TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE THE VEHICLE WAS PARKED WITH THE AIR CONDITIONER SET ON LEVEL FIVE, THE BLOWER INTERMITTENTLY CLICKED OFF AND ON. THE CONTACT ALSO STATED THAT A BURNING SMELL EMITTED THROUGH THE VENTS OF THE VEHICLE. THE FAILURE RECURRED ON SEVERAL OCCASIONS UNTIL LEVEL FIVE AND FOUR SETTING…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE THE VEHICLE WAS PARKED WITH THE AIR CONDITIONER SET ON LEVEL FIVE, THE BLOWER INTERMITTENTLY CLICKED OFF AND ON. THE CONTACT ALSO STATED THAT A BURNING SMELL EMITTED THROUGH THE VENTS OF THE VEHICLE. THE FAILURE RECURRED ON SEVERAL OCCASIONS UNTIL LEVEL FIVE AND FOUR SETTINGS NO LONGER WORKED. THE CONTACT INSPECTED THE CONNECTOR SW/POWER ST ADJUSTER AND DISCOVERED THAT THE WIRES WERE MELTED. THE VEHICLE WAS TAKEN TO THE DEALER AND WAS NOT DIAGNOSED OR REPAIRED. THE DEALER INFORMED THE CONTACT THAT THE CONNECTOR AND RESISTOR FOR THE AIR CONDITIONER AND HEATER AND THE RESISTOR FOR THE HEATER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000.
NHTSA ODI #10790722
98,750 miles · Mar 19, 2015
Electrical System
SPEEDOMETER DOES NOT READ ACCURATE. IT EITHER READS 15 MPH AT HIGHWAY SPEEDS, OR GOES WAY HIGH SUCH AS 120 MPH AT 55 TO 60 MPH. SOMETIMES AT THE HIGHER READING, IT WILL READ 60 MPH WHEN VEHICLE IS STOPPED, IN PARK, AND IGNITION OFF. I WAS TOLD THIS IS A STEPPING MOTOR BUT HARD TO CHANGE AND EXPENSIVE TO CHANGE. I HAVE READ THAT …
Read full complaint
SPEEDOMETER DOES NOT READ ACCURATE. IT EITHER READS 15 MPH AT HIGHWAY SPEEDS, OR GOES WAY HIGH SUCH AS 120 MPH AT 55 TO 60 MPH. SOMETIMES AT THE HIGHER READING, IT WILL READ 60 MPH WHEN VEHICLE IS STOPPED, IN PARK, AND IGNITION OFF. I WAS TOLD THIS IS A STEPPING MOTOR BUT HARD TO CHANGE AND EXPENSIVE TO CHANGE. I HAVE READ THAT THERE WAS A CLASS ACTION LAWSUIT THAT WAS NEVER BROUGHT UP. *TR
NHTSA ODI #10695278
45,000 miles · Aug 21, 2014
Electrical System
THE DASHBOARD CLUSTER WENT OUT, SPEED ODOMETER STUCK ON 60MPH. HAD TO RACE MOTOR UP UNTIL IT RED LINE RETURNED TO 0. THE ENTIRE ELECTRICAL BOARD STOPPED WORKING, FOUND OUT WAS A RECALL BUT MY VIN WAS NOT INCLUDED. SPOKE TO AUTRY MORLAN DEALERSHIP SEVERAL TIMES. WE PAID OUT OF POCKET TO HAVE REPLACED AND THAT CLUSTER HAS DONE …
Read full complaint
THE DASHBOARD CLUSTER WENT OUT, SPEED ODOMETER STUCK ON 60MPH. HAD TO RACE MOTOR UP UNTIL IT RED LINE RETURNED TO 0. THE ENTIRE ELECTRICAL BOARD STOPPED WORKING, FOUND OUT WAS A RECALL BUT MY VIN WAS NOT INCLUDED. SPOKE TO AUTRY MORLAN DEALERSHIP SEVERAL TIMES. WE PAID OUT OF POCKET TO HAVE REPLACED AND THAT CLUSTER HAS DONE SAME THING. STILL NO RECALL ON OUR TRUCK. WILL COST ANOTHER 200-300 TO FIX OUT OF POCKET. GAS GAUGE DOES NOT WORK, SPEED ODOMETER DOES NOT WORK. RPM WILL WORK AND THAT IS HOW WE JUDGE OUR SPEED ON TRUCK. *TR
NHTSA ODI #10626944
35,300 miles · Aug 18, 2014
Air BagsElectrical System
TURNED KEY ON AND LIGHT SAYING SERVICE AIRBAG CAME ON. LOCAL MECHANIC SAID HE READ THAT THERE WAS GOING TO BE A RECALL ON IT. *TR
NHTSA ODI #10626194
75,000 miles · Jul 15, 2014
Electrical SystemSeat Belts
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE DOOR AJAR SAFETY ALARM AND THE SEAT BELT ALARM CHIME FAILED. THE CONTACT INDICATED THAT WHILE THE DOOR WAS OPENED WHILE THE VEHICLE WAS IN MOTION BUT THE CHIME DID NOT ACTIVATE . ADDITIONALLY, THE CHIME DID NOT SOUND WHEN THE SEAT BELTS WERE NOT SECURED…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE DOOR AJAR SAFETY ALARM AND THE SEAT BELT ALARM CHIME FAILED. THE CONTACT INDICATED THAT WHILE THE DOOR WAS OPENED WHILE THE VEHICLE WAS IN MOTION BUT THE CHIME DID NOT ACTIVATE . ADDITIONALLY, THE CHIME DID NOT SOUND WHEN THE SEAT BELTS WERE NOT SECURED WHILE THE VEHICLE WAS IN MOTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 75,000.
THE BRAKE LINES AND FUEL LINES RUSTY TO THE POINT THAT THEY ARE LEAKING NEED TO BE REPLACED.THE BLEND MOTOR FOR HVAC ISN'T WORKING RIGHT. *JS
NHTSA ODI #10608414
101,000 miles · Apr 19, 2014
Electrical System
WAS DRIVING DOWN ROAD LOOKED DOWN AT MY SPEEDOMETER AND IT WAS PEGGED OUT OVER 120 MPH I WAS ONLY GOING ABOUT 15MPH SO I STOPPED AND TURNED OFF TRUCK AND SPEEDOMETER WENT DOWN TO 60 NOT 0 AS IT SHOULD I TURNED IT BACK ON AND TOOK OFF IT DID SAME THING ALL WAY OVER 120 MPH SO WHEN I GOT WHERE I WAS HEADING AND TURNED TRUCK OFF AG…
Read full complaint
WAS DRIVING DOWN ROAD LOOKED DOWN AT MY SPEEDOMETER AND IT WAS PEGGED OUT OVER 120 MPH I WAS ONLY GOING ABOUT 15MPH SO I STOPPED AND TURNED OFF TRUCK AND SPEEDOMETER WENT DOWN TO 60 NOT 0 AS IT SHOULD I TURNED IT BACK ON AND TOOK OFF IT DID SAME THING ALL WAY OVER 120 MPH SO WHEN I GOT WHERE I WAS HEADING AND TURNED TRUCK OFF AGAIN SAME THING JUST DROPPED TO 60 SO I KEPT TURNING KEY ON AND OFF AND IT WOULD DROP ABOUT 5MPH EACH TIME UNTIL IT GOT TO 0 WENT TO DEALER HE SAID LOT OF PROBLEMS WITH THIS MODEL TRUCK I WOULD NEED A NEW DASH AND IT WOULD COST ME $1200 I THINK GM SHOULD FIX THESE TRUCK IT THE LAW TO HAVE A WORKING SPEEDOMETER ON YOUR TRUCK THANK YOU. *TR
NHTSA ODI #10583621
1,000 miles · Mar 31, 2014
Electrical SystemService Brakes
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE VEHICLE FAILED TO START ACCOMPANIED BY THE ILLUMINATION OF THE CHECK ENGINE WARNING LIGHT. THE FAILURE WAS RECURRING AND SPORADIC. ADDITIONALLY, THE INSTRUMENT PANEL FAILED AND THE HEAD LIGHTS WOULD SPORADICALLY FAIL. THE CONTACT ALSO STATED THAT THE R…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE VEHICLE FAILED TO START ACCOMPANIED BY THE ILLUMINATION OF THE CHECK ENGINE WARNING LIGHT. THE FAILURE WAS RECURRING AND SPORADIC. ADDITIONALLY, THE INSTRUMENT PANEL FAILED AND THE HEAD LIGHTS WOULD SPORADICALLY FAIL. THE CONTACT ALSO STATED THAT THE ROTORS NEEDED TO BE REPLACED ON A REGULAR BASIS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO WAS NOT ABLE TO DIAGNOSE THE MULTIPLE FAILURES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 1000.
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence & remedy
Consequence: IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
ON CERTAIN TRUCKS, THE BOLT THAT ATTACHES THE INTERMEDIATE STEERING SHAFT TO THE STEERING GEAR MAY NOT MEET SPECIFICATION. THE BOLT MAY FRACTURE RESULTING IN THE LOSS OF STEERING.
Consequence & remedy
Consequence: IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE INTERMEDIATE STEERING SHAFT BOLT FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS MAY CONTACT GMC AT 1-866-996-9463 AND CHEVROLET AT 1-800-630-2438.
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH 5.3L (RPO L59) V8 ENGINES, THE ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREWS WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK.
Consequence & remedy
Consequence: IF THE TUBE RETAINER SCREW BREAKS, FUEL COULD LEAK FROM THE FUEL RAIL CROSSOVER JOINT, THE ENGINE MAY STALL AND, IF AN IGNITION SOURCE WERE PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL RAIL CROSSOVER TUBE AND, IF NECESSARY, REPLACE THE RETAINER SCREWS. OWNERS WERE NOTIFIED BY TELEPHONE ON JULY 30, 2004, WITH A FOLLOWUP OWNER LETTER BEGAN AUGUST 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. NOTE: THE GM BULLETIN LISTS THE TAHOE AND YUKON MODELS BECAUSE CANADIAN VEHICLES ARE INCLUDED IN THE BULLETIN. NO U.S. TAHOE OR YUKON VEHICLES ARE INCLUDED IN THE U.S. CAMPAIGN.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration