NHTSA owner reports · September 18, 2026 snapshot.
Tires complaints
13 reportsClear category filter119,680 miles · Jun 11, 2012
Tires
MY DAUGHTER NOTICED THAT SHE WAS NOT ABLE TO KEEP AIR IN ONE MASTERCRAFT A/S IV TIRES. AS WE LOOKED AT THE TIRE TOGETHER SHE HEARD AIR ESCAPING, AND WHEN WE TOUCHED THE AREA OF THE LEAK, THE LEAK GOT LOUDER. I TOOK IT TO THE LOCAL FARM & FLEET (WHERE THE TIRES WERE PURCHASED & INSTALLED AS I HAVE BEEN TOLD THEY ARE GOOD AT KEEPI…
Read full complaint
MY DAUGHTER NOTICED THAT SHE WAS NOT ABLE TO KEEP AIR IN ONE MASTERCRAFT A/S IV TIRES. AS WE LOOKED AT THE TIRE TOGETHER SHE HEARD AIR ESCAPING, AND WHEN WE TOUCHED THE AREA OF THE LEAK, THE LEAK GOT LOUDER. I TOOK IT TO THE LOCAL FARM & FLEET (WHERE THE TIRES WERE PURCHASED & INSTALLED AS I HAVE BEEN TOLD THEY ARE GOOD AT KEEPING UP WITH WARRANTIES) TO HAVE IT CHECKED OUT. I WAS TOLD THAT IT HAS "DRY ROT", AND I WOULD HAVE TO BUY ANOTHER BRAND AS THE MASTERCRAFT A/S IV HAVE BEEN "DISCONTINUED", AND I HAVE NO OTHER RECOURSE. I ASKED IF THEY OR I COULD FILE A COMPLAINT WITH THE MANUFACTURER, AND WAS TOLD NO AS THE TIRES HAVE BEEN DISCONTINUED AND ARE NO LONGER MANUFACTURED. FURTHER, I WAS TOLD THAT ONLY 25% OF THE TREAD REMAINS. THE TIRES WERE PURCHASED 9/08/08 & ONLY HAVE APPROXIMATELY, 20,806 MILES ON THEM, BUT THE MANUFACTURER RATES THEM AT 50,000 MILES. THE LOW MILES MAKES SENSE AS WE RARELY PUT ON MORE THAN 7K MILES ON ANY OF OUR VEHICLES. I AM CONCERNED THAT THIS MAY BE A MANUFACTURING DEFECT IN THE MATERIAL OF THE TIRE(S). *TR
NHTSA ODI #10461272
88,000 miles · Dec 12, 2006
Tires
DT*: THE CONTACT STATED WHILE DRIVING 20MPH, THERE WAS THUMPING NOISE, AND A SHIMMY IN THE FRONT WHEELS. THE VEHICLE WAS INSPECTED BY A DEALER WHO DETERMINED THERE WAS A BLISTER ON THE LEFT FRONT TIRE AND IT NEEDED TO BE REPLACED. AFTERWARDS THE REPLACEMENT, THE PROBLEM PERSISTED. THE VEHICLE WAS INSPECTED BY THE DEALER WHO …
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 20MPH, THERE WAS THUMPING NOISE, AND A SHIMMY IN THE FRONT WHEELS. THE VEHICLE WAS INSPECTED BY A DEALER WHO DETERMINED THERE WAS A BLISTER ON THE LEFT FRONT TIRE AND IT NEEDED TO BE REPLACED. AFTERWARDS THE REPLACEMENT, THE PROBLEM PERSISTED. THE VEHICLE WAS INSPECTED BY THE DEALER WHO DETERMINED THE TREAD WAS WORN AND THE STEEL BELT WAS PRESENT ON THE RIGHT FRONT TIRE. AFTER REPLACING THE RIGHT FRONT TIRE, THE LEFT REAR TIRE TREAD BEGAN TO SEPARATE WITHOUT WARNING. THE MANUFACTURER WAS NOT ALERTED. THE TIRES WERE BRIDGESTONE INSIGNIA SE200, SIZE P225/60R16.
NHTSA ODI #10175925
Mileage unknown · Dec 8, 2003
Tires
WHILE DRIVING 60 MPH RIGHT REAR TIRE EXPLODED. CONSUMER WAS ABLE TO PULL OVER TO SHOULDER, AND CHANGED THE TIRE.*AK
NHTSA ODI #10050259
Mileage unknown · Jun 27, 2003
Tires
I HAVE 4 ORIGINAL FIRESTONE TIRES [FR680] P215/70/R15 TIRES THAT HAVE SPLITS IN SIDE WALLS BY TREAD AREAS, AND THEY ALSO HAVE BULGES IN SIDEWALL AREAS. ONLY 25000 MI. ON THEM. I FEEL THAT I NEED TO REPLACE THEM BEFORE WE HAVE A MAJOR BLOW OUT AND ACCIDENT BY THESE VISIBLE PROBLEMS. WITH 3 CHILDREN I CANNOT AFFORD AN ACCIDENT …
Read full complaint
I HAVE 4 ORIGINAL FIRESTONE TIRES [FR680] P215/70/R15 TIRES THAT HAVE SPLITS IN SIDE WALLS BY TREAD AREAS, AND THEY ALSO HAVE BULGES IN SIDEWALL AREAS. ONLY 25000 MI. ON THEM. I FEEL THAT I NEED TO REPLACE THEM BEFORE WE HAVE A MAJOR BLOW OUT AND ACCIDENT BY THESE VISIBLE PROBLEMS. WITH 3 CHILDREN I CANNOT AFFORD AN ACCIDENT CAUSED BY THESE TIRES. I WILL BE KEEPING OLD TIRES . I WENT ON THE WEB SIGHT AND SAW THAT SIMILAR PROBLEMS ARE HAPPENING TO OTHER PEOPLE??? *JB
NHTSA ODI #10023915
Mileage unknown · Jun 19, 2003
Tires
WHILE DRIVING DRIVER SIDE FRONT TIRE TREAD SEPARATED. FIRESTONE FR680,P215/70R15. *AK
NHTSA ODI #10024451
Mileage unknown · Apr 2, 2003
Tires
ALL 4 TIRES CONTAINED CRACKS. *JB
NHTSA ODI #10015043
Mileage unknown · May 3, 2001
Engine And Engine CoolingFuel System, GasolineFuel System, OtherFire
WHILE FILLING VEHICLE WITH GAS NOTICED GAS SMELL INSIDE VEHICLE. ALSO, FOUND A GAS PUDDLE UNDER VEHICLE. DEALER HAS BEEN CONTACTED.*AK CONSUMER STATES VEHICLE HAS ALWAYS BEEN HARD TO START, ALSO WHILE DRVING THE RIGHT REAR TIRE CAUGHT FIRE, AND THE GAS GUAGE WAS NOT WORKING PROPERLY, FRONT WINDSHIELD WAS CRACKING, ALSO THE CHE…
Read full complaint
WHILE FILLING VEHICLE WITH GAS NOTICED GAS SMELL INSIDE VEHICLE. ALSO, FOUND A GAS PUDDLE UNDER VEHICLE. DEALER HAS BEEN CONTACTED.*AK CONSUMER STATES VEHICLE HAS ALWAYS BEEN HARD TO START, ALSO WHILE DRVING THE RIGHT REAR TIRE CAUGHT FIRE, AND THE GAS GUAGE WAS NOT WORKING PROPERLY, FRONT WINDSHIELD WAS CRACKING, ALSO THE CHECK ENGINE LIGHT WAS COMING ON, AS WELL AS THE ENGINE OIL LIGHT,AND A CRACKED GAS TANK.*JB
NHTSA ODI #887359
Mileage unknown · May 2, 2001
Tires
DURING NORMAL DRIVING CONDITIONS (NO RAIN, SNOW, HAZARDS) OUR RIGHT REAR TIRE FAILED. THE TREAD COMPLETELY SEPARATED FROM THE TIRE DESTROYING THE RIM ABS HARNESS CABLE AND OTHER FOR A TOTAL OF 2000.00 DAMAGE. NO INJURIES. THE TIRES HAVE VERY LITTLE WEAR (9000 MILES). I IMMEDIATELY REPLACED ALL THE TIRES WITH ANOTHER BRAND. THE C…
Read full complaint
DURING NORMAL DRIVING CONDITIONS (NO RAIN, SNOW, HAZARDS) OUR RIGHT REAR TIRE FAILED. THE TREAD COMPLETELY SEPARATED FROM THE TIRE DESTROYING THE RIM ABS HARNESS CABLE AND OTHER FOR A TOTAL OF 2000.00 DAMAGE. NO INJURIES. THE TIRES HAVE VERY LITTLE WEAR (9000 MILES). I IMMEDIATELY REPLACED ALL THE TIRES WITH ANOTHER BRAND. THE CATASTROPHIC FAILURE OF THE TIRE CONCERNS ME AND BELIEVE THE TIRE TO BE FAULTY. I WOULD LIKE TO HAVE THE TIRE ANALIZED BY AN INDEPENDENT LAB TO LET AND TO GIVE THEIR OPINION OF WHY THE TIRE FAILED. IS THERE A INDIEPENDENT INVESTIGATION LAB IN MY AREA WHO COULD ASSIST ME WITH THIS PROBLEM? I'D APPRECIATE YOUR RESPONSE. *AK (DOT NUMBER: W2MB3BCB08 TIRESIZE: 21570R1597)
NHTSA ODI #744836
Mileage unknown · Mar 27, 2001
Tires
WAS TRAVELING 75MPH WHEN VEHICLE STARTED VIBRATING. LOST CONTROL OF VEHICLE FOR SHORT WHILE. WAS GOING SIDEWAYS. FINALLY, WAS ABLE TO STOP AND TURN IT OFF. CHECKED IT OUT. NOTICED RIGHT REAR TIRE HAD SHREDDED , AND SIDE WALL WAS OFF TIRE. P215/70R15, W2M3, 2000, CHEVROLET, VENTURE.*AK FIRESTONE FR480. *SLC
NHTSA ODI #884388
Mileage unknown · Dec 14, 2000
Electrical SystemFuel System, GasolinePower Train
CONSUMER SMELLED STRONG GAS FUMES AND NOTICED THAT GAS WAS POURING OUT, THE DEALER REPLACED THE FUEL REGULATOR. *SLC
NHTSA ODI #558490
Official recalls
5Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
Aug 21, 2001
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Mar 8, 2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Sep 29, 1999
VEHICLE DESCRIPTION: MINI VANS WITH EXTENDED WHEELBASE. SOME OF THESE VEHICLES HAVE INOPERATIVE FUEL TANK ROLLOVER VALVES AND FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN A ROLLOVER TEST. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY."
Consequence & remedy
Consequence: IN A VEHICLE ROLLOVER ACCIDENT, IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL INSPECT THE VEHICLES TO LOCATE AND REPLACE THOSE FUEL TANKS THAT COULD HAVE INOPERATIVE ROLLOVER VALVES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.
PE02017 · Shoulder Harness Clip
Opened Feb 11, 2002 · Closed Aug 2, 2002
Status: closed (inferred from source dates) · Seat Belts
No summary supplied.
SQ00014 · Unexpected Opening Of Sliding Door
Opened Jul 25, 2000 · Closed Oct 22, 2001
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Illustration