IllustrationPASSENGER SIDE LOW BEAM HEADLIGHT WENT OUT. IT WAS REPLACED AND WITHIN 2 WEEKS IT WENT OUT AGAIN. REPLACED IT FOR THE SECOND TIME, BUT LIGHT WOULD NOT COME ON AT ALL. WHEN INSTALLED THE BULB WAS NOT TOUCHED AND GREASE/LUBRICATE WAS PUT INSIDE THE PLUG IN.
2011 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2011 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
650–25K
10125–50K
15950–75K
17575–100K
176100–150K
55150K+
731 reports with mileage · 246 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 213 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electronic Stability Control (esc). Review the 174 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
40 crash reports17 fire reports30 injury reports
What owners actually said
977 reportsI HAD THE CAR FOR ABOUT 6 MONTHS LAST NOVEMBER OR SO AND DECIDED TO HAVE MY HEADLIGHT BULBS, BLINKERS, ETC ALL CHANGED SINCE THE BUMPER HAS TO COME OFF. I ALREADY HAD THE PASSENGER BULB OUT. TWO MONTHS AFTER THIS REPAIR WAS DONE THE SAME HEADLIGHT WENT OUT AGAIN. THIS WAS REPLACED AND LASTED FOR A FEW MORE MONTHS AND JUST WENT O…
Read full complaint
I HAD THE CAR FOR ABOUT 6 MONTHS LAST NOVEMBER OR SO AND DECIDED TO HAVE MY HEADLIGHT BULBS, BLINKERS, ETC ALL CHANGED SINCE THE BUMPER HAS TO COME OFF. I ALREADY HAD THE PASSENGER BULB OUT. TWO MONTHS AFTER THIS REPAIR WAS DONE THE SAME HEADLIGHT WENT OUT AGAIN. THIS WAS REPLACED AND LASTED FOR A FEW MORE MONTHS AND JUST WENT OUT AGAIN 07-21-19 FOR THE 3RD TIME IN 8 MONTHS. I HAVE LOOKED ONLINE AND THIS APPEARS TO BE A RECURRING PROBLEM FOR MANY MALIBU OWNERS OVER MANY MODEL YEARS.
EVERY YEAR HAD TO GET MY CONNECTOR REPLACED BECAUSE MY LIGHT BULB KEEPS GOING OUT. HAPPENING FOR THE PAST 3 YEARS.
MY PASSENGER HEADLIGHT WENT OUT ON THE HIGHWAY AT NIGHT. I REPLACED THE LIGHT AND IT WENT OUT THE NEXT DAY. I TOOK THE CAR TO GET SERVICED AND FOUND OUT THAT THE HEADLIGHT PIGTAIL WAS MELTED.I BELIEVE THE PROBLEM TO BE THE DRL RELAY SWITCH BECAUSE THERE ARE NUMEROUS CHEVROLET MODELS HAVING THIS PROBLEM.
PASSENGER SIDE HEADLIGHT KEEPS GOING OUT VERY OFTEN (THREE TIMES IN THE LAST MONTH) BECAUSE THE PLASTIC CONNECTOR MELTS.
NOTHING HAPPENED SPECIFICALLY. MY LOW BEAMS (MAINLY PASSENGER SIDE) KEEPS GOING OUT. IT DOESN'T BURN OUT, IT JUST SIMPLY QUITS WORKING. EVERY NOW AND THEN I'LL HIT A BUMP AND IT WILL COME BACK ON, BUT THAT'S RARE. IT CAN BE SITTING OR IN DRIVE WHEN THIS HAPPENS.
WHILE DRIVING SERVICE TRACTION AND SERVICE ESC LIGHTS COME ON AND CAR STARTS DRIVING WEIRD AND DOESN'T FEEL SAFE!
THE HEADLIGHTS ON MY 2011 CHEVY MALIBU HAVE GONE OUT ABOUT SIX TIMES. I HAVE REPLACED BULBS AND WIRING HARNESSES WHICH INVOLVES THE REMOVAL OF THE COMPLETE FRONT FASCIA OF THE VEHICLE. MY DAUGHTER DRIVES THIS VEHICLE AT COLLEGE AND HAS BEEN PULLED OVER NUMEROUS TIMES. THIS IS UNACCEPTABLE AND A SAFETY HAZARD AT NIGHT.
THE FUSE FOR MY REAR DEFROSTER GOT SO HOT IN THE FUSE BOX IT MELTED THE PANEL-THE FUSE BOX IS IN THE TRUNK-I TOOK TO DEALER AND THEY WANT OVER 500.00 TO REPAIR- I FEEL LIKE THIS IS A SAFETY ISSUE AND HAZARD FOR DRIVERS AS IT COULD HAVE CAUGHT FIRE IF IT WAS THAT HOT- I DO NOT FEEL LIKE THIS IS MY FAULT AND MORE A MANUFACTURE ISS…
Read full complaint
THE FUSE FOR MY REAR DEFROSTER GOT SO HOT IN THE FUSE BOX IT MELTED THE PANEL-THE FUSE BOX IS IN THE TRUNK-I TOOK TO DEALER AND THEY WANT OVER 500.00 TO REPAIR- I FEEL LIKE THIS IS A SAFETY ISSUE AND HAZARD FOR DRIVERS AS IT COULD HAVE CAUGHT FIRE IF IT WAS THAT HOT- I DO NOT FEEL LIKE THIS IS MY FAULT AND MORE A MANUFACTURE ISSUE-IF I DON'T GET THIS FIXED I WILL NEVER BUY ANOTHER CHEVY AGAIN AND I AM LOOKING TO PURCHASE A CAR WITHIN THE END OF THIS YEAR. WHY TRY AND MAKE DRIVERS PAY FOR SOMETHING THAT IS MANUFACTURE? SHADY BUSINESS! ALSO NOW MY RADIO DISPLAY IS GOING IN AND OUT-THINKING MAYBE ANOTHER FUSE ISSUE OR ELECTRICAL.
81K MILES ON VEHICLE. DRIVING AT RESIDENTIAL SPEEDS (~ 30 MPH), VEHICLE STARTED SUDDENLY DOWNSHIFTING, ENGINE REVVING, THEN REFUSING TO GET OUT OF 1ST GEAR. I WOULD HATE TO THINK WHAT WOULD HAVE HAPPENED ON A HIGHWAY OR CROWDED CITY STREET!
Official recalls
319V019000 · Air Bags:frontal:driver Side:inflator Module
Jan 16, 2019
General Motors LLC (GM) is recalling certain 2010-2011 Chevrolet Malibu vehicles. In the event of a crash necessitating deployment of the driver frontal air bag, the air bag inflator may explode due to being overpressurized.
Consequence & remedy
Consequence: If the inflator explodes, sharp metal fragments may strike the driver or other occupants resulting in serious injury or death.
Remedy: GM has notified owners, and dealers will replace the front driver air bag module, free of charge. The recall began February 25, 2019. Owners may contact GM customer service at 1-800-522-9559. GM's number for this recall is N182206630.
15V269000 · Seat Belts
May 8, 2015
General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.
Consequence & remedy
Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.