ONGOING PROBLEM WITH THE FOLLOWING: 1. CRACKS DEVELOPING ON BOTH SIDES OF VEHICLE ROOF, CAN BE A POTENTIAL DANGER IN A ROLL OVER ACCIDENT; 2. BRAKES CAUSE ERRATIC OPERATION WHENEVER BRAKES ARE APPLIED, AND CAUSES VEHICLE TO WANDER AROSS THE ROAD, WHICH COULD LEAD TO A POTENTIAL ACCIDENT; AND 3. SEATBACK WOULD CONTINUE TO MOV…
Read full complaint
ONGOING PROBLEM WITH THE FOLLOWING: 1. CRACKS DEVELOPING ON BOTH SIDES OF VEHICLE ROOF, CAN BE A POTENTIAL DANGER IN A ROLL OVER ACCIDENT; 2. BRAKES CAUSE ERRATIC OPERATION WHENEVER BRAKES ARE APPLIED, AND CAUSES VEHICLE TO WANDER AROSS THE ROAD, WHICH COULD LEAD TO A POTENTIAL ACCIDENT; AND 3. SEATBACK WOULD CONTINUE TO MOVE BACKWARDS EVERY TIME VEHICLE ROLLS OVER ANY TYPE OF BUMPS. ALSO COULD LEAD TO A VEHICLE BEING OUT OF CONTROL AND A POTENTIAL ACCIDENT. *AK
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL VETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence & remedy
Consequence: IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULD ALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLE CONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
Consequence & remedy
Consequence: SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy: REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
Illustration