NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
976 reportsMileage unknown · Mar 27, 2001
Power Train
CAR STILL MADE NOISE AFTER HUB/BEARINGS REPLACED. 2ND TIME HUB/BEARING REPLACED NOISE WAS LOUDER. GOT 2ND OPINION, WAS BACK PLATE RUBBING AGAINST ROTOR. DID I EVEN NEED MY HUB/BEARING REPLACED. 3/23/01 SAID I NEED ROTORS RESURFACED, 2ND OPINION - ROTORS FINE. CHEVY IS RIPPING ME OFF. CHARGED ME FOR NEW SERPENTINE BELT & NEVER RE…
Read full complaint
CAR STILL MADE NOISE AFTER HUB/BEARINGS REPLACED. 2ND TIME HUB/BEARING REPLACED NOISE WAS LOUDER. GOT 2ND OPINION, WAS BACK PLATE RUBBING AGAINST ROTOR. DID I EVEN NEED MY HUB/BEARING REPLACED. 3/23/01 SAID I NEED ROTORS RESURFACED, 2ND OPINION - ROTORS FINE. CHEVY IS RIPPING ME OFF. CHARGED ME FOR NEW SERPENTINE BELT & NEVER REPLACED IT. MOISTURE IN HEADLIGHTS.
NHTSA ODI #743136
Mileage unknown · Mar 26, 2001
Exterior Lighting
PASSENGER STOP LIGHT GOES OUT INTERMITTENTLY, CONSUMER BELIEVES IT TO BE STOP LAMP ASSEMBLY OVERHEATING. *AK
NHTSA ODI #884079
Mileage unknown · Mar 26, 2001
Suspension
CAR SOUNDED LIKE AN AIRPLANE PROPELLER AND SQUEALING AND SQUEAKING IN THE BACK END. *AK
NHTSA ODI #743075
Mileage unknown · Mar 26, 2001
Steering
I HAVE A ANTI-THEFT LOCK THAT CAME WITH THE VEHICLE,I HAVE BEEN STUCK SEVERAL TIMES DUE TO THE ANTI-THEFT GOING ON AND I CANNOT START THE CAR FOR ATLEAST 20 MIN. AT A TIME. I HAVE BEEN LATE FOR WORK AND APPOINTMENTS ALSO. I NEED TO KNOW SHOULD I TRY TO TAKE VEHICLE IN TO REMOVE ANTI-THEFT,IF POSSIBLE, IF I THE OWNER WITH THE KEY…
Read full complaint
I HAVE A ANTI-THEFT LOCK THAT CAME WITH THE VEHICLE,I HAVE BEEN STUCK SEVERAL TIMES DUE TO THE ANTI-THEFT GOING ON AND I CANNOT START THE CAR FOR ATLEAST 20 MIN. AT A TIME. I HAVE BEEN LATE FOR WORK AND APPOINTMENTS ALSO. I NEED TO KNOW SHOULD I TRY TO TAKE VEHICLE IN TO REMOVE ANTI-THEFT,IF POSSIBLE, IF I THE OWNER WITH THE KEY CANNOT START THE CAR I GUESS A THEFT WOULD HAVE A HARD TIME ALSO. SO IN ONE WAY I LIKE THE FEATURE. WOULD LIKE TO KNOW IF THIS IS A STANDARD FEATURE IN THESE VEHICLES? AND IF IT IS WORTH HAVING?*AK
NHTSA ODI #743047
Mileage unknown · Mar 20, 2001
Suspension
WHILE DRIVING CONSUMER HEARD GRINDING NOISE COMING FROM FRONT OF VEHICLE, DEALER FOUND WHEEL BEARINGS NEEDED TO BE REPLACED ON RIGHT FRONT. *AK
NHTSA ODI #883528
Mileage unknown · Mar 20, 2001
Service Brakes, Hydraulic
WHILE DRIVING ABS AND BRAKE LIGHT CAME ON, AND BRAKES GOT HARD. IT WAS HARD TO STOP AT 45 MPH. TOOK TO DEALER, AND THEY SAID ACID WAS DRIPPING ONTO BRAKE LINE AND IT CORRODED ANTI-LOCK VALVE. CONSUMER HAS REPLACED BRAKES AND DRUMS NUMERUS TIMES BEFORD FINDING PROBLEM WAS WITH THE DRIPPING OF ACID. *AK
NHTSA ODI #883494
Mileage unknown · Mar 19, 2001
Service Brakes, Hydraulic
RETURNED TO SELLING DEALER 06/13/2000, 18121 MILES FOR REPAIR OF BRAKE PULSATION, ESPECIALLY VIOLENT AT INTERSTATE SPEEDS. BRAKE ROTORS WERE RESURFACED AND PADS DEGLAZED AT MY EXPENSE. COMPLAINED TO SERVICE MANAGER ABOUT BEING CHARGED FOR REPAIR ON A CAR WITH 3/36 BUMPER TO BUMPER WARRANTY. WAS TOLD BRAKE WARRANTY WAS ONLY 12/…
Read full complaint
RETURNED TO SELLING DEALER 06/13/2000, 18121 MILES FOR REPAIR OF BRAKE PULSATION, ESPECIALLY VIOLENT AT INTERSTATE SPEEDS. BRAKE ROTORS WERE RESURFACED AND PADS DEGLAZED AT MY EXPENSE. COMPLAINED TO SERVICE MANAGER ABOUT BEING CHARGED FOR REPAIR ON A CAR WITH 3/36 BUMPER TO BUMPER WARRANTY. WAS TOLD BRAKE WARRANTY WAS ONLY 12/12000. CALLED CHEVROLET AND LODGED A COMPLAINT, FOLLOWED BY A LETTER ON 06/16/2000. CHEVROLET REP GAVE ME A COMPLAINT FILE #, C00624109. NOW AT 26000 MILES, BRAKE PULSATION HAS RETURNED. I HAVE NO REASON TO THINK THIS WILL NOT BE CONSTANTLY REOCURRING. AT HIGHWAY SPEED THIS IS A SAFETY PROBLEM. THE STEERING WHEEL WILL SHUDDER VIOLENTLY. I FEEL CONFIDENT THAT SOME REENGINEERING IS POSSIBLE AND SHOULD BE REQUIRED. *AK
