Electrical System. Review the 290 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 202 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 191 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

50 crash reports13 fire reports27 injury reports

What owners actually said

906 reports

Mileage unknown · Aug 31, 2026

Seats

Read full complaint

Car has 161,848 miles and the seat frame broke on the drivers side of my 2012 Chevy Malibu. It had a slight tilt to the right. It was taken to the Chevrolet Dealership and they inspected and verified that the frame welding was broken. I have a video from the service tech showing the broken frame. I took a screen shot of the video and attached it to this incident repot. I would be happy to share the video but it won't allow me to share on this page. I asked the dealership if there was any recall because I find it hard to believe that a seat frame would just break. I have gone online and read that multiple people have had this issue however, Chevrolet has done nothing about it. A few people have at least gotten somewhat of a compensation for having to replace something that should last the life of the vehicle. I was not one of them. I had to pay over a thousand dollars for a USED frame and labor. What is to keep this frame from cracking too? I think Chevrolet should do better.

NHTSA ODI #11761110

Mileage unknown · Jul 22, 2026

Electrical System

Read full complaint

Electrical system problems that create unsafe driving conditions!! Vehicle has electrical glitches. Internal warning lights flicker on and off. Battery drains. Car randomly will not start. Multiple incidents. Car stalled on roadway without warning and would not crank. Luckily I was in a residential neighborhood with little to no traffic when this happened. I have had crank sensors replaced, fuel pump module replaced, fuses replaced and still problems occur. If this is a common issue with the 2012 Chevrolet Malibu, could you please issue a safety recall? Thank you

NHTSA ODI #11752135

Mileage unknown · Mar 26, 2026

Electrical System

Rear defrost stopped working. Hasn't worked in years. I took it to GM, they had a print out of a kit that I had to purchase to repair. This stopped working back around 2016.

NHTSA ODI #11727179

Mileage unknown · Mar 21, 2026

Air BagsSeat Belts

My airbag warning light and notification have came on and sometimes seat belt lights come on unexpectedly and will not go off I feel like this is a safety issue

NHTSA ODI #11725989

Mileage unknown · Mar 11, 2026

Steering

Read full complaint

On March 4, 2026, my wife was driving the vehicle when she suddenly lost power steering. The steering wheel became extremely difficult to turn, creating a dangerous situation that could have resulted in serious injury. She was able to safely pull over and contact me. I carefully drove the vehicle home. The vehicle was taken to Jeff Wyler Chevrolet of Columbus for diagnosis and repair. The dealership confirmed that the problem involved the power steering system. The repair cost was $1,513.03. After researching the issue, I discovered that this 2012 Malibu is subject to a special coverage related to the steering torque sensor. General Motors had reportedly sent notification letters to owners, but we never received one. Had we been aware, we would have addressed the issue immediately. This defect represents a significant safety risk, as sudden loss of power steering could cause an accident or serious injury.

NHTSA ODI #11723670

Mileage unknown · Feb 25, 2026

Steering

i was driving and the steering wheel locked, the whole steering column has to be replaced it brought up a code saying torque input sensor i've only put 10,000 miles on this car and have only had it for 11 months

NHTSA ODI #11720451

Mileage unknown · Feb 22, 2026

Electrical SystemExterior LightingVehicle Speed Control

Was driving home on the parkway and the headlights shut off on their own had to call for roadside assistance to get my vehicle home they will work on dim but brights will not work and if I drive for more than an hour and a half they will not work at all the speed sensor keeps going bad after having it replaced multiple times

NHTSA ODI #11719671

Mileage unknown · Feb 22, 2026

Seat Belts

I have tried since July of 2025 to have a recall fixed I have been in contact with multiple dealerships for Chevy and none have contacted me to fix my recall I've left messages and still no response

NHTSA ODI #11719670

Mileage unknown · Jan 15, 2026

Steering

The “service ESC” light came on while I was driving on the freeway causing the steering wheel to lock up and I couldn’t turn the wheel. It was really stiff after it said “Service ESC” and “ESC Off”

NHTSA ODI #11711045

111,000 miles · Jan 13, 2026

Electronic Stability Control (esc)Steering

Read full complaint

The contact owns a 2012 Chevrolet Malibu. The contact stated that the power steering warning light was illuminated, and the message "ESC OFF" was displayed. The contact stated that the vehicle experienced an intermittent loss of power steering while driving. The contact stated that upon restarting the vehicle, the vehicle operated as intended; however, the failure initially became a persistent failure upon restarting the vehicle and then became a permanent failure. The contact stated that upon taking the vehicle to an independent mechanic for a tire replacement, the contact was also informed that the steering failure was related to Chevrolet Special Coverage Number: 15356. The contact was referred to the dealer, who informed the contact that the VIN was not included in a recall. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 111,000.

NHTSA ODI #11710607

Official recalls

15V269000 · Seat Belts

May 8, 2015

General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.

Consequence & remedy

Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.

Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.

14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control

May 14, 2014

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence & remedy

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Additional source detail variants (5)

Electronic Stability Control (esc)