Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
840–25K
4025–50K
4850–75K
4275–100K
42100–150K
11150K+
267 reports with mileage · 49 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports7 fire reports9 injury reports
What owners actually said
316 reports
25,143 miles · Jan 24, 2005
Service Brakes, Hydraulic
UPON ATTEMPTING TO BACK UP FROM A PARKED POSITION, AN AUDIBLE "POP" WAS HEARD BY THE VEHICLE OPERATOR AND THREE BYSTANDERS. THE VEHICLE THEN STOPPED MOTION AFTER ABOUT FIVE FEET OF TRAVEL AS THE RIGHT REAR WHEEL WAS LOCKED UP. UPON VISUAL ON-THE-SPOT INSPECTION BY COMPANY MECHANIC, IT WAS OBVIOUS THE CASTING ATTACHED TO THE AXLE…
Read full complaint
UPON ATTEMPTING TO BACK UP FROM A PARKED POSITION, AN AUDIBLE "POP" WAS HEARD BY THE VEHICLE OPERATOR AND THREE BYSTANDERS. THE VEHICLE THEN STOPPED MOTION AFTER ABOUT FIVE FEET OF TRAVEL AS THE RIGHT REAR WHEEL WAS LOCKED UP. UPON VISUAL ON-THE-SPOT INSPECTION BY COMPANY MECHANIC, IT WAS OBVIOUS THE CASTING ATTACHED TO THE AXLE END WHICH ACTS AS THE SUPPORT FOR BOTH THE BRAKE CALIPER AND THE PARKING BRAKE HAD "EXPLODED" WITH A LARGE PIECE SHOOTING ONTO THE GROUND AND OTHER PIECES JAMMING UP IN THE DRUM PART OF THE ROTOR ASSEMBLY CAUSING THE LOCK-UP. VEHICLE IMMOVABLE, WAS FLATBEDED TO THE SELLING DEALER. REPAIR WAS MADE BY REPLACING ALL AFFECTED COMPONENTS WITH NEW, AND WE WERE BILLED EVEN THOUGH VEHICLE WAS WELL WITH-IN ITS ORIGINAL WARRANTY BASED ON SERVICE MANAGERS ASSUMPTION THAT WE (THE OPERATORS) HAD SOMEHOW CONTRIBUTED TO THE FAILURE. TELECOM COMPLAINT TO GM CUST. ASSISTANCE, (FILE NO, 1-299810112) RETURNED SAME RESULTS. IT IS OUR CONTENTION THAT THIS CRITICAL PART FAILED OF ITS OWN ACCORD EITHER THROUGH DEFECT OR DESIGN, AND THAT WE WERE EXTREMELY LUCKY THAT THIS HAPPENED IN OUR PARKING LOT AND NOT ON A HIGHWAY AT 55 MPH. VEHICLE OPERATOR HAS LOST CONFIDENCE IN THE SAFETY OF THIS EQUIPMENT WITHOUT A VALID EXPLANATION AND CORRECTIVE ACTION TO A PERMANENT REMEDY. *NM
NHTSA ODI #10107820
999,999 miles · Jan 14, 2005
Electrical SystemCrashFire
THIS IS A FAILURE OF ALL AUTOS. WHY NOT REQUIRE ALL AUTO MAKERS TO HOOK UP CARS LIGHTS TO THEIR WINDSHIELD WIPERS? THAT WAY IF WIPERS ARE ON LIGHTS ARE ON. *JB
NHTSA ODI #10106321
Mileage unknown · Jan 9, 2005
Latches/locks/linkagesInjury
I HAVE SERIOUS CONCERNS ABOUT THE INTERIOR DOOR HANDLES ON THE 2005 CHEVROLET SILVERADO PU TRUCKS. THE LOCATION AND GENERAL SHAPE OF THESE HANDLES MAKE THEM VERY EASY TO ACCIDENTLY OPEN WHILE VEHICLE IS MOVING. THIS VEHICLE IS EQUIPPED WITH AUTO LOCKS , HOWEVER, THESE SAFETY LOCKS DON'T SEEM TO ALWAYS FUNCTION. THERE ARE CERTAIN…
Read full complaint
I HAVE SERIOUS CONCERNS ABOUT THE INTERIOR DOOR HANDLES ON THE 2005 CHEVROLET SILVERADO PU TRUCKS. THE LOCATION AND GENERAL SHAPE OF THESE HANDLES MAKE THEM VERY EASY TO ACCIDENTLY OPEN WHILE VEHICLE IS MOVING. THIS VEHICLE IS EQUIPPED WITH AUTO LOCKS , HOWEVER, THESE SAFETY LOCKS DON'T SEEM TO ALWAYS FUNCTION. THERE ARE CERTAIN SITUATIONS WHEN A DOOR CAN BE UNLOCKED AND THE AUTOMATIC LOCKS DOES NOT RELOCK. Y WIFE WAS INJURED ON THE INCIDENT DATE. SHE HAD REMOVED HER SEAT BELT TO RETRIEVE ITEMS FROM FLOORBOARD WHEN HER PURSE STRAP SNAGGED ON DOOR HANDLE AND CAUSED THE DOOR TO OPEN. SHE FELL FROM A VEHICLE MOVING AT APPROXIMATELY 35-40 MPH. SHE SUFFERED A CLOSED HEAD INJURY AND CLAVICLE FRACTURE.*AK
