIMING CHAIN FAILED AND CAUSED THE CHECK ENGINE LIGHT TO ILLUMINATE. THE O-RINGS FAILED AND CAUSED FUEL ODOR INSIDE THE VEHICLE. *SCC *NLM
NHTSA ODI #10021582
Mileage unknown · Apr 23, 2003
Fuel System, Gasoline
THERE WAS A QUARTER SIZE HOLE IN THE VEHICLES FUEL TANK WHICH CAUSED FUEL TO LEAK. THE DEALER WAS NOTIFIED BUT COULD NOT EXPLAIN HOW FUEL TANK WAS PUNCTURE. *NLM
NHTSA ODI #10017455
Mileage unknown · Jun 24, 2002
Fuel System, Gasoline
CONSUMER IS CONCERNED WITH A POTENTIAL GAS LEAK WHICH MAY OCCUR IF THE VEHICLE IS INVOLVED IN A FRONTAL COLLISION AT A LOW SPEED, CONSUMERS VEHICLE WAS MANFACTURERD PRIOR TO THE TIME THE MANUFACTURER REDESIGNED AND BEGAN INSTALLING REPLACEMENT PARTS TO CORRECT THE PROBLEM, CONSUMER IS REQUESTING THAT THE PART BE REPLACED OR BE G…
Read full complaint
CONSUMER IS CONCERNED WITH A POTENTIAL GAS LEAK WHICH MAY OCCUR IF THE VEHICLE IS INVOLVED IN A FRONTAL COLLISION AT A LOW SPEED, CONSUMERS VEHICLE WAS MANFACTURERD PRIOR TO THE TIME THE MANUFACTURER REDESIGNED AND BEGAN INSTALLING REPLACEMENT PARTS TO CORRECT THE PROBLEM, CONSUMER IS REQUESTING THAT THE PART BE REPLACED OR BE GIVEN A NEW VEHICLE ENTIRELY THAT DOES NOT HAVE A GAS LEAK PROBLEM.*JB
NHTSA ODI #566735
Mileage unknown · Feb 22, 2002
Fuel System, Gasoline
THE INSURANCE INSTITUTE FOR HIGHWAY SAFETY HAS CONDUCTED TWO 40 MPH CRASH TESTS AND BOTH RESULTED IN A FUEL LEAK. THEY DETERMINED THAT "A WEAKNESS IN THE DESIGN OF A CIRCULAR FITTING WHERE THE FUEL LINES EXIT THE FUEL TANK". CHRYSLER REDESIGNED AND BEGAN. *AK
NHTSA ODI #758487
Mileage unknown · Sep 25, 2001
Fuel System, Gasoline
ENGINE CHECK LIGHT COMES AND A SMELL FROM EXHAUST IS ON INSDE AND OUTSIDE OF VEHICLE. DEALER HAS CONFIRMED THAT INJECTORS WERE LEAKING. MANUFACTURER STATED THERE WAS A RECALL ONLY FOR CALIFORNIA RESIDENTS. *AK
NHTSA ODI #896840
Mileage unknown · Jul 19, 2001
Fuel System, Gasoline
I HAVE NOT YET HAD AN ACCIDENT, BUT, BASED UPON THE RECENT ' REPORTS WISH TO DEMAND A RECALL OF THE 2001 DAIMLER/CHRYSLER MINIVANS, AS THEIR FUEL TANKS LEAKED ON MORE THAN ONE OCCASION DURING TESTING. PLEASE HELP FORCE THIS RECALL. I HAVE CONTACTED DAIMLER CHRYSLER VIA MAIL AND EMAIL, AND, THUS FAR, THEY HAVE BEEN UNRESPONSIVE…
Read full complaint
I HAVE NOT YET HAD AN ACCIDENT, BUT, BASED UPON THE RECENT ' REPORTS WISH TO DEMAND A RECALL OF THE 2001 DAIMLER/CHRYSLER MINIVANS, AS THEIR FUEL TANKS LEAKED ON MORE THAN ONE OCCASION DURING TESTING. PLEASE HELP FORCE THIS RECALL. I HAVE CONTACTED DAIMLER CHRYSLER VIA MAIL AND EMAIL, AND, THUS FAR, THEY HAVE BEEN UNRESPONSIVE. THANK YOU! *AK
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINIVANS. THE LOWER CONTROL ARM PIVOT BOLT COULD FRACTURE.
Consequence & remedy
Consequence: IF THE BOLT FRACTURES, THE LOWER CONTROL ARM COULD SEPARATE FROM THE CROSSMEMBER, CAUSING A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT LOWER CONTROL ARM BOLTS AND NUTS. OWNER NOTIFICATION BEGAN APRIL 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
EA04031 · Power Liftgate Latch
Opened Nov 22, 2004 · Closed Apr 7, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Additional source detail variants (2)
Latches/locks/linkages
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
2001 Chrysler Town And Country Problems, Complaints & Recalls | Skip That Year
Illustration