Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 213 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electronic Stability Control (esc). Review the 174 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

40 crash reports17 fire reports30 injury reports

Electrical System complaints

235 reports

Clear category filter

44,500 miles · Sep 9, 2020

Electrical System

GOT A 2011 CHEVY MALIBU FROM MY FATHER IN LAW. CAR ONLY HAS 44500 MILES ON IT. SO OF COURSE IT'S OUT OF WARRANTY. NOTICE THAT THE REAR DEFROSTER WAS NOT WORKING, SO DID SOME RESEARCH ONLINE AND FOUND MULTIPLE ACCOUNTS OF PEOPLE WITH SAME ISSUE WITH MELTED FUSES IN FUSE BOX IN TRUCK AND FUSE BOX MELTING ALSO. WHY IS CHEVY NOT TE…

Read full complaint

NHTSA ODI #11353990

151,000 miles · Sep 7, 2020

Electrical SystemElectronic Stability Control (esc)Exterior Lighting

Read full complaint

MY VEHICLE IS EXPERIENCING ALL SYMPTOMS RELATED TO NHTSA CAMPAIGN NUMBER: 14V252000 AND THERE IS NO ACTIVE RECALL FOR MY VIN. THAT PROBLEM HIS CAUSING HIGH VOLTAGE WHICH KEEPS CAUSING ELECTRICAL ISSUES LIKE BURNING CABLES TO THE HEADLIGHTS AND NOT GETTING POWER TO MULTIPLE INTERIOR EQUIPMENT SUCH AS THE IPC WHICH STOPS WORKING WHILE DRIVING AND I AM NO LONGER ABLE TO MY SPEED AND OTHER INFORMATION. I ALSO GET A ENGINE POWER REDUCED ERROR FROM A BAD CONNECTED FROM THE APP TO THE BCM, CODE P1238.

NHTSA ODI #11353572

Mileage unknown · Aug 29, 2020

Electrical System

LOW BEAM HEADLIGHT SOCKET MELTED ON BOTH SIDES NOT ALLOWING LOW BEAM LIGHTS TO WORK. HAD TO REWIRE A NEW WIRING HARNESS. I HAVE READ MULTIPLE ACCOUNTS ON LINE OF THE EXACT SAME THING HAPPENING. UNTIL I DIAGNOSED THE PROBLEM I HAVE HAD TO ONLY DRIVE DURING DAYLIGHT HOURS. RIDICULOUS!

NHTSA ODI #11351992

178,000 miles · Aug 17, 2020

Electrical SystemEngineUnknown Or Other

Read full complaint

MULTIPLE FRONT HEAD LIGHT REPLACEMENT IN SHORT PERIOD OF TIME WITHIN 3 TO 4 MONTHS REPLACED 3 TIMES. NOTICED WARPING OF FACEPLATE BY AUDIO EQUIPMENT SO HAD TO REPLACE THAT. THEN CAME BACK FROM VACATION AND DROVE MY CAR FOR ABOUT 20 MINUTES, PARKED I WENT INSIDE STORE AND MY DAUGHTER WAS IN THE CAR WHEN SHE SAID IT JUMPED AND THEN TURNED OFF. WHEN I TURNED IT ON IT SAID "ENGINE POWER REDUCED" "SERVICE TRACTION" "SERVICE ESC" I DROVE IT TO GET HOME. NEXT MORNING IT WAS FINE TO GET TO WORK SHORT DISTANCE, ON WAY HOME IN HOTTER TIME OF DAY (LIVE IN ARIZONA) IT DID IT AGAIN. ONLY 20 MILES AN HOUR MAXIUM AND GULPING GASOLINE. I WAS IN MY CAR WITH MY 13 YEAR OLD AND IT WAS DANGEROUS AS WE WERE DRIVING AND ALL OF A SUDDEN WE WERE REDUCED TO 20 MPH OR LESS AND WERE ALMOST REAR-ENDED VARIOUS TIMES, CAUGHT MID TRANSITION FROM YELLOW TO RED LIGHT WHILE MAKING LEFT TURN. VERY SCARY. MECHANIC DROVE IT AND SAID AFTER ONLY 10 TO 20 MINUTES OF DRIVING IT DID THE SAME THING. MECHANIC HE RAN TESTS AND FOUND RELAY FUSE BOX ISSUE. TRIED TO ORDER AND WAS TOLD IT WAS ON "NATIONAL BACK-ORDER" BECAUSE THIS WAS THE SAME PROBLEM MANY OF MY VEHICLE YEAR MAKE AND MODEL WERE EXPERIENCING. I HAD TO GET RENTAL FOR 20 DAYS WHICH COST IN EXCESS OF $500 AND WAIT FOR PART. PAY FOR PARTS $223 AND LABOR. THESE EXPENSES CAUSE INCREDIBLE FINANCIAL HARDSHIP AND STRESS. RECEPTS DID NOT GO THROUGH AND SCREEN SHOTS OF PANEL BECAUSE OF SIZE, PLEASE REACH OUT SO I CAN PROVIDE

NHTSA ODI #11349897

Mileage unknown · Aug 5, 2020

Electrical System

I'VE HAD THIS HAPPEN A FEW TIMES, WHEN I PARK MY CAR SHUT OFF ENGINE PULL KEYS OUT OPEN DOOR THE IGNITION KEY KEEPS RINGING LIKE I LEFT MY KEYS IN THE IGNITION BUT I DIDN'T. I GET OUT OF THE CAR AND CLOSE THE DOOR AND IT WILL STOP AFTER A WHILE.

NHTSA ODI #11343542

85,876 miles · Jul 31, 2020

Electrical SystemSeats

THE METAL ON SIDE OF SEAT BROKE CAUSING THE SEAT NOT TO BE ABLE TO ADJUST. ALSO, ELECTRICAL PROBLEMS LIGHTER HAD SHORTAGE AND SPEAKER SOUNDS INCREASE AND DECREASE WITH BEING ADJUSTED, AND THE LIGHT FOR THE TIRE PRESSURE REMAIN ON EVEN WHEN THE TIRES HAS SUFFICIENT AIR. I DIDN'T NOTICE AN EXACT TIME THE DEFECT HAPPEN. I JUST NOT…

Read full complaint

NHTSA ODI #11342520

65,000 miles · Jul 28, 2020

Electrical System

Read full complaint

THE ISSUE IS CONCERNING HEADLIGHTS ON THE CHEVY MALIBU. I HAVE HAD TO HAVE THE HEADLIGHTS REPLACED NUMEROUS TIMES ONLY TO HAVE THEM BURN OUT WITHIN DAYS/WEEKS. ACCORDING TO THE MECHANIC THE FAULT LIES WITH THE DESIGN. THE LIGHT GETS HOT ENOUGH TO BURN OUT THE HARNESS. THERE IS NOTHING THAT CAN BE DONE EXCEPT TO CONTINUE TO REPLACE THE BULB/HARNESS WHICH REQUIRES REMOVAL OF THE END FRONT BUMPER WHICH ONLY ADDS TO THE EXPENSE. THE INTERNET IS FULL OF COMPLAINTS OF THIS ISSUE. YOU NEVER KNOW WHEN THE LIGHT WILL GO OUT WHICH HAS CAUSED US TO BE PULLED OVER SEVERAL TIMES BY THE POLICE AND GIVEN WARNINGS.

NHTSA ODI #11341950

Mileage unknown · Jul 13, 2020

Electrical SystemElectronic Stability Control (esc)

MY HEADLIGHTS KEEP GOING OFF. I USE TO HIT THE FRONT AND IT TURNS ON BUT NOT ANYMORE. HAD IT FIXED 3 TIMES WITHIN A YEAR. NO AC DOESN'T TURN ON WHEN I START THE CAR AS WELL.

NHTSA ODI #11339030

137,000 miles · Jun 8, 2020

Electrical SystemEnginePower Train

Read full complaint

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE ESC, THE SERVICE TRACTION CONTROL, AND THE ENGINE REDUCED POWER WARNING LIGHTS ILLUMINATED. THE VEHICLE ALSO VIBRATED ABNORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED AN ELECTRICAL SHORT IN THE WIRING SYSTEM, AND REPLACED THREE DIFFERENT SENSORS. THE TECHNICIAN ALSO REPROGRAMMED THE ENGINE CONTROL UNIT. THE FAILURES RECURRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 137,000.

NHTSA ODI #11327797

91,500 miles · May 24, 2020

Electrical SystemElectronic Stability Control (esc)Unknown Or Other

Read full complaint

MY VEHICLE HAS APPROX. 91,500 MILES. UPON STARTING THE CAR RECENTLY, AN ERROR APPEARED SAYING "SERVICE TRACTION" AND "ENGINE POWER REDUCED." THE VEHICLE COULD NOT GO ABOVE 35 MPH AND THE TRACTION CONTROL SYSTEM WAS DISABLED. UPON INSPECTION BY THE DEALERSHIP, THEY DISCOVERED THE SUNROOF DRAIN TUBES HAD SHRUNK AND WATER HAD ACCUMULATED IN THE FLOORBOARD, EVENTUALLY LEADING TO CORROSION. I HAVE RESEARCHED THIS ISSUE AND FOUND SEVERAL OTHER DRIVERS REPORTING ISSUES WITH THE DRAIN TUBES BECOMING DISCONNECTED AND CAUSING LEAKS. I HAVE ALSO FOUND SEVERAL INSTANCES WHERE DRIVERS LOST ENGINE POWER ON THE HIGHWAY. IF THIS WERE TO HAPPEN, IT COULD EASILY CAUSE A CRASH. *TR

NHTSA ODI #11325751

Official recalls

19V019000 · Air Bags:frontal:driver Side:inflator Module

Jan 16, 2019

General Motors LLC (GM) is recalling certain 2010-2011 Chevrolet Malibu vehicles. In the event of a crash necessitating deployment of the driver frontal air bag, the air bag inflator may explode due to being overpressurized.

Consequence & remedy

Consequence: If the inflator explodes, sharp metal fragments may strike the driver or other occupants resulting in serious injury or death.

Remedy: GM has notified owners, and dealers will replace the front driver air bag module, free of charge. The recall began February 25, 2019. Owners may contact GM customer service at 1-800-522-9559. GM's number for this recall is N182206630.

15V269000 · Seat Belts

May 8, 2015

General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.

Consequence & remedy

Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.

Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.

14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control

May 14, 2014

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence & remedy

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Additional source detail variants (5)

Electronic Stability Control (esc)