NHTSA ODI #742670
Mileage unknown · Mar 17, 2001
Service Brakes, Hydraulic
THE BRAKE LINES COME OUT OF THE MASTER CYLINDER AND GO TO A HYDRALIC VALVE ON THE ANTILOCK BRAKE VALVE WHICH IS LOCATED UNDER THE BATTERY AND CORROSION HAS GOTTEN INTO AND ON THIS VALVE ASSEMBLY WHICH HAS CAUSED REAR BRAKE FAILURE THE VALVE IS LOCATED IN A VERY BAD PLACE TO CONTROL SUCH AN IMPORTANT PART OF THE OPERATIONS OF A V…
Read full complaint
THE BRAKE LINES COME OUT OF THE MASTER CYLINDER AND GO TO A HYDRALIC VALVE ON THE ANTILOCK BRAKE VALVE WHICH IS LOCATED UNDER THE BATTERY AND CORROSION HAS GOTTEN INTO AND ON THIS VALVE ASSEMBLY WHICH HAS CAUSED REAR BRAKE FAILURE THE VALVE IS LOCATED IN A VERY BAD PLACE TO CONTROL SUCH AN IMPORTANT PART OF THE OPERATIONS OF A VEHICLE. THIS PROBLEM NEEDS TO BE ADDRESSED AS SOON AS POSSIBLE BEFORE THERE IS FAILURES OF BRAKES ON THESE VEHICLES. WHEN THE ACID HAS BEEN THERE LONG ENOUGH IT WILL EAT AWAY AT THE BRAKE LINES COMPLETLY AND CAUSE MAJOR ACCIDENTS WHITH THE LOSS BEING MORE THAN MONEY OR PROPERTY.*AK
NHTSA ODI #742584
Mileage unknown · Mar 14, 2001
Engine And Engine CoolingEquipmentService Brakes, Hydraulic
MY MALIBU HAS HAD BOTH FRONT BRAKE SHOES REPLACED TWICE. THE ROTORS AND CALIPARS REPLACED THE ALTINATOR REPLACED. NOW THE COOLANT SYSTEM IS LEAKING ALL OVER THE ENGINE. THE PASSENGER WINDOW WILL NOT ROLL DOWN EVERYTIME. THE DASHBOARD IS LOOSE AND RATTLES. MY A/C LIGHT IN CAR CLICKS ON AND OFF. THE LEFT TAILIGHT BURNED OUT …
Read full complaint
MY MALIBU HAS HAD BOTH FRONT BRAKE SHOES REPLACED TWICE. THE ROTORS AND CALIPARS REPLACED THE ALTINATOR REPLACED. NOW THE COOLANT SYSTEM IS LEAKING ALL OVER THE ENGINE. THE PASSENGER WINDOW WILL NOT ROLL DOWN EVERYTIME. THE DASHBOARD IS LOOSE AND RATTLES. MY A/C LIGHT IN CAR CLICKS ON AND OFF. THE LEFT TAILIGHT BURNED OUT TWICE. THAT'S ALL THAT I CAN THINK OF RIGHT NOW.
NHTSA ODI #742460
Mileage unknown · Mar 14, 2001
Service Brakes, Hydraulic
WITH 58000 MILES, THE ROTORS HAVE BEEN REPLACED FOUR TIMES AND I'M NOW ON THE THIRD SET OF BRAKE PADS. BRAKE PEDAL TRAVELS ALMOST TO THE FLOOR, AND EVEN AT A STOP, WITH BRAND NEW PADS AND ROTORS, THE CAR STILL LURCHES FORWARD A BIT AS IF THE BRAKES CAN'T COMPLETELY STOP IT. CHEVROLET AGREED TO REPLACE THE ROTORS FOR 100000 MILES…
Read full complaint
WITH 58000 MILES, THE ROTORS HAVE BEEN REPLACED FOUR TIMES AND I'M NOW ON THE THIRD SET OF BRAKE PADS. BRAKE PEDAL TRAVELS ALMOST TO THE FLOOR, AND EVEN AT A STOP, WITH BRAND NEW PADS AND ROTORS, THE CAR STILL LURCHES FORWARD A BIT AS IF THE BRAKES CAN'T COMPLETELY STOP IT. CHEVROLET AGREED TO REPLACE THE ROTORS FOR 100000 MILES BECAUSE I FILED A FORMAL COMPLAINT, HOWEVER THIS TIME I TOOK IT TO AN INDEPENDENT GARAGE WHO PUT HEAVY DUTY ROTORS ON TO SEE IF THAT WILL HELP. EVEN THAT MECHANIC STATES THAT THE BRAKES DO NOT SEEM ADEQUATE FOR THE CAR.*AK
NHTSA ODI #742434
Official recalls
3Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
EA00010 · Stop Lamp Assembly Overheat
Opened Mar 27, 2000 · Closed Aug 9, 2001
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE99071 · Stop Lamp
Opened Nov 17, 1999 · Closed Mar 27, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
Illustration