NHTSA owner reports · September 18, 2026 snapshot.
Equipment complaints
12 reportsClear category filterMileage unknown · Jan 15, 2004
Engine And Engine CoolingEquipmentFuel System, Gasoline
WE ARE NOW ABOUT TO PUT IN OUR 3RD 95 CIRRUS TRANSMISSION AND 2ND 95 CONCORDE TRANSMISSION AND FEEL THAT CHRYSLER SHOULD PAY FOR THE COST OF REPAIRS. I HAVE SHELLED OUT NEARLY $12,000 BETWEEN THE TWO CARS IN THE LAST 6 YEARS FOR REPEATED FAILURES IN ENGINES, WATER PUMPS, STEERING ASSEMBLY FAILURES, TRANSMISSIONS, BRAKE SYSTEMS,…
Read full complaint
WE ARE NOW ABOUT TO PUT IN OUR 3RD 95 CIRRUS TRANSMISSION AND 2ND 95 CONCORDE TRANSMISSION AND FEEL THAT CHRYSLER SHOULD PAY FOR THE COST OF REPAIRS. I HAVE SHELLED OUT NEARLY $12,000 BETWEEN THE TWO CARS IN THE LAST 6 YEARS FOR REPEATED FAILURES IN ENGINES, WATER PUMPS, STEERING ASSEMBLY FAILURES, TRANSMISSIONS, BRAKE SYSTEMS, RADIOS, AIR CONDITIONERS, FUEL RAILS, ALTERNATORS AND COMPUTER PCM'S TO NAME A FEW. BY FAR THE WORST QUALITY CARS AND HIGHEST COST OF OWNERSHIP OF ANY CARS I HAVE OWNED IN THE LAST 30 YEARS. SOMETHING MAJOR GOES WRONG WITH THESE CARS EVERY FEW MONTHS.
NHTSA ODI #10071236
Mileage unknown · Mar 15, 2000
Equipment
ON THREE SEPARATE OCCASIONS THE AIR CONDITIONER QUIT COOLING FIRST TWO TIMES DEALER COULD NOT FIND COOLANT LEAK. ON THE SECOND RECHARGE OF THE COOLING SYSTEM THE DEALER ADDED A LEAK DETECTION DYE TO THE SYSTEM SO IF IT QUIT WORKING AGAIN IT WOULD BE EASYER TO FIND LEAK. ON 7 MARCH 2000 WE TESTED THE AIRCONDITIONER, AND AGAIN IT …
Read full complaint
ON THREE SEPARATE OCCASIONS THE AIR CONDITIONER QUIT COOLING FIRST TWO TIMES DEALER COULD NOT FIND COOLANT LEAK. ON THE SECOND RECHARGE OF THE COOLING SYSTEM THE DEALER ADDED A LEAK DETECTION DYE TO THE SYSTEM SO IF IT QUIT WORKING AGAIN IT WOULD BE EASYER TO FIND LEAK. ON 7 MARCH 2000 WE TESTED THE AIRCONDITIONER, AND AGAIN IT DID NOT WORK. TOOK TO DIFFERENT DEALER , THEY FOUND THE LEAK IN THE EVAPORATER CORE WHICH WAS STILL UNDER WARRANTY. THE DEALER DID REPAIR AT NO COST TO ME. BUT THE FIRST TWO TIME I HAD TO PAY FOR CHARGING THE SYSTEM. I NEED TO KNOW HOW GET REIMBURSED FOR THOSE EXPENSES SINCE IT WAS A WARRANTY ITEM ALL THE TIME. THE CHARGES I INCURRED TOTALED TO $103.58. *AK
NHTSA ODI #720138
Mileage unknown · Mar 9, 2000
Electrical SystemEquipmentSteering
STEERING PUMP FAILED. NLM
NHTSA ODI #551288
Mileage unknown · Dec 9, 1999
Engine And Engine CoolingEquipmentFuel System, Gasoline
FRONT END STRUTS WRE REPLACED AFTER REPORTING CLUNKING NOISE IN FRONT END WHEN CAR WAS PLACED IN REVERSE. ONE YEAR LATER, WHILE ENROUTE FROM PENNSYLVANIA TO WASHINGTON ON VACATION, THE STEERING BROKE WHEN BACKING OUT OF A PARKING SPACE IN AN UNDERGROUND PARKING LOT IN SOUTH BEND, IN. RACK AND PINION WAS REPAIRED BY DEALERSHIP …
Read full complaint
FRONT END STRUTS WRE REPLACED AFTER REPORTING CLUNKING NOISE IN FRONT END WHEN CAR WAS PLACED IN REVERSE. ONE YEAR LATER, WHILE ENROUTE FROM PENNSYLVANIA TO WASHINGTON ON VACATION, THE STEERING BROKE WHEN BACKING OUT OF A PARKING SPACE IN AN UNDERGROUND PARKING LOT IN SOUTH BEND, IN. RACK AND PINION WAS REPAIRED BY DEALERSHIP IN SOUTH BEND. STARTED TO SMELL GAS FUMES IN VEHICLE WHILE DRIVING TO WASHINGTON. TRIED TO GET REPAIRS IN SOUTH DAKOTA BUT WAS UNABLE TO FIND A DEALERSHIP WHO WOULD REPAIR IT. LOCATED DEALERSHIP IN PASCO, WASHINTON TOREPAIR THE FUEL LINE WHICH WAS NOT CONNECTED PROPERLY AFTER RACK REPAIR, AS I WAS TOLD BY DEALER. BATTERY EXPLODED WHILE IN PARKING LOT AT LOCAL MALL. AIR CONDITIONER STARTED EMITTING MUSTY SMELL. HAD AIR CONDITIONER CHARGED TWICE AND IT STILL DOESNT SEEM TO HOLD A CHARGE. CAR WOULD NOT START ON 12/3/1999. THINKING IT WAS THE BATTERY, TRIED TO JUMP THE CAR BUT WAS TOLD BY MECHANIC THAT IT SOUNDED LIKE IT MIGHT BE THE TIMING BELT. NOW I FIND THE WATER PUMP LEAKED WHICH MAY HAVE CAUSED A BLOWN GASKET. MECHANIC REPORTS LITTLE COMPRESSION IN THREE CYLINDERS AND 1500.00 ESTIMATE FOR REPAIR. *AK
NHTSA ODI #715836
Mileage unknown · Oct 23, 1999
EquipmentPower TrainSteering
TIE ROD END SOCKETS AT STEERING BOX COMPLETELY WORN OUT (ELONGATED). AIR CONDITIONER COMPRESSOR FAILED. TRANSMISSION FAILED.
NHTSA ODI #713755
Mileage unknown · Sep 29, 1999
Equipment
IN HIGH HUMIDITY CONDITIONS THE A/C CUTS OFF AFTER WORKING FOR AN HOUR AND WILL NOT CUT BACK ON UNTIL ICE MELTS FROM THE EVAPORATOR. DEALER HAS REPLACED THE CONDENSOR TWICE, AND PROBLEM STILL EXISTS. *AK
NHTSA ODI #849144
Mileage unknown · Sep 29, 1999
Engine And Engine CoolingEquipmentVisibility
NO SUMMARY.
NHTSA ODI #712524
Mileage unknown · May 5, 1999
EquipmentVisibility
AIR CONDITIONING NOT HOLDING A CHARGE. CAR WAS BROUGHT TO PROFESSIONAL AIR CONDITIONING SHOP SYSTEM EVACUATED AND A DYE PUT IN WITH THE FREON. THE TECHNICHAN INFORMED ME RIGHT AWAY THAT THE CHRYSLER CORPORATION HAS HAD DEFECTS IN THESE SYSTEMS SINCE DAY ONE BUT WILL NOT ADMIT TO IT. HE SAID THAT PRACTICALLY EVERY CONCORDE, I…
Read full complaint
AIR CONDITIONING NOT HOLDING A CHARGE. CAR WAS BROUGHT TO PROFESSIONAL AIR CONDITIONING SHOP SYSTEM EVACUATED AND A DYE PUT IN WITH THE FREON. THE TECHNICHAN INFORMED ME RIGHT AWAY THAT THE CHRYSLER CORPORATION HAS HAD DEFECTS IN THESE SYSTEMS SINCE DAY ONE BUT WILL NOT ADMIT TO IT. HE SAID THAT PRACTICALLY EVERY CONCORDE, INTREPID, CIRRUS, JEEP THAT COMES IN EITHER LEAKS IN ONE OF THE THREE SYSTEM, EVAPORATOR, CONDENSOR, DRYER. CHRYSLER CHARGES $950.00 TO REPLACE THE EVAPORATOR!!!! I CAN'T AFFORD THAT COST AND WILL LOSE SUBSTANTIAL MONEY ON THE SALE OF THE VEHICLE WITHOUT A PROPER WORKING AIR CONDITIONING SYSTEM.
NHTSA ODI #706248
Mileage unknown · Apr 19, 1999
Air BagsElectrical SystemEquipment
WHILE DRIVING INSTRUMENT PANEL/AIR BAG LIGHT/AIR CONDITIONING SYSTEM MALFUCTIONED, CAUSING VEHICLE TO STALL, ALMOST CAUSING AN ACCIDENT. THERE IS A TECHNICAL SERVICE BULLETIN ON THIS PROBLEM, BUT DEALER HAS NOT INSPECTED THE VEHICLE. *AK
NHTSA ODI #836840
Mileage unknown · Jun 24, 1998
Equipment
AIR CONDITIONER FAILURE.
NHTSA ODI #537460
NHTSA investigations
9DP04007 · Fuel Rail, Brake Fluid, Chassis
Opened Oct 13, 2004 · Closed Oct 27, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail; Service Brakes, Hydraulic:fluid; Structure:frame And Members
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
Additional source detail variants (3)
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
Service Brakes, Hydraulic:fluid
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
Structure:frame And Members
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
EA99031 · Steering System Rack And Pinion
Opened Oct 29, 1999 · Closed Sep 13, 2001
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE99044 · Steering System Rack And Pinion
Opened Jun 28, 1999 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Steering
SINCE OPENING THE PRELIMINARY EVALUATION (PE), ODI HAS RECEIVED 6 ADDITIONAL COMPLAINTS.DURING THE PE IT WAS DETERMINED MULTIPLE FAILURE MODES ARE INVOLVED IN THIS MATTER.THE WARRANTY CLAIM RATE IS HIGH FOR A STEERING SYSTEM CONCERN.THE ISSUES REPORTED INVOLVE PREMATURE WEAR OUT AT THE RACK AND PINION INTERFACE WITH THE INNER TIE ROD END(S), BINDING AND STICKING OF THE STEERING GEAR, CRACKED OR BROKEN TIE ROD ENDS, SHEARED RACK AND PINION ASSEMBLY BOLTS, AND WEAR OUT OF THE RACK AND PINION MOUNT BUSHINGS.MANY OF THE COMPLAINANTS MENTION STEERING WONDER AND LOOSE STEERING.THREE OF THE MOST RECENT COMPLAINTS ALLEGE A COMPLETE LOSS OF STEERING DUE TO SHEARED BOLTS.ODI IS UPGRADING THIS PE IN ORDER TO PERFORM A THOROUGH TECHNICAL ANALYSIS OF THE VARIOUS SYSTEM FAILURE ALLEGATIONS AND TO QUANTIFY THE EFFECT THAT THESE FAILURES HAVE ON VEHICLE CONTROL.
RQ98018 · Fuel Injection Delivery System Fuel Leak
Opened Oct 7, 1998 · Closed Jul 8, 2002
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System
No summary supplied.
EA98007 · Fuel Injector Assembly Leakage
Opened Mar 10, 1998 · Closed Feb 1, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:fuel Injection System; Fuel System, Gasoline:fuel Injection System:fuel Rail
NITRILE RUBBER SEALS USED IN THE FUEL RAIL ASSEMBLIES OF THE SUBJECT VEHICLES AT THE SUPPLY, RETURN, AND CROSSOVER TUBE FITTINGS, AND AT THE PRESSURE REGULATOR FAIL, RESULTING IN FUEL LEAKAGE IN THE ENGINE COMPARTMENT.ALSO, THE OUTLET (RIGHT) FUEL RAIL MAY LEAK FROM CRACKS AT CERTAIN MOLD GATES IN THE THERMOSET RAIL MATERIAL.CHRYSLER WILL RECALL THE SUBJECT VEHICLES AND STATED THAT IT INTENDS TO REPLACE THE O-RINGS WITH FLUOROCARBON O-RING HAVING GREATER HEAT RESISTANCE CAPABILITY AND ATTACH REINFORCEMENTS TO THE RAIL IN THE AREAS WHERE THE CRACKING CONCERN HAS BEEN KNOWN TO OCCUR MOST FREQUENTLY.RAILS THAT ARE ALREADY CRACKED WILL BE REPLACED BY NEW, REINFORCED RAILS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
NITRILE RUBBER SEALS USED IN THE FUEL RAIL ASSEMBLIES OF THE SUBJECT VEHICLES AT THE SUPPLY, RETURN, AND CROSSOVER TUBE FITTINGS, AND AT THE PRESSURE REGULATOR FAIL, RESULTING IN FUEL LEAKAGE IN THE ENGINE COMPARTMENT.ALSO, THE OUTLET (RIGHT) FUEL RAIL MAY LEAK FROM CRACKS AT CERTAIN MOLD GATES IN THE THERMOSET RAIL MATERIAL.CHRYSLER WILL RECALL THE SUBJECT VEHICLES AND STATED THAT IT INTENDS TO REPLACE THE O-RINGS WITH FLUOROCARBON O-RING HAVING GREATER HEAT RESISTANCE CAPABILITY AND ATTACH REINFORCEMENTS TO THE RAIL IN THE AREAS WHERE THE CRACKING CONCERN HAS BEEN KNOWN TO OCCUR MOST FREQUENTLY.RAILS THAT ARE ALREADY CRACKED WILL BE REPLACED BY NEW, REINFORCED RAILS.
Fuel System, Gasoline:fuel Injection System
NITRILE RUBBER SEALS USED IN THE FUEL RAIL ASSEMBLIES OF THE SUBJECT VEHICLES AT THE SUPPLY, RETURN, AND CROSSOVER TUBE FITTINGS, AND AT THE PRESSURE REGULATOR FAIL, RESULTING IN FUEL LEAKAGE IN THE ENGINE COMPARTMENT.ALSO, THE OUTLET (RIGHT) FUEL RAIL MAY LEAK FROM CRACKS AT CERTAIN MOLD GATES IN THE THERMOSET RAIL MATERIAL.CHRYSLER WILL RECALL THE SUBJECT VEHICLES AND STATED THAT IT INTENDS TO REPLACE THE O-RINGS WITH FLUOROCARBON O-RING HAVING GREATER HEAT RESISTANCE CAPABILITY AND ATTACH REINFORCEMENTS TO THE RAIL IN THE AREAS WHERE THE CRACKING CONCERN HAS BEEN KNOWN TO OCCUR MOST FREQUENTLY.RAILS THAT ARE ALREADY CRACKED WILL BE REPLACED BY NEW, REINFORCED RAILS.
Fuel System, Gasoline:fuel Injection System:fuel Rail
NITRILE RUBBER SEALS USED IN THE FUEL RAIL ASSEMBLIES OF THE SUBJECT VEHICLES AT THE SUPPLY, RETURN, AND CROSSOVER TUBE FITTINGS, AND AT THE PRESSURE REGULATOR FAIL, RESULTING IN FUEL LEAKAGE IN THE ENGINE COMPARTMENT.ALSO, THE OUTLET (RIGHT) FUEL RAIL MAY LEAK FROM CRACKS AT CERTAIN MOLD GATES IN THE THERMOSET RAIL MATERIAL.CHRYSLER WILL RECALL THE SUBJECT VEHICLES AND STATED THAT IT INTENDS TO REPLACE THE O-RINGS WITH FLUOROCARBON O-RING HAVING GREATER HEAT RESISTANCE CAPABILITY AND ATTACH REINFORCEMENTS TO THE RAIL IN THE AREAS WHERE THE CRACKING CONCERN HAS BEEN KNOWN TO OCCUR MOST FREQUENTLY.RAILS THAT ARE ALREADY CRACKED WILL BE REPLACED BY NEW, REINFORCED RAILS.
EA95028 · Underhood Fuel Leaks
Opened Sep 22, 1995 · Closed Feb 24, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WAARRANTED BY THE CIRCUMSTANCES.AN ENGINEERING ANALYSIS CLOSSING REPORT IS INCLUDED IN THE PUBLIC FILE.
EA95023 · Water In Defroster System
Opened Aug 31, 1995 · Closed Dec 31, 1996
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE THE ENGINEERING ANALYSIS CLOSING REPORT (EA95-023)
Illustration