Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
840–25K
4025–50K
4850–75K
4275–100K
42100–150K
11150K+
267 reports with mileage · 49 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports7 fire reports9 injury reports
What owners actually said
316 reports
102,000 miles · Jan 3, 2014
Service BrakesCrash
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH AND DEPRESSING THE BRAKES, THE BRAKE PEDAL ABNORMALLY TRAVELED TO THE FLOORBOARD. THE CONTACT APPLIED THE EMERGENCY BRAKE. THE CONTACT CRASHED AND REAR ENDED ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THERE WERE NO INJURI…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH AND DEPRESSING THE BRAKES, THE BRAKE PEDAL ABNORMALLY TRAVELED TO THE FLOORBOARD. THE CONTACT APPLIED THE EMERGENCY BRAKE. THE CONTACT CRASHED AND REAR ENDED ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE LINES WERE CORRODED AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT HE WAS ADVISED THAT THE PARTS WERE ON A NATIONAL BACK ORDER. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 102,000. *TR
NHTSA ODI #10558374
95,000 miles · Dec 20, 2013
Service Brakes
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING 25 MPH AND DEPRESSING THE BRAKES, THE PEDAL ABNORMALLY TRAVELED TO THE FLOORBOARD. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE BRAKE LINES WERE CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE M…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING 25 MPH AND DEPRESSING THE BRAKES, THE PEDAL ABNORMALLY TRAVELED TO THE FLOORBOARD. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE BRAKE LINES WERE CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 95,000.
NHTSA ODI #10556787
60,000 miles · Nov 30, 2013
Power Train
THIS IS PROBLEM(S) THAT HAS BEEN INTERMITTENT FOR A COUPLE A YEARS SHORTLY AFTER I PURCHASED THE VEHICLE BUT DID NOT MENTION ANYTHING BECAUSE IT WAS SO INTERMITTENT....FIRST THE ILLUMINATION LEVEL SEEMED TO DIM EVERY ONCE IN A WHILE FOR MANY AREAS SUCH AS THE GEAR (PRND), THE SPEEDOMETER, THE TEMP CONTROL LEVELS. NEXT THE SPEEDO…
Read full complaint
THIS IS PROBLEM(S) THAT HAS BEEN INTERMITTENT FOR A COUPLE A YEARS SHORTLY AFTER I PURCHASED THE VEHICLE BUT DID NOT MENTION ANYTHING BECAUSE IT WAS SO INTERMITTENT....FIRST THE ILLUMINATION LEVEL SEEMED TO DIM EVERY ONCE IN A WHILE FOR MANY AREAS SUCH AS THE GEAR (PRND), THE SPEEDOMETER, THE TEMP CONTROL LEVELS. NEXT THE SPEEDOMETER DID NOT REFLECT CORRECT SPEED SOMETIMES EVEN WHEN YOU WERE PARKED. THESE SYMPTOMS WERE INITIALLY INTERMITTENT BUT NOW ARE MORE PREDOMINANT. NOW THIS AT TIMES IS A REAL PROBLEM AND EVEN A SAFETY ISSUE. *TR
NHTSA ODI #10554200
120,000 miles · Nov 22, 2013
Service Brakes
APPROACHING A 4 WAY TRAFFIC SIGNALED INTERSECTION WHEN SIGNAL STARTED TO CHANGE TO YELLOW. DECIDED TO NOT PROCEED THROUGH INTERSECTION SO APPLIED BRAKE PEDAL TO STOP. PEDAL WENT DIRECTLY TO FLOOR, BRAKE DASHBOARD LIGHT ILLUMINATED. VEHICLE WOULD NOT STOP AND PROCEEDED THROUGH INTERSECTION, WHILE VEHICLES TO MY RIGHT PROCEEDED TO…
Read full complaint
APPROACHING A 4 WAY TRAFFIC SIGNALED INTERSECTION WHEN SIGNAL STARTED TO CHANGE TO YELLOW. DECIDED TO NOT PROCEED THROUGH INTERSECTION SO APPLIED BRAKE PEDAL TO STOP. PEDAL WENT DIRECTLY TO FLOOR, BRAKE DASHBOARD LIGHT ILLUMINATED. VEHICLE WOULD NOT STOP AND PROCEEDED THROUGH INTERSECTION, WHILE VEHICLES TO MY RIGHT PROCEEDED TO MOVE. I HAD NO BRAKES AT ALL. I MANEUVERED VEHICLE ONTO A PARALLEL ACCESS ROAD AND VEHICLE EVENTUALLY ROLLED TO A STOP. UPON INSPECTION IT WAS OBVIOUS THAT THERE WAS A FAILURE OF THE BRAKING SYSTEM, AS HYDRAULIC FLUID WAS ON THE ROAD IN THE VICINITY OF THE RIGHT FRONT OF THE VEHICLE...ONLY... I WAS ALWAYS AWARE THAT I HAD SOME BRAKING CAPACITY WHEN I HAD A BRAKE FAILURE. FOLLOWING 8 DAYS AT A GM DEALERSHIP AND A BILL FOR $2,000, THE BRAKE LINES WERE REPLACED FOLLOWING THE DIAGNOSIS "RUSTED/CORRODED BRAKE LINES". A COMPLAINT TO GM HAS FALLEN ON DEAF EARS. *TR
NHTSA ODI #10553296
100,000 miles · Nov 7, 2013
Power Train
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE GEAR POSITION INDICATOR LIGHTING FAILED TO ILLUMINATE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE DEALER WAS CONTACTED AND STATED THAT THE VIN WAS NOT INCLUDED IN THE MANUFACTURER'S RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAIL…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE GEAR POSITION INDICATOR LIGHTING FAILED TO ILLUMINATE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE DEALER WAS CONTACTED AND STATED THAT THE VIN WAS NOT INCLUDED IN THE MANUFACTURER'S RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10551404
90,092 miles · Nov 6, 2013
Service Brakes
I WAS DRIVING MY TRUCK INTO MY DRIVEWAY WHEN I PUT MY FOOT ON BRAKE PEDAL IT WENT TO FLOOR , NO WARNING. WHEN I LOOKED UNDER VEHICLE BRAKE LINE WAS LEAKING, VERY RUSTED. *TR
NHTSA ODI #10551114
64,000 miles · Oct 25, 2013
Service Brakes
REAR STEEL BRAKE LINE CORRODED AND BLEW OUT CAUSING BRAKE FAILURE. THIS HAS HAPPENED TO FOUR PEOPLE I KNOW. ONE OF THOSE PEOPLE HAD A BAD ACCIDENT. ALL VEHICLES WERE CHEVY SILVERADOS. *TR
NHTSA ODI #10549447
150,000 miles · Oct 16, 2013
Service Brakes
ON OUR 2005 CHEVY SILVERADO 2500 HD THE ABS SYSTEM HAS BEEN KICKING IN WHEN COMING TO A STOP AND YOU ALMOST HIT THE CAR IN FRONT OF YOU. I HAVE READ A LOT OF ISSUES WITH THIS AND I HAVE NOT SEEN A RECALL FOR THIS YEAR OF THE CHEVY TRUCK. THE RECALL ONLY STOPS AT 2002 TRUCKS. HOW MANY PEOPLE HAVE TO BE INJURED OR KILLED BEFORE…
Read full complaint
ON OUR 2005 CHEVY SILVERADO 2500 HD THE ABS SYSTEM HAS BEEN KICKING IN WHEN COMING TO A STOP AND YOU ALMOST HIT THE CAR IN FRONT OF YOU. I HAVE READ A LOT OF ISSUES WITH THIS AND I HAVE NOT SEEN A RECALL FOR THIS YEAR OF THE CHEVY TRUCK. THE RECALL ONLY STOPS AT 2002 TRUCKS. HOW MANY PEOPLE HAVE TO BE INJURED OR KILLED BEFORE YOU GUYS DECIDE TO RECALL THIS YEAR OF THE CHEVY TRUCK???? *TR
NHTSA ODI #10548072
46,555 miles · Oct 4, 2013
Service Brakes
THE FIRST INCIDENT OCCURRED IN AUGUST 2013. WHEN BACKING UP (AT APPROXIMATELY 5 MPH), I STEPPED ON THE BRAKES AND THE BRAKES FAILED. THE BRAKE LINE WAS REPLACED OVER THE RIGHT SIDE OF THE REAR END HOUSING. ON OCTOBER 3, 2013, ANOTHER BRAKE LINE FAILED CAUSING THE BRAKE PEDAL TO GO TO THE FLOOR OF THE TRUCK. THIS TIME THE BRA…
Read full complaint
THE FIRST INCIDENT OCCURRED IN AUGUST 2013. WHEN BACKING UP (AT APPROXIMATELY 5 MPH), I STEPPED ON THE BRAKES AND THE BRAKES FAILED. THE BRAKE LINE WAS REPLACED OVER THE RIGHT SIDE OF THE REAR END HOUSING. ON OCTOBER 3, 2013, ANOTHER BRAKE LINE FAILED CAUSING THE BRAKE PEDAL TO GO TO THE FLOOR OF THE TRUCK. THIS TIME THE BRAKE LINE IS ON THE LEFT SIDE OF THE FRAME UNDER THE DRIVER'S COMPARTMENT. *TR
NHTSA ODI #10546714
105,880 miles · Aug 23, 2013
Service Brakes
THE BRAKES WENT OUT BACKING IN TO A DRIVEWAY AND ALL THE FLUID LEAKED ON TO THE DRIVEWAY AND STREET. THIS COULD OF BEEN VERY SERIOUS IF IT HAPPENED ON THE HIGHWAY COMING HOME FROM PICKING UP FURNITURE. ALL THE BRAKE LINES WERE RUSTED AND HAD TO BE REPLACED?????? COSTLY FOR US? *TR
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence & remedy
Consequence: IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
ON CERTAIN TRUCKS, THE BOLT THAT ATTACHES THE INTERMEDIATE STEERING SHAFT TO THE STEERING GEAR MAY NOT MEET SPECIFICATION. THE BOLT MAY FRACTURE RESULTING IN THE LOSS OF STEERING.
Consequence & remedy
Consequence: IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE INTERMEDIATE STEERING SHAFT BOLT FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS MAY CONTACT GMC AT 1-866-996-9463 AND CHEVROLET AT 1-800-630-2438.
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH 5.3L (RPO L59) V8 ENGINES, THE ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREWS WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK.
Consequence & remedy
Consequence: IF THE TUBE RETAINER SCREW BREAKS, FUEL COULD LEAK FROM THE FUEL RAIL CROSSOVER JOINT, THE ENGINE MAY STALL AND, IF AN IGNITION SOURCE WERE PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL RAIL CROSSOVER TUBE AND, IF NECESSARY, REPLACE THE RETAINER SCREWS. OWNERS WERE NOTIFIED BY TELEPHONE ON JULY 30, 2004, WITH A FOLLOWUP OWNER LETTER BEGAN AUGUST 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. NOTE: THE GM BULLETIN LISTS THE TAHOE AND YUKON MODELS BECAUSE CANADIAN VEHICLES ARE INCLUDED IN THE BULLETIN. NO U.S. TAHOE OR YUKON VEHICLES ARE INCLUDED IN THE U.S. CAMPAIGN.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration