Electrical System. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Hybrid Propulsion System. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Back Over Prevention. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

Engine complaints

5 reports

Clear category filter

30,000 miles · Oct 3, 2024

EngineHybrid Propulsion System

The contact owns a 2021 Chrysler Pacifica Hybrid. The contact stated while driving 60 MPH, the check engine warning light illuminated. The vehicle was diagnosed, and it was determined that the battery had failed and needed to be replaced. The vehicle was not repaired. The VIN was not included in NHTSA Campaign Number: 24V538000 …

Read full complaint

NHTSA ODI #11617946

60,682 miles · Jun 4, 2024

Engine

Read full complaint

The contact owns a 2021 Chrysler Pacifica Hybrid. The contact stated while driving 70 MPH on the freeway, the vehicle lost power and stalled. After several minutes, the vehicle restarted. The “Service Engine - Stop Soon” message was displayed. The vehicle had previously been taken to the local dealer, Huntington Beach Chrysler Dodge Jeep (16701 Beach Blvd., Huntington Beach, CA 92647), where the computer was programmed, but the failure recurred. The manufacturer was contacted, but no assistance was provided. The approximate failure mileage was 60,682.

NHTSA ODI #11592412

15,000 miles · Mar 9, 2023

Electrical SystemEngineHybrid Propulsion System

Read full complaint

The contact owns a 2021 Chrysler Pacifica Hybrid. The contact stated that while driving at various speeds, the check engine warning light illuminated. The contact received notification of NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available. The failure mileage was approximately 15,000.

NHTSA ODI #11510979

31,000 miles · Mar 7, 2023

Electrical SystemEngineHybrid Propulsion System

Read full complaint

The contact owns a 2021 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The check engine warning light illuminated, and the vehicle failed to switch to the electrical system at initial start-up intermittently, and instead used fuel. The sensor to detect the temperature and cooling for the battery failed and needed to be replaced. The manufacturer was made aware of the failure. The approximate failure mileage was 31,000. VIN tool confirms parts not available. The consumer stated certain things are incorrect and not related to the safety complaint. This was a separate incident and was repaired. The complaint involving the part for 23V-010 recall was not available. However when the dealer was called the recall could be repaired by computer software input and was repaired on 03/14/23.

NHTSA ODI #11510532

20,000 miles · Nov 22, 2022

Engine

Read full complaint

The contact owns a 2021 Chrysler Pacifica Hybrid. The contact stated while driving at slower speeds, the service charging station light illuminated, and the vehicle stalled. The contact stated that after waiting for 10 to 15 minutes, he was able to restart the vehicle. The contact also stated that the check engine warning light intermittently illuminated. The vehicle was taken to the dealer where it had not yet been diagnosed. The vehicle was not repaired. the manufacturer was not notified of the failure. The failure mileage was approximately 20,000.

NHTSA ODI #11494618

Official recalls

24V538000 · Hybrid Propulsion System

Jul 18, 2024

Chrysler (FCA US, LLC) is recalling certain 2019-2021 Pacifica Plug-In Hybrid Electric (PHEV) vehicles. The battery pack may cause a vehicle fire when parked, even with the ignition in the "Off" position.

Consequence & remedy

Consequence: A vehicle fire increases the risk of injury.

Remedy: Owners are advised not to charge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed free of charge. Owner notification letters were mailed March 6, 2025. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is 72B. This recall is an expansion of NHTSA recall number 22V-077.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ24004 · Loss Of Motive Power Due To An Internal Wiring Connector Short.

Opened Feb 27, 2024 · No close date supplied

Status: open (inferred from source dates) · Electrical System:wiring

On July 22, 2022, the Office of Defects Investigation (ODI) opened investigation PE22-008 regarding complaints alleging a loss of motive power condition potentially due to a transmission malfunction in Model Years 2019-2021 Chrysler Pacifica Plug-In Hybrid Electric Vehicles (PHEV). On January 17, 2023, Fiat Chrysler Automobiles (FCA) issued safety recall (NHTSA Recall 23V-010) involving 2017-2023 Model Years (MY) Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016, through January 9, 2023. The recall states that the loss of motive power condition in these vehicles is caused by an internal transmission wiring connector that may short circuit, resulting in an unexpected engine shutdown. An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash. In discussions with FCA on Recall 23V-010, ODI confirmed the recall was related to investigation PE22-008. The remedy for 23V-010 is to update the Power Inverter module (PIM) and/or Instrument Panel Cluster (IPC) software to provide drivers a message stating “Stop Safely - Vehicle Will Shut Off Soon” followed by a chime and MIL, PRNDL blinking (on cluster and shifter knob), low SOC (State of Charge) warning and reduced power mode. The recall remedy does not replace the defective hardware that was described in Recall 23V-010, and the wiring connector short still exists on these vehicles. To date, ODI has received 132 reports for the population of vehicles subject to recall 23V-010. These reports allege a loss of motive power condition that reduces the vehicles speed, followed by dashboard warning lamps displaying messages associated with recall 23V-010. The presence of these warning lamps and messages indicates the vehicle likely had the recall remedy applied. Follow up discussions with FCA confirm their remedy does not prevent a loss of motive power, but instead limits torque to the engine and after an unspecified number of miles or period of time, the engine will shut down. When this occurs, FCA relies on the owner to transport the vehicle to a dealership after they experience a loss of motive power condition, at which time the defective hardware is replaced. Furthermore, the dashboard messages introduced in the recall remedy may cause the driver to pull over in an unsafe location. Pulling over in an unsafe location may expose the occupants to undue harm. The Office of Defects Investigation is opening this Recall Query (RQ) to assess the adequacy, frequency, and safety consequence of the remedy for recall 23V-010. To review the ODI reports cited in the opening resume ODI report identification number document, go to NHTSA.gov.