NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
61 reportsClear category filter101,097 miles · Jul 7, 2014
Service BrakesCrash
APPROACHING A TRAFFIC LIGHT AT THE BOTTOM OF A STEEP GRADED HIGHWAY, I NOTICED THE BRAKE PEDAL FELT SPUNGEY AND NEAR THE BOTTOM THE BRAKE PEDAL WENT CLEAR TO THE FLOOR BOARD. I WAS FORCED TO LEAVE THE HIGHWAY TO PREVENT A REAR END COLLISION WITH THE STOPPED VEHICLE IN FRONT OF ME RESULTING IN NO REAL DAMAGE TO THE VEHICLE ITSELF…
Read full complaint
APPROACHING A TRAFFIC LIGHT AT THE BOTTOM OF A STEEP GRADED HIGHWAY, I NOTICED THE BRAKE PEDAL FELT SPUNGEY AND NEAR THE BOTTOM THE BRAKE PEDAL WENT CLEAR TO THE FLOOR BOARD. I WAS FORCED TO LEAVE THE HIGHWAY TO PREVENT A REAR END COLLISION WITH THE STOPPED VEHICLE IN FRONT OF ME RESULTING IN NO REAL DAMAGE TO THE VEHICLE ITSELF. IT COULD HAVE BEEN MUCH WORSE. THE BRAKE LINES (4 OF THEM) HAVE RUSTED OUT SO MUCH THAT THEY COULD NOT CONTAIN PRESSURE OF THE FLUID WHEN APPLYING THE BRAKE AND BURSTED. MY MECHANIC TELLS ME THIS WILL BE IN EXCESS OF $600.00 TO REPAIR DO TO THE CAB HAVING TO BE UNBOLTED AND LIFTED FROM THE CHASSIS TO ACCESS THE LINES FOR REPLACING. HE ALSO TELLS ME THAT MANY GM MODELS, NEW AND OLD HAVE THIS PROBLEM WITH RUSTING BRAKE LINES. GM IS AWARE OF THESE PROBLEMS. WHY HAS THIS NOT BEEN ADDRESSED? WHY HAVE THESE MODELS NOT BEEN RECALLED? SUBARU RECENTLY RECALLED OVER 660,000 VEHICLES FOR THE SAME PROBLEM; #DOINGTHERIGHTTHING. I AM NOT AT ALL HAPPY ABOUT THIS. *JS
NHTSA ODI #10608756
134,000 miles · Jul 6, 2014
Electrical SystemFuel/propulsion SystemService Brakes
THE BRAKE LINES AND FUEL LINES RUSTY TO THE POINT THAT THEY ARE LEAKING NEED TO BE REPLACED.THE BLEND MOTOR FOR HVAC ISN'T WORKING RIGHT. *JS
NHTSA ODI #10608414
69,000 miles · Jun 30, 2014
Service Brakes
WHILE DOING AN OIL CHANGE ON MY 2005 PU SILVERADO I NOTICED LARGE RUST BUILD UP ON THE BRAKE LINES' THIS IS NOT THROUGH NEGLECT ON MY PART, BUT IS SUFFICIENT ENOUGH TO CAUSE SERIOUS CONCERN. MY SON IN LAW WITH CHEVY 2002 HAD A SIMILAR PROBLEM WHEN HIS BRAKES FAILED ON A HILL WHICH CAUSED ME TO CHECK MINE.THIS IS EXTREMELY DANG…
Read full complaint
WHILE DOING AN OIL CHANGE ON MY 2005 PU SILVERADO I NOTICED LARGE RUST BUILD UP ON THE BRAKE LINES' THIS IS NOT THROUGH NEGLECT ON MY PART, BUT IS SUFFICIENT ENOUGH TO CAUSE SERIOUS CONCERN. MY SON IN LAW WITH CHEVY 2002 HAD A SIMILAR PROBLEM WHEN HIS BRAKES FAILED ON A HILL WHICH CAUSED ME TO CHECK MINE.THIS IS EXTREMELY DANGEROUS AND GM SHOULD BEAR THE RECALL EXPENSE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10607047
20,500 miles · Jun 21, 2014
Service Brakes
DRIVING DOWN HIGHWAY ROAD WHEN SEVERAL DEER RAN IN FRONT OF VEHICLE. SLAMMED ON BRAKES AND THE PEDAL, AFTER A FEW SECONDS, WENT TO THE FLOOR. NOTICED BIG PUDDLE OF FLUID THE NEXT DAY UNDER CAB OF TRUCK. STARTED TRUCK AND HAD NO BRAKES AT ALL. HAD THE TRUCK INSPECTED BY LOCAL REPAIR SHOP AND WAS INFORMED THAT ALL OF THE BRAKE…
Read full complaint
DRIVING DOWN HIGHWAY ROAD WHEN SEVERAL DEER RAN IN FRONT OF VEHICLE. SLAMMED ON BRAKES AND THE PEDAL, AFTER A FEW SECONDS, WENT TO THE FLOOR. NOTICED BIG PUDDLE OF FLUID THE NEXT DAY UNDER CAB OF TRUCK. STARTED TRUCK AND HAD NO BRAKES AT ALL. HAD THE TRUCK INSPECTED BY LOCAL REPAIR SHOP AND WAS INFORMED THAT ALL OF THE BRAKE LINES WERE RUSTY BEYOND THE POINT OF REPAIR. HAD TO HAVE A WHOLE NEW BRAKE LINE KIT INSTALLED. *TR
NHTSA ODI #10604981
113,149 miles · Jun 13, 2014
Service Brakes
BRAKE PEDAL PUSH TO THE FLOOR, OIL COMING OUT ONTO THE GROUND, BRAKE LINES RUSTED OUT IN MANY PLACES UNDER THE HOOD. *JS
NHTSA ODI #10598175
170,000 miles · Apr 5, 2014
Service Brakes
REAR BRAKE LINE APPEARED RUSTY AND SCALY, THEN WHEN HIT MY BRAKES, THE PEDAL WENT TO THE FLOOR. I USED EMERGENCY BRAKE. I REPLACED REAR BRAKE LINE. ALL OTHER LINES APPEARED RUSTY AND SCALY. NOW, MY FRONT LEFT BRAKE LINE IS BEGINNING TO WEEP; IT'S MOIST AND IT GLISTENS WITH OIL. I WILL HAVE TO REPLACE IT SOON. ALL THE OTHER…
Read full complaint
REAR BRAKE LINE APPEARED RUSTY AND SCALY, THEN WHEN HIT MY BRAKES, THE PEDAL WENT TO THE FLOOR. I USED EMERGENCY BRAKE. I REPLACED REAR BRAKE LINE. ALL OTHER LINES APPEARED RUSTY AND SCALY. NOW, MY FRONT LEFT BRAKE LINE IS BEGINNING TO WEEP; IT'S MOIST AND IT GLISTENS WITH OIL. I WILL HAVE TO REPLACE IT SOON. ALL THE OTHER LINES IN THE TRUCK APPEAR TO BE THE SAME, RUSTY AND SCALY. I WILL NO DOUBT HAVE TO CONTINUE TO REPLACE EACH LINE. *TR
NHTSA ODI #10577643
1,000 miles · Mar 31, 2014
Electrical SystemService Brakes
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE VEHICLE FAILED TO START ACCOMPANIED BY THE ILLUMINATION OF THE CHECK ENGINE WARNING LIGHT. THE FAILURE WAS RECURRING AND SPORADIC. ADDITIONALLY, THE INSTRUMENT PANEL FAILED AND THE HEAD LIGHTS WOULD SPORADICALLY FAIL. THE CONTACT ALSO STATED THAT THE R…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE VEHICLE FAILED TO START ACCOMPANIED BY THE ILLUMINATION OF THE CHECK ENGINE WARNING LIGHT. THE FAILURE WAS RECURRING AND SPORADIC. ADDITIONALLY, THE INSTRUMENT PANEL FAILED AND THE HEAD LIGHTS WOULD SPORADICALLY FAIL. THE CONTACT ALSO STATED THAT THE ROTORS NEEDED TO BE REPLACED ON A REGULAR BASIS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO WAS NOT ABLE TO DIAGNOSE THE MULTIPLE FAILURES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 1000.
NHTSA ODI #10575949
164,412 miles · Jan 9, 2014
Service Brakes
BRAKE LINES RUSTED OUT. TRUCK FAILED TO STOP WITHIN A SAFE DISTANCE ON THE HIGHWAY. BRAKE LINE GAVE OUT ON THE HIGHWAY NO WARNING AT ALL. JUST A SOFT, NON FUNCTIONING PEDAL. LUCKILY I WAS ABLE TO PULL THE TRUCK OVER TO THE SIDE OF THE ROAD NO ACCIDENT. *TR
NHTSA ODI #10559233
72,000 miles · Jan 7, 2014
Air BagsService Brakes
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE AIR BAG SENSOR LIGHT WAS ILLUMINATED. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC THAT DETERMINED A SENSOR INSIDE THE FRONT BUMPER WAS THE CAUSE OF THE DEFECT. THE CONTACT ALSO REPORTED THAT THE DRIVER'S SIDE REAR BRAKE LINE WAS RUSTED AND RUPT…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE AIR BAG SENSOR LIGHT WAS ILLUMINATED. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC THAT DETERMINED A SENSOR INSIDE THE FRONT BUMPER WAS THE CAUSE OF THE DEFECT. THE CONTACT ALSO REPORTED THAT THE DRIVER'S SIDE REAR BRAKE LINE WAS RUSTED AND RUPTURED, WHICH CAUSED THE REAR BRAKES TO BECOME INOPERABLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED FOR THE PROBLEM. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 72,000.
NHTSA ODI #10558784
102,000 miles · Jan 3, 2014
Service BrakesCrash
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH AND DEPRESSING THE BRAKES, THE BRAKE PEDAL ABNORMALLY TRAVELED TO THE FLOORBOARD. THE CONTACT APPLIED THE EMERGENCY BRAKE. THE CONTACT CRASHED AND REAR ENDED ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THERE WERE NO INJURI…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH AND DEPRESSING THE BRAKES, THE BRAKE PEDAL ABNORMALLY TRAVELED TO THE FLOORBOARD. THE CONTACT APPLIED THE EMERGENCY BRAKE. THE CONTACT CRASHED AND REAR ENDED ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE LINES WERE CORRODED AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT HE WAS ADVISED THAT THE PARTS WERE ON A NATIONAL BACK ORDER. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 102,000. *TR
NHTSA ODI #10558374
Official recalls
8Aug 3, 2006
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
Oct 5, 2005
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
Apr 22, 2005
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence & remedy
Consequence: IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Apr 22, 2005
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Feb 14, 2005
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
Feb 8, 2005
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
Jan 21, 2005
ON CERTAIN TRUCKS, THE BOLT THAT ATTACHES THE INTERMEDIATE STEERING SHAFT TO THE STEERING GEAR MAY NOT MEET SPECIFICATION. THE BOLT MAY FRACTURE RESULTING IN THE LOSS OF STEERING.
Consequence & remedy
Consequence: IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE INTERMEDIATE STEERING SHAFT BOLT FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS MAY CONTACT GMC AT 1-866-996-9463 AND CHEVROLET AT 1-800-630-2438.
Aug 2, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH 5.3L (RPO L59) V8 ENGINES, THE ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREWS WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK.
Consequence & remedy
Consequence: IF THE TUBE RETAINER SCREW BREAKS, FUEL COULD LEAK FROM THE FUEL RAIL CROSSOVER JOINT, THE ENGINE MAY STALL AND, IF AN IGNITION SOURCE WERE PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL RAIL CROSSOVER TUBE AND, IF NECESSARY, REPLACE THE RETAINER SCREWS. OWNERS WERE NOTIFIED BY TELEPHONE ON JULY 30, 2004, WITH A FOLLOWUP OWNER LETTER BEGAN AUGUST 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. NOTE: THE GM BULLETIN LISTS THE TAHOE AND YUKON MODELS BECAUSE CANADIAN VEHICLES ARE INCLUDED IN THE BULLETIN. NO U.S. TAHOE OR YUKON VEHICLES ARE INCLUDED IN THE U.S. CAMPAIGN.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration