Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
840–25K
4025–50K
4850–75K
4275–100K
42100–150K
11150K+
267 reports with mileage · 49 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports7 fire reports9 injury reports
What owners actually said
316 reports
Mileage unknown · Jun 24, 2005
Engine And Engine CoolingService Brakes, Hydraulic
THE DAY THE VEHICLE WAS PURCHASED THE CONSUMER NOTICED THAT THE CHECK ENGINE LIGHT ON HIS 2005 CHEVROLET SILVERADO HAD ILLUMINATED. *NM THE DEALER RESET THE CHECK ENGINE LIGHT, HOWEVER IT ILLUMINATED AGAIN AND THE DEALER STATED IT WAS A BAD GAS PRESSURE SENSOR. 4 MONTHS AFTER OWNING THE VEHICLE THE VEHICLE STARTED JERKING AND…
Read full complaint
THE DAY THE VEHICLE WAS PURCHASED THE CONSUMER NOTICED THAT THE CHECK ENGINE LIGHT ON HIS 2005 CHEVROLET SILVERADO HAD ILLUMINATED. *NM THE DEALER RESET THE CHECK ENGINE LIGHT, HOWEVER IT ILLUMINATED AGAIN AND THE DEALER STATED IT WAS A BAD GAS PRESSURE SENSOR. 4 MONTHS AFTER OWNING THE VEHICLE THE VEHICLE STARTED JERKING AND THE CONSUMER WAS UNABLE TO PASS OTHER MOTORIST ON THE HIGHWAY. THE CONSUMER MANAGED TO GET TO HIS DESTINATION WHEN ALL OF A SUDDEN ALL OF THE LIGHTS ON THE DASHBOARD LIT UP AND THE VEHICLE CUT OFF. THE DEALER INFORMED THE CONSUMER THE ABS SENSOR AND CRANK POSITIONING SENSOR WERE BAD. *JB *NM
NHTSA ODI #10127930
200 miles · Jun 10, 2005
Visibility
DRIVERS-SIDE OUTSIDE REAR VIEW MIRROR SHAKES EXCESSIVELY, RENDERING IT USELESS. DEALER REPLACED THE MIRROR, BUT STATED THE PROBLEM WAS MOST LIKELY WITH THE AFTERMARKET BUG SHIELD ON THE HOOD. AFTER REPLACEMENT THE MIRROR STILL SHOOK. I REMOVED THE BUG SHIELD, WHICH TOOK CARE OF THE PROBLEM. DEALER STATED THAT A GM BUG SHIELD…
Read full complaint
DRIVERS-SIDE OUTSIDE REAR VIEW MIRROR SHAKES EXCESSIVELY, RENDERING IT USELESS. DEALER REPLACED THE MIRROR, BUT STATED THE PROBLEM WAS MOST LIKELY WITH THE AFTERMARKET BUG SHIELD ON THE HOOD. AFTER REPLACEMENT THE MIRROR STILL SHOOK. I REMOVED THE BUG SHIELD, WHICH TOOK CARE OF THE PROBLEM. DEALER STATED THAT A GM BUG SHIELD WAS DESIGNED NOT TO CAUSE THE DISTURBANCE THAT CAUSES THE MIRROR TO SHAKE.
NHTSA ODI #10124893
9,379 miles · Jun 1, 2005
Power Train
AS THE BRAKES WHERE BEEING APPLIED TO MAKE A STOP THE VEHICLE A 2005 CHEVROLET SILVERADO, STARTED TO REV HIGH WHEN IDLING INTERMITTENTLY.
NHTSA ODI #10123857
476 miles · May 31, 2005
Power Train
THE TRANSMISSION SLIPS UPON ACCELERATION. THE TRANSMISSION WILL SLIP WHEN CROSSING AN INTERSECTION, MAKING THE VEHICLE VOLURNABLE TO BE HIT. THE RPM'S RISE WHILE THE VEHICLE IS IN DRIVE AND THE VEHICLE COMES TO AN ALMOST STAND STILL. THIS HAS HAPPENED A FEW TIMES BUT NO ACCIDENT OCCERED. THE VEHICLE'S TRANSMISSION SLIPPED WHILE …
Read full complaint
THE TRANSMISSION SLIPS UPON ACCELERATION. THE TRANSMISSION WILL SLIP WHEN CROSSING AN INTERSECTION, MAKING THE VEHICLE VOLURNABLE TO BE HIT. THE RPM'S RISE WHILE THE VEHICLE IS IN DRIVE AND THE VEHICLE COMES TO AN ALMOST STAND STILL. THIS HAS HAPPENED A FEW TIMES BUT NO ACCIDENT OCCERED. THE VEHICLE'S TRANSMISSION SLIPPED WHILE CROSSING A 4 LANE DIVIDED HIGHWAY WITH TRAFFIC FLOWING AT 65MPH. NO ACCIDENT OCCERED AND THE TRANSMISSION ENGAGED BEFORE AN ACCIDENT COULD OCCERED. GM HAS BEEN CONTACTED MANY TIMES WITH NO RESPONSE TO FIXING THE PROBLEM. GM WANTS TO DUPLICATE THE PROBLEM BEFORE FIXING, AND TELLING ME NO SERVICE CAN BE DONE AT THIS TIME. GM WANTS ME TO DRIVE THE VEHICLE EVEN THOUGH THEY ARE AWARE OF THIS SAFETY HAZZARD AND PUTTING ME AND MY FAMILY AT RISK ON THE HIGHWAYS.
NHTSA ODI #10122593
Mileage unknown · May 6, 2005
VisibilityCrash
2005 CHEVROLET SILVERADO CUT OUTS IN THE EXTERIOR SIDE VIEW MIRRORS CAUSES BLIND SPOTS.*MR THE MIRROR HAD TO BE REPOSITIONED EACH TME THE CONSUMER WAS BACKING UP TO SEE CRITICAL AREAS. THEN IT HAD TO BE REPOSITIONED AGIAN FOR NORMAL DRIVING. BLIND SPOT CAUSED CONSUMER TO HIT A CONCRETE POST WHEN BACKING. *BF
NHTSA ODI #10120434
Mileage unknown · Apr 21, 2005
Service Brakes, Hydraulic
2005 CHEVROLET SILVERADO EXPERIENCING PROBLEMS WITH STEERING AND BRAKE EQUIPMENT.***NO ANSWER REQUIRED***.*MR WHEN THE CONSUMERS WIFE MADE LEFT TURN, SHE STATED THE STEERING AND FELT SLUGGISH, SHE THEN NOTICED THE BRAKES FELT USELESS. SHE STRUGGLE FOR ABOUT 60 YARDS TO KEEP THE VEHICLE UNDER CONTROL. THE VEHICLE WAS TOWED TO T…
Read full complaint
2005 CHEVROLET SILVERADO EXPERIENCING PROBLEMS WITH STEERING AND BRAKE EQUIPMENT.***NO ANSWER REQUIRED***.*MR WHEN THE CONSUMERS WIFE MADE LEFT TURN, SHE STATED THE STEERING AND FELT SLUGGISH, SHE THEN NOTICED THE BRAKES FELT USELESS. SHE STRUGGLE FOR ABOUT 60 YARDS TO KEEP THE VEHICLE UNDER CONTROL. THE VEHICLE WAS TOWED TO THE DEALER, HOWEVER THEY WERE UNABLE TO RECTIFY THE PROBLEM, BUT THE DEALER DID SUGGEST THAT THE FLOW CONTROL VALVE TO THE BOOST VACUUM POWER IN THE BRAKE AND STEERING SYSTEM BE REPLACED. *JB
NHTSA ODI #10119196
680 miles · Apr 20, 2005
Power Train
MY 2005 CHEVROLET SILVERADO HAS A MANUAL TRANSMISSION. WHEN I CHANGE GEARS IT MAKES A CLANKING SOUND AND IT SOUNDS LIKE THERE LOT OF SLACK IN THE TRANSMISSION. IT JUST HAS 680 MILES.*AK
NHTSA ODI #10118189
Mileage unknown · Apr 19, 2005
Visibility
OUTSIDE REAR VIEW MIRRORS HAVE A BLIND SPOT AT THE REAR BUMPER AREA. MIRROR MUST BE REPOSITIONED, FOR BACKING, EACH TIME TO VIEW AREA, AND THEN REPOSITIONED TO DRIVE FORWARD.*AK
NHTSA ODI #10118116
466 miles · Apr 8, 2005
Service Brakes, Hydraulic
2005 SILVERADO LS EXTENDED CAB: EXTREME HEAT WITH SMOKE BILLOWING FROM THE FRONT DISC BRAKES. EXTREMELY HOT HUBS LEFT AND RIGHT FRONT. PROIR TO TODAYS PRE-FIRE CONDITONS, I REPORTED TO THE CHEVROLET DEALER THAT THE FRONT BRAKES SEEM TO "STICK" WHILE DRIVING AND WERE HOT WITH A BURNING SMELL. (TRUCK WAS PURCHASED LAST MONTH AND …
Read full complaint
2005 SILVERADO LS EXTENDED CAB: EXTREME HEAT WITH SMOKE BILLOWING FROM THE FRONT DISC BRAKES. EXTREMELY HOT HUBS LEFT AND RIGHT FRONT. PROIR TO TODAYS PRE-FIRE CONDITONS, I REPORTED TO THE CHEVROLET DEALER THAT THE FRONT BRAKES SEEM TO "STICK" WHILE DRIVING AND WERE HOT WITH A BURNING SMELL. (TRUCK WAS PURCHASED LAST MONTH AND HAS ONLY 466 MILES) INTERMITTENT HOT HUBS AND BURN SMELL, BUT NO SMOKE. TODAY, REPORTING FIRE CONDITIONS WITH THE EXTREME HEAT AND BILLOWING SMOKE. LEFT A MESSAGE TO THE CHEVROLET DEALER AND WILL PUT IN THEIR SHOP TOMMORROW THE 8TH OF APRIL 2005.*AK
NHTSA ODI #10116590
6,000 miles · Apr 7, 2005
Air BagsCrash
WHILE DRIVING 40 MPH VEHICLE CRASHED INTO A STORE FRONT. UPON IMPACT, DUAL AIRBAGS DID NOT DEPLOY. NO INJURIES REPORTED. *AK
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence & remedy
Consequence: IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
ON CERTAIN TRUCKS, THE BOLT THAT ATTACHES THE INTERMEDIATE STEERING SHAFT TO THE STEERING GEAR MAY NOT MEET SPECIFICATION. THE BOLT MAY FRACTURE RESULTING IN THE LOSS OF STEERING.
Consequence & remedy
Consequence: IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE INTERMEDIATE STEERING SHAFT BOLT FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS MAY CONTACT GMC AT 1-866-996-9463 AND CHEVROLET AT 1-800-630-2438.
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH 5.3L (RPO L59) V8 ENGINES, THE ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREWS WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK.
Consequence & remedy
Consequence: IF THE TUBE RETAINER SCREW BREAKS, FUEL COULD LEAK FROM THE FUEL RAIL CROSSOVER JOINT, THE ENGINE MAY STALL AND, IF AN IGNITION SOURCE WERE PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL RAIL CROSSOVER TUBE AND, IF NECESSARY, REPLACE THE RETAINER SCREWS. OWNERS WERE NOTIFIED BY TELEPHONE ON JULY 30, 2004, WITH A FOLLOWUP OWNER LETTER BEGAN AUGUST 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. NOTE: THE GM BULLETIN LISTS THE TAHOE AND YUKON MODELS BECAUSE CANADIAN VEHICLES ARE INCLUDED IN THE BULLETIN. NO U.S. TAHOE OR YUKON VEHICLES ARE INCLUDED IN THE U.S. CAMPAIGN.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration