IllustrationTL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE REAR HATCH WOULD NOT OPEN. THE DEALER STATED THAT THE ACTUATOR NEEDED TO BE REPLACED. THE CONTACT NOTIFIED THE MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 200,000. UPDATED 04/20/16*LJ *TR
2004 Chevrolet Suburban 1500
Owner reports · Recalls · Investigations
More warning signs than most Suburban 1500 years
Owner complaints for the 2004 Chevrolet Suburban 1500 are substantially higher than the model-year median of 53.
About this comparison →How this year compares
Owner complaints by model year
Compare all Suburban 1500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
60–25K
1925–50K
4050–75K
5075–100K
31100–150K
21150K+
167 reports with mileage · 15 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports4 fire reports2 injury reports
Structure complaints
5 reportsWHILE DRIVING AT APPROXIMATELY 65 MPH ON AN INTERSTATE, THE SUN ROOF ON MY 2004 CHEVROLET SUBURBAN RIPPED OFF NARROWLY MISSING THE CAR FOLLOWING US. THE SUN ROOF WAS CLOSED AT TIME OF THE INCIDENT. OTHER THAN WHAT SOUNDED LIKE AN AIR LEAK, THERE WAS NO WARNING OR OTHER INDICATION OF PROBLEMS. THE SUN ROOF HAS RARELY BEEN OPE…
Read full complaint
WHILE DRIVING AT APPROXIMATELY 65 MPH ON AN INTERSTATE, THE SUN ROOF ON MY 2004 CHEVROLET SUBURBAN RIPPED OFF NARROWLY MISSING THE CAR FOLLOWING US. THE SUN ROOF WAS CLOSED AT TIME OF THE INCIDENT. OTHER THAN WHAT SOUNDED LIKE AN AIR LEAK, THERE WAS NO WARNING OR OTHER INDICATION OF PROBLEMS. THE SUN ROOF HAS RARELY BEEN OPENED SINCE THE CAR WAS PURCHASED AND DEFINITELY HAD NOT BEEN OPENED IN THE PAST 2 YEARS AT LEAST. *TR
I OWN A 2004 CHEVROLET SUBURBAN. THE RIGHT HINGE FOR THE LIFTGATE WINDOW HAS CRACKED AND THERE IS A POSSIBILITY THAT WHEN DRIVING, THE WINDOW COULD FALL OFF IF WIND GETS WITHIN THE WINDOW AND THE HINGES. GM IS IGNORING ANY COMPLAINTS ON THIS EVEN THOUGH THEY ARE ALL OVER THE INTERNET. *TR
BACK GLASS OF THE 2004 CHEVY SUBURBAN DISENGAGE FROM THE VEHICLE. THIS IS VERY DANGEROUS IT COULD COME OFF WHILE DRIVING AND STRIKE ANOTHER VEHICLE OR WORSE IT COULD FALL ON SOMEBODY CAUSING SERIOUS INJURIES. *TR
WE OWN A 2004 CHEVROLET SUBURBAN WITH APPROXIMATELY 50,000 CURRENT MILES. WE PURCHASED THE VEHICLE USED AT 20,000 MILES. AT SOME POINT AFTER 36000 WE STARTED NOTICING A "CLUNKING" IN THE STEERING COLUMN WHEN WE WOULD TURN THE WHEEL. I AN EMPLOYED AT A SCHOOL AND IT HAS HAD TO HAVE THIS SAME PROBLEM REPAIRED ON 3 OF IT'S 2004 CHE…
Read full complaint
WE OWN A 2004 CHEVROLET SUBURBAN WITH APPROXIMATELY 50,000 CURRENT MILES. WE PURCHASED THE VEHICLE USED AT 20,000 MILES. AT SOME POINT AFTER 36000 WE STARTED NOTICING A "CLUNKING" IN THE STEERING COLUMN WHEN WE WOULD TURN THE WHEEL. I AN EMPLOYED AT A SCHOOL AND IT HAS HAD TO HAVE THIS SAME PROBLEM REPAIRED ON 3 OF IT'S 2004 CHEVROLET 1500 SUBURBANS, EACH WITH JUST OVER THE 36,000 WARRANTY MILEAGE. EACH COST ABOUT $370.00 TO REPAIR. *TR
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.