IllustrationTHE TRANSMISSION ITSELF DIDN'T FAIL THE HOUSING CRACKED. I WAS TOLD BY CHEVY "WHAT DID I EXPECT IT HAD OVER 70,000 MILES. I WAS TOLD BY A MECHANIC THAT IT WAS A DEFECT.*AK
1996 Chevrolet Suburban
Owner reports · Recalls · Investigations
More warning signs than most Suburban years
Owner complaints for the 1996 Chevrolet Suburban are substantially higher than the model-year median of 118.
About this comparison →How this year compares
Owner complaints by model year
Compare all Suburban years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 26 of 360 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 129 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports12 fire reports7 injury reports
Power Train complaints
40 reportsCHEVROLET, SUBURBAN 1996, LS 1500, 4 X 4 I HAVE ONLY OWNED THIS CAR 2YRS, I HAD TO PUT ON 5 SETS OF BRAKES, 2 SETS OF ROTORS, DRUMS, STEER KNUCKLES, ALTERNATOR, WINDSHIELD WIPER MOTOR, BATTERY, DIFFERENTIAL/AXLES REPLACED AND AIR CONDITION UNIT HAS FOWL SMELL AND THE BACK PASSAGER DOOR STICKS AND WON'T OPEN MOST OF THE TIME. I …
Read full complaint
CHEVROLET, SUBURBAN 1996, LS 1500, 4 X 4 I HAVE ONLY OWNED THIS CAR 2YRS, I HAD TO PUT ON 5 SETS OF BRAKES, 2 SETS OF ROTORS, DRUMS, STEER KNUCKLES, ALTERNATOR, WINDSHIELD WIPER MOTOR, BATTERY, DIFFERENTIAL/AXLES REPLACED AND AIR CONDITION UNIT HAS FOWL SMELL AND THE BACK PASSAGER DOOR STICKS AND WON'T OPEN MOST OF THE TIME. I BOUGHT IT AS A LEASE RETURN WITH 34,900 MILES ON IT. PLEASE HELP ME FIND OUT WHY THIS CAR IS STILL BEING SOLD. I ONLY DRIVE THIS SUBURBAN IN EMERGENCY.*AK
THESE TIRE ACT AS IF THEY ARE OUT OF BALANCE, A SPEEDS OF 65-70MPH THEY WILL SHAKE TO VEHICLE SO BAD,IT DISLOGDES MY CELL PHONE BATTERY. I HAVE HAD THESE TIRE BACK TO FIRESTONE TO BE REBALANCED SEVERAL TIMES. THEY SAY THE TIRE ARE BALANCED CORRECTLY. THIS PROBLEM OCCURS AFTER THE VEHICLE HAS BEEN DRIVIN FOR A HALF HOUR OR SO.…
Read full complaint
THESE TIRE ACT AS IF THEY ARE OUT OF BALANCE, A SPEEDS OF 65-70MPH THEY WILL SHAKE TO VEHICLE SO BAD,IT DISLOGDES MY CELL PHONE BATTERY. I HAVE HAD THESE TIRE BACK TO FIRESTONE TO BE REBALANCED SEVERAL TIMES. THEY SAY THE TIRE ARE BALANCED CORRECTLY. THIS PROBLEM OCCURS AFTER THE VEHICLE HAS BEEN DRIVIN FOR A HALF HOUR OR SO. WHEN THEY ARE COLD THEIR FINE. FIRESTONE HAS BLAMED MY DRIVESHAFT AND CV JOINTS. I HAVE MOVED THE TIRE AROUND THE VEHICLE AND THE VIBRATION FOLLOWS THE TIRES. COULD THESE TIRE BE GOING OUT OF ROUND AFTER THEY WARM UP? I WAS JUST LIVING WITH THIS PROBLEM, BUT NOW I SEE THAT THESE TIRE ARE UNDER INVESTIGATION BY THE NHTSA. (DOT NUMBER: NONE TIRESIZE: LT24575R16)
POST ON BATTERY BROKE OFF. BATTERY ACID HAD LEAKED FROM THE BREAK. TRANSMISSION FAILED, FLUID LEVEL HAD BEEN CHECK APPROXIMATELY 10 DAYS PRIOR TO FAILURE. FLUID LEVEL WAS FINE.
VEHICLE EXPERIENCED A TRANSMISSION FAILURE DUE TO A DEFECTIVE HUB. MANUFACTURER NOTIFIED , AND INFORMED CONSUMER THAT NOTHING COULD BE DONE DUE TO VEHICLE BEING OUT OF ITS WARRANTY. FEEL FREE TO PROVIDE FURTHER DETAILS. *AK
HAVE LETTER STATING THAT MANUF PART FAILED IN HUB REGION. NO SAFETY DEFECT MENTIONED IN SUMMARY. *AK
THE VEHICLE MAKES A HUMMING SOUND AND INCREASES AS IT ACCELERATES DUE TO THE TRANSMISSION OIL PUMP AND THE TORQUE CONVERTER FAILURE. YH
FRONT AND REAR BRAKES FAILED. YH
PINION SEAL ON REAR DIFF. LEAKED AT 36K MILES, FUEL INJECTORS CLOGGED AT 40K AND INOPERABLE OXYGEN SENSOR. BATTERY LEAKED AT SIDE TERMINAL (38K MILES), CORRODED BATTERY CABLES AND SHELF. WINSHEILD WIPERS DO NOT GO ALL THE WAY DOWN TO THE STARTING POSITION WHEN TURNED OFF. CURRENTLY HAVING PROBLEMS WITH STARTING THE VEHICLE. S…
Read full complaint
PINION SEAL ON REAR DIFF. LEAKED AT 36K MILES, FUEL INJECTORS CLOGGED AT 40K AND INOPERABLE OXYGEN SENSOR. BATTERY LEAKED AT SIDE TERMINAL (38K MILES), CORRODED BATTERY CABLES AND SHELF. WINSHEILD WIPERS DO NOT GO ALL THE WAY DOWN TO THE STARTING POSITION WHEN TURNED OFF. CURRENTLY HAVING PROBLEMS WITH STARTING THE VEHICLE. STARTER WAS CHECKED AND IS O.K. PROBABLY ELECTRICAL, DUE TO LEAKING BATTERY OR A COMPUTER PROBLEM.
NO SUMMARY.
Official recalls
303V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
98V150001 · Visibility:windshield Wiper/washer
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
96V057000 · Vehicle Speed Control
Apr 4, 1996
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00024 · Headlight
Opened Sep 26, 2000 · Closed Dec 21, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
EA00013 · Battery Leaks Acid
Opened May 2, 2000 · Closed Jun 28, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
DP00001 · Oem Hitch Receiver Platform Cracking
Opened Jan 31, 2000 · No close date supplied
Status: open (inferred from source dates) · Equipment
THE PETITION ALLEGES THAT CRACKS IN THE HITCH RECEIVER PLATFORM MAY LEAD TO SEPARATION OF THE TRAILER AND LOSS OF STEERING CONTROL
EA97007 · Steering Shaft Separations
Opened Apr 17, 1997 · Closed Mar 12, 1998
Status: closed (inferred from source dates) · Steering
COUPLING BOLTS, JOINING THE STEERING SHAFT, MAY SEPARATE.IN SOME CASES, TOTAL UNFORESEEN, LOSS OF STEERING CONTROL MAY RESULT.
PE96076 · Steering Shaft Separations
Opened Dec 18, 1996 · Closed Apr 17, 1997
Status: closed (inferred from source dates) · Steering
BOLT IN THE COUPLING, JOINING THE UPPER INTERMEDIATE AND STEERING COLUMN SHAFTS, FALLS OUT.TOTAL LOSS OF STEERING OCCURS WHEN THE SHAFTS THEN SEPARATE.
EA95026 · Poor Brake Performance
Opened Sep 20, 1995 · Closed Sep 20, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
POOR PERFORMANCE OF ABS BRAKES