THE BRAKE ROTORS HAD SEPARATED. THE BRAKES ON THIS VEHICLE ARE DEFECTIVE. THE SAME PART FOR THE BRAKES WERE REPLACED FOR THE RECALL BRAKE PART AND THE PROBLEM STILL EXIST. THE CONSUMER CONTACTED THE MANUFACTURER AND WAS INFORMED THAT THE CAMPAIGN WAS CLOSED AND WAS NOT ABLE TO INDICATE WHAT WAS REPAIRED DUE TO NOT BEING THE O…
Read full complaint
THE BRAKE ROTORS HAD SEPARATED. THE BRAKES ON THIS VEHICLE ARE DEFECTIVE. THE SAME PART FOR THE BRAKES WERE REPLACED FOR THE RECALL BRAKE PART AND THE PROBLEM STILL EXIST. THE CONSUMER CONTACTED THE MANUFACTURER AND WAS INFORMED THAT THE CAMPAIGN WAS CLOSED AND WAS NOT ABLE TO INDICATE WHAT WAS REPAIRED DUE TO NOT BEING THE ORIGINAL OWNER RECALL 93V119000. *CM *SCC
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL VETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence & remedy
Consequence: IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULD ALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLE CONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
Consequence & remedy
Consequence: SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy: REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
Illustration