← New search

2004 Chevrolet Suburban 1500

Owner reports · Recalls · Investigations

More warning signs than most Suburban 1500 years

Owner complaints for the 2004 Chevrolet Suburban 1500 are substantially higher than the model-year median of 53.

About this comparison →

When problems were reported

Mileage at the reported incident

167 reports with mileage · 15 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Steering. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

2 crash reports4 fire reports2 injury reports

Seats complaints

2 reports
Clear category filter
13,000 miles · Nov 25, 2017
Seats

THIS PROBLEM CONCERNS A 2004 CHEVROLET SUBURBAN. THE SEAT HEATER SWITCH, LOCATED ABOVE THE DRIVER'S DOOR ARMREST, TURNS ITSELF ON WHEN THE CAR IS OPERATING. THE HEATED SEAT BECOMES EXTRAORDINARILY HOT RAPIDLY AND IT IS DIFFICULT TO TURN OFF - EVERY BUMP AND JAR IN THE ROAD TURNS THE LIGHT AND THE SEAT BACK ON. THE LIGHT'S LOCAT…

Read full complaint

THIS PROBLEM CONCERNS A 2004 CHEVROLET SUBURBAN. THE SEAT HEATER SWITCH, LOCATED ABOVE THE DRIVER'S DOOR ARMREST, TURNS ITSELF ON WHEN THE CAR IS OPERATING. THE HEATED SEAT BECOMES EXTRAORDINARILY HOT RAPIDLY AND IT IS DIFFICULT TO TURN OFF - EVERY BUMP AND JAR IN THE ROAD TURNS THE LIGHT AND THE SEAT BACK ON. THE LIGHT'S LOCATION WHICH INDICATES THE OPERATION OF THE HEATED SEATS IS DIFFICULT TO SEE AS WELL - ESPECIALLY WHEN THE SUN IS STRONG & I'M WEARING SUNGLASSES. LOOKING DOWN AND AWAY FROM THE ROAD AND TRAFFIC IS FAIRLY DANGEROUS. THIS DISTRACTION COULD EASILY EVOLVE INTO AN ACCIDENT AS THE DRIVER IS CONSTANTLY TRYING TO TURN THE HEATED SEAT OFF. I HAVE HAD THIS ITEM "REPAIRED" ONCE, YET THE PROBLEM CONTINUES. THE MOST MEMORABLE MOMENT WAS TRYING TO DRIVE IN A TORRENTIAL RAINSTORM ON THE INTERSTATE. I PULLED OVER FOR SAFETY BEFORE I TRIED TO TURN OFF THE LIGHT. THE MINUTE I PULLED BACK ONTO THE INTERSTATE, THE HEATED SEAT TURNED ITSELF BACK ON AND STAYED ON FOR THE NEXT 250 MILES. I KNOW I AM NOT THE ONLY PERSON WITH A 2004 SUBURBAN THAT SUFFERS FROM THIS PROBLEM. WE HAVE TAKEN THE FUSE OUT OF THE CAR THAT CONTROLS THE HEATED SEATS, BUT THAT ALSO AFFECTS THE ABILITY TO READJUST THE SEAT POSITION FOR THE INDIVIDUAL DRIVERS. THE HEATED SEAT DISTRACTION COMBINED WITH THE LOCATION OF THE SWITCH ARE DEFINITELY A SAFETY ISSUE AND SHOULD BE REPAIRED.

NHTSA ODI #11048367

60,000 miles · Feb 5, 2008
Seats

THE SLIDE ASSEMBLY UNDER THE 2ND SEAT, DOES NOT WORK, SO THAT PASSENGERS CANNOT EASILY CLIMB INTO THE BACK SEAT. *TR

NHTSA ODI #10217033

Official recalls

0

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

0

No exact-year investigations in this snapshot.