Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 213 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electronic Stability Control (esc). Review the 174 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

40 crash reports17 fire reports30 injury reports

Engine And Engine Cooling complaints

12 reports

Clear category filter

Mileage unknown · Feb 20, 2015

Engine And Engine CoolingFuel/propulsion System

MY CAR WILL NOT START. IT TURNS OVER BUT WON'T START. BATTERY IS FULLY CHARGED, GAS TANK FULL, WIRING IS GOOD, SPARK PLUGS ARE BRAND NEW, JUST WON'T START AND I DON'T KNOW WHY. *TR

NHTSA ODI #10689550

35,600 miles · Feb 13, 2015

Engine And Engine Cooling

Read full complaint

I WAS SLOWING DOWN AT A VERY BUSY INTERSECTION, TRAVELING AT ABOUT 10MPH. SUDDENLY THE CAR STARTED TO SHAKE VIOLENTLY AND WHEN I PRESSED ON THE GAS AS TRAFFIC STARTED TO MOVE AGAIN, THE CAR WOULD BARELY CRAWL FORWARD. THE REDUCED ENGINE POWER LIGHT AND TRACTION CONTROL LIGHT CAME ON. I MANAGED TO PULL INTO A PARKING LOT AND TURNED THE ENGINE OFF. I TURNED IT BACK ON AND THE SAME PROBLEM OCCURRED. AGAIN, I TURNED THE ENGINE OFF AND ON AND THIS TIME THE CAR SEEMED TO DRIVE AS NORMAL, HOWEVER THE CHECK ENGINE LIGHT REMAINED ON. I'M JUST HAPPY THAT I WASN'T TRAVELING AT A HIGHER SPEED AND THAT NO ONE HIT ME FROM BEHIND WHEN THIS OCCURRED. I HAVE READ ON CHEVY FORUMS THAT MANY PEOPLE ARE HAVING THE SAME PROBLEMS. HOPEFULLY CHEVY CAN FIND AN ANSWER TO THIS PROBLEM BEFORE SOMEONE GETS SERIOUSLY HURT. *TR

NHTSA ODI #10683390

Mileage unknown · Oct 7, 2014

Engine And Engine CoolingPower Train

Read full complaint

I WENT TO GET AIR IN TIRE. GOT BACK IN MY CAR AND STARTED IT UP. IT STARTED SHAKING REAL BAD AND ENGINE LIGHT CAME ON , CHECK ENGINE LIGHT CAME ON, AND A THING ABOUT LOSS OF POWER. I WAS ONLY 5 MINUTES FROM HOME SO I WENT BACK HOME. IT WOULDN'T GET OVER 25 MILES AN HOUR. I CALLED EDWARD CHEVROLET IN BIRMINGHAM,AL. THEY TOLD ME TO GET CAR TO THEM BUT NOT DRIVE IT. THEY CALLED ME BACK AND SAID IT WASN'T UNDER WARRANTY. I DON'T EVEN HAVE 100,000 ON IT. I READ ON LINE OTHER PEOPLE HAD THIS PROBLEM BUT THEY SAY IT'S NOT ON RECALL. WHY? HOW MANY PEOPLE HAVE TO DIE OR CHILDREN? I DIDN'T READ OF ANY DEATHS JUST ALMOST. I CAN'T BELIEVE PEOPLE HAVE TO DIE TO GET SOMETHING DONE. I WAS LUCKY AND NOT FAR FROM HOME. IT COULD HAVE STOPPED ON ME IN MIDDLE OF ROAD. I'VE NEVER GOT ANY RECALL NOTICES. I TOLD THE LADY AT EDWARDS CHEV. THE SAME THING. *TR

NHTSA ODI #10643072

119,958 miles · May 18, 2014

Engine And Engine CoolingFuel System, Gasoline

VEHICLE SHUT DOWN WHILE DRIVING ON I 84 ON ROUTE TO WORCESTER, MA. HAD TO COAST WITH NO POWER STEERING AND AVOID A TRUCK TO GET OVER TO THE SIDE. ENGINE STARTED AFTER FIVE MINUTES AND RAN FOR ANOTHER HR. LUCKILY THIS TIME, STOPPED FOR FUEL AND ENGINE WOULD NOT START AGAIN. HAD TO BE TO TO DEALER AND WAS ADVISED FUEL PUMP HAD FA…

Read full complaint

NHTSA ODI #10593027

20,000 miles · Jul 12, 2013

Engine And Engine CoolingVisibility

Read full complaint

I HAVE A 2011 CHEVROLET MALIBU AND HAD TO REPLACE THE HEATING CORE AND NOW THE HVAC SYSTEM IS LEAKING AND DAMAGED ALL THE CARPETS. I AM ALSO HEARING A THUMPING NOISE IN THE REAR OF THE CAR. I HAVE RECENTLY BROUGHT IT BACK TO THE DEALERSHIP AND I HAVE TO WAIT FOR MY CARPETS TO DRY AND WE HAVE BEEN HAVING RAIN SHOWERS FOR DAYS. THE ONLY WAY THE DEALER IS ABLE TO DRY THE CARPETS IS TO PLACE THEM OUTSIDE. I NOW HAVE TO PAY FOR A RENTAL BECAUSE MY BUMPER TO BUMPER WARRANTY IS EXPIRED. *TR

NHTSA ODI #10524585

35,000 miles · Jun 15, 2012

Engine And Engine Cooling

ENGINE SHUT OFF WHILE DRIVING ON HIGHWAY. *JB

NHTSA ODI #10461834

100 miles · Apr 9, 2012

Engine And Engine CoolingFuel System, GasolineVehicle Speed Control

Read full complaint

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

NHTSA ODI #10454540

6,800 miles · Mar 17, 2012

Electronic Stability Control (esc)Engine And Engine CoolingSteering

Read full complaint

THIS PROBLEM OCCURRED FIRST IN NOVEMBER 2011. THE ENGINE STOPPED, THERE WAS NO STEERING, SERVICE ESC,THE ENGINE LIGHT CAME ON. THE VEHICLE WAS RESTARTED BUT WOULD NOT MOVE WHEN PUT IN GEAR. TODAY IS THE SECOND TIME THIS SAME PROBLEM HAS OCCURRED. CHEVY SAID THE PROBLEM WAS REPAIRED IN NOVEMBER, BUT NOW IT'S BACK. THE MALIBU IS BACK AT CHEVY FOR THE SECOND TIME FOR THIS PROBLEM. WE EXPERIENCED ANOTHER INCIDENT 2 WEEKS AGO BUT AFTER STARTING THE CAR AGAIN THE PROBLEM WAS NOT THERE AND HAS NOT SURFACED UNTIL NOW. I CERTAINLY HOPE THIS PROBLEM IS RESOLVED THIS TIME FOR GOOD. I FEEL VERY UNCOMFORTABLE PULLING INTO TRAFFIC. *TR

NHTSA ODI #10452080

1,500 miles · Jul 19, 2011

Electrical SystemEngine And Engine Cooling

Read full complaint

I WAS DRIVING AND WHEN I WENT OVER A SMALL HILL THE CAR SEEMED TO LOSE POWER. THE SERVICE /ESC MESSAGE CAME ON. I WAS BARELY ABLE TO GET TO THE SIDE OF THE ROAD THE CAR WAS RUNNING BUT WOULD NOT MOVE AT ALL. IT HAD NO POWER WHATSOEVER. WHEN I CALLED ONSTAR THEY SAID TO SHUT IT OFF FOR A MINUTE AND TURN IT BACK ON TO SEE IF THE CODE WOULD CLEAR. IT DIDN'T SO I CALLED A TOW TRUCK TO TOW IT TO BANKS CHEVROLET (NH). AFTER SITTING IN THE CAR FOR ABOUT AN HOUR WITH THE ENGINE RUNNING (IT WAS FEBRUARY AND VERY COLD OUT) THE TOW OPERATOR ARRIVED. I SHUT THE CAR OFF FOR ABOUT 3 MINUTES, HE THEN STARTED IT AND LOW AND BEHOLD THE MESSAGE WAS GONE THE CAR HAD POWER AND HE PROCEEDED TO DRIVE IT ON THE TOW TRUCK. THE GARAGE HAD THE CAR FOR SEVERAL DAYS TRYING TO RECREATE THE PROBLEM. THEY COULD NOT. THEY SAID A SERVICE BULLETIN DID GO OUT ABOUT THIS PROBLEM. I WILL ADMIT IT DOES MAKE ME NERVOUS THE CAR WAS 1 MONTH IN MY POSSESSION WHEN THIS HAPPENED NOT EVEN 1500 MILES ON IT. I NOW HAVE 7500 MILES AND NO PROBLEMS SINCE THEN. IT COULD HAVE BEEN CATASTROPHIC IF I HAD BEEN MERGING ONTO THE HIGHWAY AND LOST POWER AT A HIGH SPEED-THANK-GOD THAT DIDN'T HAPPEN!!! BUT REALLY NO RESOLUTION THEY COULDN'T FIND OUT WHAT CAUSED IT THEY DID HOWEVER GIVE ME SOME SONG AND DANCE ABOUT THINGS LOOSENING UP FROM GOING OVER BUMPY ROADS. WELL I LIVE IN THE NORTHEAST SO THAT IS PRETTY UNAVOIDABLE. *KB

NHTSA ODI #10413498

19,800 miles · Jul 18, 2011

Electrical SystemEngine And Engine CoolingPower Train

I HAVE A 2011 MALIBU, I CHANGED MY TIRES OUT ON MY CAR AND TIRE PRESSURE LOW LIGHT CAME ON, THEN 3 DAYS LATER SERVICE ESC LIGHT CAME ON, AN I INSTANTLY FELT LIKE I WAS IN A WRONG GEAR, POWER AND SPEED REDUCED, THANKFULLY I WASN'T IN HEAVY TRAFFIC, I'M UNDER THE 5 YEAR WARRANTY CAN I GET SERVICE, AND IS IT DANGEROUS FOR ME TO DRI…

Read full complaint

NHTSA ODI #10413254

Official recalls

19V019000 · Air Bags:frontal:driver Side:inflator Module

Jan 16, 2019

General Motors LLC (GM) is recalling certain 2010-2011 Chevrolet Malibu vehicles. In the event of a crash necessitating deployment of the driver frontal air bag, the air bag inflator may explode due to being overpressurized.

Consequence & remedy

Consequence: If the inflator explodes, sharp metal fragments may strike the driver or other occupants resulting in serious injury or death.

Remedy: GM has notified owners, and dealers will replace the front driver air bag module, free of charge. The recall began February 25, 2019. Owners may contact GM customer service at 1-800-522-9559. GM's number for this recall is N182206630.

15V269000 · Seat Belts

May 8, 2015

General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.

Consequence & remedy

Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.

Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.

14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control

May 14, 2014

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence & remedy

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Additional source detail variants (5)

Electronic Stability Control (esc)