Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 213 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electronic Stability Control (esc). Review the 174 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

40 crash reports17 fire reports30 injury reports

Structure complaints

19 reports

Clear category filter

Mileage unknown · Sep 18, 2024

Structure

Read full complaint

I was under this car inspecting the exhaust system when I noticed the steel rear impact beam was rusty. Upon further inspection, I found that it was completely rusted and rotted out and was being held up by the wire for the license plate light. The car has quite a few miles on in but no other parts of the car are rusted like this. An automotive Engineer inspected it and advised us to replace it. There is no way for customers to know of this issue or easily watch out for it and I am concerned that this may be an issue in other Malibus. This is a huge safety issue as there was no rear protection during a crash due to the severity of the rust on this rear impact beam.

NHTSA ODI #11615209

Mileage unknown · Feb 11, 2023

SteeringStructure

Read full complaint

I have bought multiple Chevy Malibu manufactured in the 2008-2012 year range and I have experienced the same problems on all of them. The first one is almost everytime I remotely start the car and begin to drive the electric power steering feature goes out until I park the car and restart it. Another problem I’ve been experiencing is the the passenger door malfunctions and does not open from The inside or outside even though the locking system is working properly. Upon looking online I have also seen there’s been a good amount of people reporting the same problem

NHTSA ODI #11506750

100,000 miles · Oct 21, 2020

Electrical SystemEngineStructure

Read full complaint

MY TEENAGE SON WAS DRIVING IN THE RAIN WHEN HIS MALIBU GAVE ENGINE POWER REDUCED, SERVICE TRACTION, SERVICE ESC, AND ESC OFF WARNINGS. CAR WAS BARELY DRIVABLE. THIS IS A SAFETY ISSUE SINCE IT HAPPENS SUDDENLY AND INCREASE THE CHANCES OF A COLLISION WITH OTHER VEHICLES. CODE READER SHOWED THE P2138 DTC. THE HEADLINER ABOVE THE DRIVER SIDE DOOR WAS ALSO WET. THIS APPEARS TO BE COMING FROM THE SUN ROOF. I BELIEVE THAT THIS LEAKAGE IS CAUSING ELECTRICAL CONNECTION ISSUES SOMEWHERE ELSE IN THE CAR THAT IS CAUSING THE ABOVE MENTIONED WARNINGS AND PERFORMANCE ISSUES. ACCORDING THE THE CHEVY WEBSITE, THERE ARE NO RECALLS APPLICABLE TO THIS CAR BASED ON ITS VIN.

NHTSA ODI #11365506

5 miles · Aug 19, 2019

EngineStructure

Read full complaint

TAKATA RECALL... THE UNDERCARRIAGE FELL DOWN UNEXPECTEDLY WHILE DRIVING. THE MOST IMPORTANT THING IS THAT I HAVE BEEN CONTINUALLY GETTING AN ERROR THAT MY ENGINE REDUCED/ENGINE DISABLED AND IT SHUTS OFF WHILE I'M DRIVING ON THE STREET. I MAY GET A FEW SECONDS OF MOTION TO GET TO THE SIDE OF THE ROAD BEFORE IT STOPS COMPLETELY. IT'S HAPPENED WITH MY CHILD IN THE CAR AND THAT SCARES ME MORE TO THINK IT MAY HAPPEN AGAIN. IT HAS HAPPENED 3 TIME IN THE PAST 5 WEEKS. I'VE HAD A TUNE UP AND A NUMBER OF THINGS REPLACED IN THE PAST 12 MONTHS. MY ENGINE LIGHT CAME ON AGAIN AND ONE OF THE SAME SENSORS ON THE ENGINE HAD TO BE REPLACED AGAIN.

NHTSA ODI #11244869

178,000 miles · May 29, 2019

Structure

I TRIED TO OPEN MY DRIVERS SIDE DOOR AND IT WOULD NOT OPEN RANDOMLY LOOKED IT UP ONLINE AND APPARENTLY ALOT OF OTHER PEOPLE WERE HAVING THIS PROBLEM WITH NO WAY TO FIX BECAUSE THEY COULD NOT GET TO THE PROBLEM WITH THE DOOR STUCK SHUT, WITH NO SOLUTION SHOULD BE COVERED BY CHEVROLET IN A RECALL

NHTSA ODI #11210522

105,000 miles · Dec 4, 2018

Electrical SystemEngineStructureFire

Read full complaint

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE FAILED TO START UPON ATTEMPTING TO TURN THE KEY IN THE IGNITION. WOOD MOTOR COMPANY (600 US-62, HARRISON, AR 72601, (870) 741-8211) INDICATED THAT THERE WAS AN INTERNAL ELECTRICAL AND ENGINE FAILURE THAT REQUIRED DIAGNOSTIC TESTING. THE DEALER STATED THAT THE REPAIR MAY BE EXTENSIVE. THE DEALER INDICATED THAT THE TIMING CHAIN, GEAR, BELT, AND VALVES WITHIN THE ENGINE ASSEMBLY MAY NEED TO BE REPLACED. THE DEALER ALSO STATED THAT THE PISTONS HAD NOT BEEN FIRING AT THE RIGHT TIME AND THERE WAS AN INTERNAL MELTDOWN OF THE DASHBOARD AREA. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.

NHTSA ODI #11155911

96,000 miles · Nov 14, 2017

Structure

FRONT PASSENGER DOOR CANNOT BE OPENED FROM OUTSIDE OR INSIDE. HAD TO CLIMB OVER SEAT TO GET OUT OF THE BACK DOOR. CAR WAS IN A PARKING LOT.

NHTSA ODI #11046057

60,000 miles · Jan 11, 2017

Electrical SystemStructure

THE DRIVER'S SIDE BODY SEAM OF MY 2011 CHEVY MALIBU WAS NOT PROPERLY SEALED. THIS ALLOWED WATER TO LEAK INTO MY ELECTRICAL PANEL CAUSE CORROSION TO ALL OF MY WIRING. I DETERMINED THIS AFTER DRIVING DOWN A HIGH WAY AT 60 MPH AND HAVING MY CAR DROP DOWN TO 10 MPH WITH SERVICE ENGINE LIGHTS, ENGINE POWER REDUCED WARNINGS ALL LIGHT…

Read full complaint

NHTSA ODI #10944360

30,000 miles · May 11, 2016

SteeringStructure

Read full complaint

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THAT THE AREA WHERE THE FRONT DRIVER SIDE SEAT WAS WELDED HAD FRACTURED. AS A RESULT, THE SEAT FAILED TO REMAIN IN POSITION. IN ADDITION, WHILE MAKING A LEFT TURN AT VARIOUS SPEEDS, THE STEERING WHEEL STEERED TO THE LEFT IN EXCESS AND THERE WAS AN ABNORMAL NOISE COMING FROM THE STEERING WHEEL. THE ESC WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 30,000.

NHTSA ODI #10864441

58,000 miles · Feb 1, 2016

Structure

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT 5 MPH, THE VEHICLE MADE A LOUD SQUEALING NOISE COMING FROM THE EXTERIOR BODY OF THE VEHICLE. THE VEHICLE WAS TAKEN TO BE REPAIRED BUT THE DEALER COULD NOT REPLICATE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE M…

Read full complaint

NHTSA ODI #10823469

Official recalls

19V019000 · Air Bags:frontal:driver Side:inflator Module

Jan 16, 2019

General Motors LLC (GM) is recalling certain 2010-2011 Chevrolet Malibu vehicles. In the event of a crash necessitating deployment of the driver frontal air bag, the air bag inflator may explode due to being overpressurized.

Consequence & remedy

Consequence: If the inflator explodes, sharp metal fragments may strike the driver or other occupants resulting in serious injury or death.

Remedy: GM has notified owners, and dealers will replace the front driver air bag module, free of charge. The recall began February 25, 2019. Owners may contact GM customer service at 1-800-522-9559. GM's number for this recall is N182206630.

15V269000 · Seat Belts

May 8, 2015

General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.

Consequence & remedy

Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.

Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.

14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control

May 14, 2014

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence & remedy

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Additional source detail variants (5)

Electronic Stability Control (esc)