IllustrationTHE VEHICLE MAKES A HUMMING SOUND AND INCREASES AS IT ACCELERATES DUE TO THE TRANSMISSION OIL PUMP AND THE TORQUE CONVERTER FAILURE. YH
1996 Chevrolet Suburban
Owner reports · Recalls · Investigations
More warning signs than most Suburban years
Owner complaints for the 1996 Chevrolet Suburban are substantially higher than the model-year median of 118.
About this comparison →How this year compares
Owner complaints by model year
Compare all Suburban years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 26 of 360 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 129 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports12 fire reports7 injury reports
Service Brakes, Hydraulic complaints
129 reportsPOOR BRAKE PERFORMANCE, PEDAL GOES TO FLOOR AND DO NOT REALLY MAKE A GOOD EFFORT TO STOP
THE BATTERY LEAKED/SPRAYED ACID ONTO THE ENGINE AND RIGHT FRONT SIDE COMPONENTS OF THE SUBURBAN. THE AIR BAG SENSOR HAD TO BE REPLACED, BUT THE REST OF THE COMPONENTS WERE JUST CLEANED OFF (THIS INCLUDED BRAKE HYDRAULIC CABLES AND LINES, BRAKES, AIR CONDITIONING HOSES, RADIATOR, ETC.). THE DEALER/MANUFACTURER SAID THEY DON'T C…
Read full complaint
THE BATTERY LEAKED/SPRAYED ACID ONTO THE ENGINE AND RIGHT FRONT SIDE COMPONENTS OF THE SUBURBAN. THE AIR BAG SENSOR HAD TO BE REPLACED, BUT THE REST OF THE COMPONENTS WERE JUST CLEANED OFF (THIS INCLUDED BRAKE HYDRAULIC CABLES AND LINES, BRAKES, AIR CONDITIONING HOSES, RADIATOR, ETC.). THE DEALER/MANUFACTURER SAID THEY DON'T COVER THE BATTERY BECAUSE IT IS NOT MADE BY THEM ALTHOUGHT I THINK THE COMPANY IS OWNED BY THEM. WE HAD TO BUY A NEW BATTERY AND PAY FOR ALL THE DAMAGE TO THE CAR AND STILL DON'T KNOW WHAT THE LONG TERM AFFECTS OF THIS CORROSIVE ACID WILL BE. IT LEFT A HUGE ORANGE PUDDLE IN OUR GARAGE FLOOR WHICH WE CAN'T GET RID OF. WE TOOK VIDEO AND PICTURES OF THE DAMAGE TO THE CAR, BATTERY AND GARAGE. THE CRACKED FRONT TRANSAXLE CASING WAS ONLY DIAGNOSED AFTER THEY HAD REPLACED THE SEAL ON THE FRONT AXLE TWICE SINCE IT WAS ALWAYS LEAKING FLUID. THE REAR DIFFERENTIAL HAD THE SEAL REPLACED 2 OR 3 TIMES BUT IT STILL LEAKS. THE FUEL PUMPED FAILED ON OUR CAR LEAVING US STRANDED. WE WERE TOLD THAT THE TRUCK NEEDS TO KEEP A 1/4 TANK OF GAS AT ALL TIMES IN THE TANK SO THAT THIS DOES NOT HAPPEN. THE AIR CONDITIONER HAS NEVER REALLY WORKED WELL ON THIS MODEL, IT APPEARS THAT IT IS UNDERSIZED TO HANDLE THE THERMAL LOAD. WE ALSO HAD TO HAVE THE SPOT WELDS ON THE DOOR JAMS FILED BECAUSE MANY SHARP BURRS EXISTED WHICH WERE A SAFETY HAZARD.*AK
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
FRONT AND REAR BRAKES FAILED. YH
WHILE TRAVELING AND WHEN DEPRESSING THE BRAKES VEHICLE WOULD TRAVEL TO THE RIGHT. DEALER HAS BEEN CONTACTED , AND STATED BRAKES UNEVENLY WORE OUT. PLEASE PROVIDE FURTHER INFORMATON.
WHILE TRAVELING AT A LOW SPEED AND WHEN DEPRESSING THE BRAKES, VEHICLE WOULD GO INTO A EXTENDED STOPPING DISTANCE, LEAKING BRAKE FLUID RESERVIOR CAUSING BRAKES TO LOCK UP. *AK
WHILE DRIVING ABOUT 30 MPH CONSUMER TRIED TO STOP. BUT, BRAKES LOCKED UP, CAUSING DRIVER TO LOSE CONTROL OF VEHICLE. *AK
WHILE MAKING A STOP VEHICLE WOULD CONTINUE TO TRAVEL, CAUSING EXTENDED STOPPING DISTANCE. DEALER CAN'T DUPLICATE INTERMITTENT PROBLEM. *AK *ML
BRAKES DON'T STOP VEHICLE WHEN CONSUMER TRIES TO STOP. IT ONLY HAPPENS ON SLIPPERY SURFACES, MAKES A METAL-AGAINST-METAL SOUND. CONSUMER SAYS THE DEALER IS WAITING FOR WORD ON THE INVESTIGATION WITH US, THEY SAID NOTHING WAS WRONG WITH THEM. *AK *ML
Official recalls
303V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
98V150001 · Visibility:windshield Wiper/washer
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
96V057000 · Vehicle Speed Control
Apr 4, 1996
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00024 · Headlight
Opened Sep 26, 2000 · Closed Dec 21, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
EA00013 · Battery Leaks Acid
Opened May 2, 2000 · Closed Jun 28, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
DP00001 · Oem Hitch Receiver Platform Cracking
Opened Jan 31, 2000 · No close date supplied
Status: open (inferred from source dates) · Equipment
THE PETITION ALLEGES THAT CRACKS IN THE HITCH RECEIVER PLATFORM MAY LEAD TO SEPARATION OF THE TRAILER AND LOSS OF STEERING CONTROL
EA97007 · Steering Shaft Separations
Opened Apr 17, 1997 · Closed Mar 12, 1998
Status: closed (inferred from source dates) · Steering
COUPLING BOLTS, JOINING THE STEERING SHAFT, MAY SEPARATE.IN SOME CASES, TOTAL UNFORESEEN, LOSS OF STEERING CONTROL MAY RESULT.
PE96076 · Steering Shaft Separations
Opened Dec 18, 1996 · Closed Apr 17, 1997
Status: closed (inferred from source dates) · Steering
BOLT IN THE COUPLING, JOINING THE UPPER INTERMEDIATE AND STEERING COLUMN SHAFTS, FALLS OUT.TOTAL LOSS OF STEERING OCCURS WHEN THE SHAFTS THEN SEPARATE.
EA95026 · Poor Brake Performance
Opened Sep 20, 1995 · Closed Sep 20, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
POOR PERFORMANCE OF ABS BRAKES