NHTSA ODI #10106028
1,444 miles · Jan 9, 2005
Service Brakes, Hydraulic
REAR BRAKES; HANGING UP, THE VEHICLE DID NOT SEEM TO WANT TO MONE FROM A STOPPED POSITION. THREE WEEKS LATER THE SERVICE BRAKE SYSTEM LIGHT CAME ON. THE BRAKE MASTER CYLINDER WAS REMOVED AND REPLACED.*AK
NHTSA ODI #10106018
1,449 miles · Jan 6, 2005
Service Brakes, Hydraulic
I REPORTED THAT THE VEHICLE DID NOT SEEM TO WANT TO MOVE FROM A STOPPED POSITION. APPROXIMATELY THREE WEEKS LATER THE PROBLEM REPEATED ITSELF BUT WITH THE SERVICE BRAKE SYSTEM LIGHTS COMING ON.*AK
NHTSA ODI #10105858
100 miles · Nov 2, 2004
Seats
EASY EXIT AND KEYLESS ENTRY FUNCTION ON KEY FOB DO NOT OPERATE 10 WAY POWER SEAT. ON EXIT SEAT GOES FULL BACK, BUT HAS TO MANUALLY BE REPOSITIONED TO SETTING 1 OR 2. KEY FOB 1 AND 2 DO NOT POSTION SEAT TO PRE-SET POSITIONS 1 AND 2. DEALER NOTED THE COMPUTER INFORMATION CENTER DOES NOT (THIS YEAR) HAVE THE QUESTION CONCERNING OPT…
Read full complaint
EASY EXIT AND KEYLESS ENTRY FUNCTION ON KEY FOB DO NOT OPERATE 10 WAY POWER SEAT. ON EXIT SEAT GOES FULL BACK, BUT HAS TO MANUALLY BE REPOSITIONED TO SETTING 1 OR 2. KEY FOB 1 AND 2 DO NOT POSTION SEAT TO PRE-SET POSITIONS 1 AND 2. DEALER NOTED THE COMPUTER INFORMATION CENTER DOES NOT (THIS YEAR) HAVE THE QUESTION CONCERNING OPTIONS FOR ACTIVATION OF THE EASY EXIT BUTTON. THEREFORE, IT COULD BE CONCLUDED THERE IS A SOFTWARE ISSUE IN THE COMPUTER PROGRAM. I.E. IF THE USER NEVER SELECTS ONE OF THE OPTIONS FOR THE EASY EXIT/KEY FOB PROGRAMS, THEY MAY WELL BE IN THE DEFAULT MODE (NOT ACTIVATED) THIS ISSUE HAS BEEN REPORTED TO DEALER AND GM (CASE NUMBER OPENED). *AK
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence & remedy
Consequence: IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
ON CERTAIN TRUCKS, THE BOLT THAT ATTACHES THE INTERMEDIATE STEERING SHAFT TO THE STEERING GEAR MAY NOT MEET SPECIFICATION. THE BOLT MAY FRACTURE RESULTING IN THE LOSS OF STEERING.
Consequence & remedy
Consequence: IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE INTERMEDIATE STEERING SHAFT BOLT FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS MAY CONTACT GMC AT 1-866-996-9463 AND CHEVROLET AT 1-800-630-2438.
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH 5.3L (RPO L59) V8 ENGINES, THE ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREWS WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK.
Consequence & remedy
Consequence: IF THE TUBE RETAINER SCREW BREAKS, FUEL COULD LEAK FROM THE FUEL RAIL CROSSOVER JOINT, THE ENGINE MAY STALL AND, IF AN IGNITION SOURCE WERE PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL RAIL CROSSOVER TUBE AND, IF NECESSARY, REPLACE THE RETAINER SCREWS. OWNERS WERE NOTIFIED BY TELEPHONE ON JULY 30, 2004, WITH A FOLLOWUP OWNER LETTER BEGAN AUGUST 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. NOTE: THE GM BULLETIN LISTS THE TAHOE AND YUKON MODELS BECAUSE CANADIAN VEHICLES ARE INCLUDED IN THE BULLETIN. NO U.S. TAHOE OR YUKON VEHICLES ARE INCLUDED IN THE U.S. CAMPAIGN.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration