IllustrationNO HEAT COMING OUT OF PASSENGER SIDE VENTS AND REDUCED HEAT COMING OUT OF DRIVER SIDE VENTS. I HAD THE SYSTEM REVERSE FLUSHED AND REPLACED WITH NEW COOLANT AND DID NOT FIX THE PROBLEM. THIS PROBLEM CAUSES REDUCED VISIBILITY DUE TO INEFFECTIVE DEFROSTING OF WINDSHIELD AND SIDE WINDOWS.
2011 Chrysler 200
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2011 Chrysler 200 do not stand out strongly from the model-year median of 336.
About this comparison →How this year compares
Owner complaints by model year
Compare all 200 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1080–25K
2925–50K
4050–75K
2475–100K
41100–150K
13150K+
255 reports with mileage · 81 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports3 fire reports8 injury reports
Visibility/wiper complaints
15 reportsHEATER CORE PLUGS FROM THE DEXCOOL BRAKING DOWN, THEN FINALLY STARTS TO LEAK CAUSING LACK OF HEAT, EVENTUALLY FOGGING THE WINDOWS SO YOU CAN'T SEE CAUSING MULTIPLE SAFETY HAZARDS. COMMON PROBLEM FROM WHAT I SEE ON LINE! YOU DON'T REALIZE IN SUMMER WHEN YOU BUY THE CAR TILL YOU GO TO USE IT IN THE SPRING AND IT'S NOT COVERED UN…
Read full complaint
HEATER CORE PLUGS FROM THE DEXCOOL BRAKING DOWN, THEN FINALLY STARTS TO LEAK CAUSING LACK OF HEAT, EVENTUALLY FOGGING THE WINDOWS SO YOU CAN'T SEE CAUSING MULTIPLE SAFETY HAZARDS. COMMON PROBLEM FROM WHAT I SEE ON LINE! YOU DON'T REALIZE IN SUMMER WHEN YOU BUY THE CAR TILL YOU GO TO USE IT IN THE SPRING AND IT'S NOT COVERED UNDER WARRANTY!
A FOLLOW UP TO ADD ON TO MY INITIAL COMPLAINT. I HAVE A SCREENSHOT SHOWING HOW DANGEROUS THIS ISSUE CAN BECOME IF NOT RESOLVED. MY WIPERS AND HORN ARE A SAFETY CONCERN SINCE THEY AREN'T WORKING DUE TO A DEFECTIVE TOTAL INTEGRATED POWER MODULE. PLEASE ADVISE BEFORE ANOTHER CHRYSLER OWNER HAS THE SAME PROBLEM AND COULD POSSIBLE HA…
Read full complaint
A FOLLOW UP TO ADD ON TO MY INITIAL COMPLAINT. I HAVE A SCREENSHOT SHOWING HOW DANGEROUS THIS ISSUE CAN BECOME IF NOT RESOLVED. MY WIPERS AND HORN ARE A SAFETY CONCERN SINCE THEY AREN'T WORKING DUE TO A DEFECTIVE TOTAL INTEGRATED POWER MODULE. PLEASE ADVISE BEFORE ANOTHER CHRYSLER OWNER HAS THE SAME PROBLEM AND COULD POSSIBLE HARM THEMSELVES IN A CRASH OR OTHERS.
MY WIPERS HAVE STARTED TO NOT EXACTLY STOP WORKING BUT THAT STOP THEN START UP AGAIN WHEN YOU TRY TO TURN THEM ON AS IF THEY ARE GLITCHING. THEN MY HORN STOPPED WORKING SO I WENT TO GET MY CAR INSPECTED. THE TOTAL INTEGRATED POWER DISTRIBUTION MODULE WAS NOT WORKING APPARENTLY, A $1300 FIX. THIS CAR HAS BEEN A PAIN. HAVE REPLACE…
Read full complaint
MY WIPERS HAVE STARTED TO NOT EXACTLY STOP WORKING BUT THAT STOP THEN START UP AGAIN WHEN YOU TRY TO TURN THEM ON AS IF THEY ARE GLITCHING. THEN MY HORN STOPPED WORKING SO I WENT TO GET MY CAR INSPECTED. THE TOTAL INTEGRATED POWER DISTRIBUTION MODULE WAS NOT WORKING APPARENTLY, A $1300 FIX. THIS CAR HAS BEEN A PAIN. HAVE REPLACED PART AFTER PART. HAVE HAD 3 RECALLS AND TRULY BELIEVE THIS SHOULD BE A RECALL DUE TO IT BEING SUCH A DUMB THING. EVEN THE MECHANIC WAS LIKE THIS IS THE MOST EXPENSIVE FIX FOR A HORN THAT I'VE EVER SEEN!!
HEATER CORE CLOGGED WITH GELLED COOLANT, REDUCING ABILITY TO DEFROST /MELT ICE FROM WINDSHIELD IN FREEZING RAIN AT ALL SPEEDS. ONLINE RESEARCH SHOWS GELLED COOLANT AFFECTS MANY CHRYSLER CARS, CAUSING NO HEAT, ESP. ON PASSENGER SIDE, NO ABILITY TO MELT ICE, CLOGGED COOLANT SYSTEM, CLOGGED T-STAT (SUMMER 2019) CLOGGED OIL INTERC…
Read full complaint
HEATER CORE CLOGGED WITH GELLED COOLANT, REDUCING ABILITY TO DEFROST /MELT ICE FROM WINDSHIELD IN FREEZING RAIN AT ALL SPEEDS. ONLINE RESEARCH SHOWS GELLED COOLANT AFFECTS MANY CHRYSLER CARS, CAUSING NO HEAT, ESP. ON PASSENGER SIDE, NO ABILITY TO MELT ICE, CLOGGED COOLANT SYSTEM, CLOGGED T-STAT (SUMMER 2019) CLOGGED OIL INTERCOOLER (11/14/19) . THIS IS THE SECOND TIME THAT COOLING SYSTEM HAD TO BE FLUSHED SINCE PURCHASING CAR ON 8/4/18. SUSPECT SPECIFIED HOAT COOLANT CAUSING PROBLEMS IN ALL CHRYSLER VEHICLES INCLUDING AVENGER, CHARGER (PER SERVICE TECH), PICKUPS.
TL* THE CONTACT OWNS A 2011 CHRYSLER 200. THE CONTACT STATED THAT THE DEFROSTER WAS NOT OPERABLE AND HOT AIR BLEW FROM THE VENTS. THE VEHICLE WAS TAKEN TO COBLESKILL CHRYSLER DODGE JEEP RAM (2444 STATE ROUTE 7, COBLESKILL, NY 12043, (518) 234-4000) WHERE IT WAS DIAGNOSED THAT THE HEATER CORE NEEDED TO BE REPLACED. THE VEHICLE WA…
Read full complaint
TL* THE CONTACT OWNS A 2011 CHRYSLER 200. THE CONTACT STATED THAT THE DEFROSTER WAS NOT OPERABLE AND HOT AIR BLEW FROM THE VENTS. THE VEHICLE WAS TAKEN TO COBLESKILL CHRYSLER DODGE JEEP RAM (2444 STATE ROUTE 7, COBLESKILL, NY 12043, (518) 234-4000) WHERE IT WAS DIAGNOSED THAT THE HEATER CORE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 152,000. *TT CONSUMER STATED "HOT AIR BLEW FROM THE VENTS" NOT WHAT SHE SAID. F MANUFACTURER IS AWARE OF THE FAILURE. CONSUMER CALLE AND STATED THAT I WAS GETTING HEAT ON THE DRIVERS AND NOT THE PASSENGER SIDE. THUS CAUSING THE PASSENGER SIDE NOT ABLE TO DEFROST PROPERLY AS WELL AS CAUSING VISUAL ISSUE.*JB
CLOGGED HEATER CORE ON PASSENGER SIDE VENTS, ALL FLOOR VENTS, AND NOW ALSO AFFECTING DRIVER'S SIDE. DEFROSTER DOES NOT WORK PROPERLY ON EITHER SIDE. ONLY BLOWING COLD "AIR CONDITIONING" TEMPERATURE AIR. THIS OCCURRED SLOWLY OVER TIME BUT WE NOTICED IT THE FIRST TIME WHILE TRAVELING DOWN THE HIGHWAY AT 75MPH IN SUB ZERO TEMPERATU…
Read full complaint
CLOGGED HEATER CORE ON PASSENGER SIDE VENTS, ALL FLOOR VENTS, AND NOW ALSO AFFECTING DRIVER'S SIDE. DEFROSTER DOES NOT WORK PROPERLY ON EITHER SIDE. ONLY BLOWING COLD "AIR CONDITIONING" TEMPERATURE AIR. THIS OCCURRED SLOWLY OVER TIME BUT WE NOTICED IT THE FIRST TIME WHILE TRAVELING DOWN THE HIGHWAY AT 75MPH IN SUB ZERO TEMPERATURES FOR 13 HOURS - THE ISSUE HAS PROGRESSED OVER THE 13 HOUR TRIP AND IS COMPLETELY CLOGGED NOW. TOOK TO AN AUTO SHOP ONCE AT DESTINATION BUT THEY CANNOT FLUSH THE SYSTEM BECAUSE OF THE POOR HEATER CORE DESIGN THAT WON'T ALLOW FOR THE FLUID TO FLOW THROUGH THE DUAL SYSTEM.
WHILE DRIVING HOME FROM DINNER MY HUSBANDS HEAT STOPPED WORKING ON THE PASSENGER SIDE OF THE VEHICLE. OHIO WINTERS A VERY COLD. DEFROST ON THE DRIVERS SIDE WAS WORKING BUST THE PASSENGER SIDE WAS NOT. WITHIN MINUTES OF DRIVING THE PASSENGER SIDE OF THE WINDSHIELD FROSTED OVER MAKING IT IMPOSSIBLE GO SEE. IT WAS UNBEARABLE BEING …
Read full complaint
WHILE DRIVING HOME FROM DINNER MY HUSBANDS HEAT STOPPED WORKING ON THE PASSENGER SIDE OF THE VEHICLE. OHIO WINTERS A VERY COLD. DEFROST ON THE DRIVERS SIDE WAS WORKING BUST THE PASSENGER SIDE WAS NOT. WITHIN MINUTES OF DRIVING THE PASSENGER SIDE OF THE WINDSHIELD FROSTED OVER MAKING IT IMPOSSIBLE GO SEE. IT WAS UNBEARABLE BEING IN THE VEHICLE IT WAS SO COLD. WE HAVE 2 SMALL CHILDREN AND WITH A WIND CHILL IN THE NEGATIVE DIGITS THERE IS RISK FOR FROST BITE. THEY ARE MY BIGGEST CONCERN HOWEVER WHAT WOULD NORMALLY BE A 35 MINUTE DRIVE TURNED INTO OVER AN HOUR BECAISE OF POOR VISIBILITY. HOW IS THIS NOT A RECALL YET. NOT BEING ABLE TO SEE IS DANGEROUS AND BEING IN A FREEZING CAR FOR OVER AN HOUR IS DANGEROUS.
TL* THE CONTACT OWNS A 2011 CHRYSLER 200. WHEN THE CONTACT ENTERED THE VEHICLE AND ATTEMPTED TO ACTIVATE THE DEFROSTER, THE VEHICLE BLEW OUT COLD AIR ON THE FRONT PASSENGER SIDE. THE CONTACT TOOK THE VEHICLE TO HENDRIX JEEP CHRYSLER (543 MCPHEARSON CHURCH RD, FAYETTEVILLE, NORTH CAROLINA 28303) WHERE THE RADIATOR WAS FLUSHED, BU…
Read full complaint
TL* THE CONTACT OWNS A 2011 CHRYSLER 200. WHEN THE CONTACT ENTERED THE VEHICLE AND ATTEMPTED TO ACTIVATE THE DEFROSTER, THE VEHICLE BLEW OUT COLD AIR ON THE FRONT PASSENGER SIDE. THE CONTACT TOOK THE VEHICLE TO HENDRIX JEEP CHRYSLER (543 MCPHEARSON CHURCH RD, FAYETTEVILLE, NORTH CAROLINA 28303) WHERE THE RADIATOR WAS FLUSHED, BUT THE ISSUE WAS NOT RESOLVED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.
HEAT ON PASSENGER SIDE GOES OUT DUE TO MANUFACTURER COOLANT. CAUSES THE WINDSHIELD NOT TO DEFROST ON THE PASSENGER SIDE IN COLD MONTHS WHICH MAKES VISIBILITY DURING DRIVING IMPOSSIBLE.
Official recalls
316V668000 · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Sep 15, 2016
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence & remedy
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Additional source detail variants (3)
Seat Belts:pretensioner
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
13V282000 · Air Bags; Electrical System
Jul 2, 2013
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence & remedy
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
Additional source detail variants (2)
Air Bags
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
Electrical System
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
11V315000 · Steering:column
Jun 8, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011DODGE JOURNEY, JEEP WRANGLER, CHRYSLER 200, CHRYSLER 200 CONVERTIBLE, DODGE AVENGER, DODGE NITRO, JEEP LIBERTY, DODGE CALIBER, JEEP COMPASS, JEEP PATRIOT, DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES. SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH A MISSING OR INCORRECTLY INSTALLED STEERING COLUMN PIVOT RIVET.
Consequence & remedy
Consequence: A MISSING OR INCORRECTLY INSTALLED RIVET COULD COMPROMISE THE ABILITY OF THE STEERING COLUMN TO SUPPORT THE OCCUPANT LOADS IN THE EVENT OF A FRONTAL CRASH, DECREASING THE EFFECTIVENESS OF THE FRONTAL IMPACT SAFETY SYSTEM. AS A RESULT, THE CONDITION MAY INCREASE THE POTENTIAL FOR INJURY IN A FRONTAL CRASH.
Remedy: DEALERS WILL INSPECT FOR RIVET PRESENCE AND ALIGNMENT AND REPAIR THE STEERING COLUMN PIVOT AS REQUIRED, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 4, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE12016 · Engine Stall
Opened Jun 18, 2012 · Closed Oct 15, 2012
Status: closed (inferred from source dates) · Engine
During PE12-016, Chrysler identified a condition in model year (MY) 2011 Chrysler 200 and Dodge Avenger vehicles equipped with 3.6L engines that may result in engine stall when stopped or travelling at very low speeds.According to Chrysler, this condition occurs when the Powertrain Control Module (PCM) initiates a purge monitor check while the engine is at idle which can result in an overly rich vapor condition and cause the engine to stall while stopped.Chrysler developed a software countermeasure to address the condition and has initiated a customer satisfaction campaign to reprogram the PCM on all affected vehicles. The bulletin was sent to dealers on September 28, 2012 and the owner letter mailing began on October 5, 2012.See the investigative file for copies of Chrysler's bulletin and owner letter.The Office of Defects Investigation (ODI) analyzed complaints related to engine stall that were provided by Chrysler or submitted to ODI from consumers.The predominant failure mode identified involved stalling when stopped or travelling at low speeds.The complaint counts shown in this resume include incidents in which enough detail was available to verify the symptoms were related to the defect condition identified by Chrysler.Two complaints alleged engine stall resulting in collisions, one involving very minor damage and one involving a single vehicle road departure crash in which the vehicle was totalled.In the first incident, the vehicle stalled while stopped at an intersection and rolled back into a following vehicle resulting in a minor scratch in the rear bumper.In the second incident, the vehicle was totalled from damage sustained from striking a tree after failing to negotiate a sharp turn in wet road conditions.The police report does not include any references to stalling as a cause or contributor, but cites excessive speed entering the turn.Although there was evidence or prior history with stalling when stopped, there is no evidence that engine stall was a factor in the crash.The condition that is causing the majority of stalling incidents in the subject vehicles occurs at a stop or very low speed and allows the vehicle to be restarted immediately.The condition represents a low risk to motor vehicle safety and is adequately addressed by Chrysler's service campaign. This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers (ODI Nos.):10458865, 10458713, 10456385, 10456270, 10452622, 10452327, 10451870, 10451243, 10450745, 10450609, 10449370, 10448136, 10446374, 10443383, 10428753, 10463086, 10463085, 10462966, 10462908, 10462901, 10462851, 10462772, 10462720, 10462702, 10462691.