NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
18 reportsClear category filterMileage unknown · Mar 7, 2004
Structure
I OWN A 1998 CHEVROLET MALIBU AND MY COMPLAINT IS THAT THE TRUNK DOES NOT STAY UP IN THE AIR ON WINDY DAYS OR SOMETIMES BY JUST PUTTING GROCERIES INTO THE TRUNK. I CAN NOT RECALL THE AMOUNT OF TIMES MYSELF OR ANOTHER PERSON HAS BEEN HIT ON THE HEAD WITH THE TRUNK LID. I FIND THIS TO BE VERY DANGEROUS AND THINK THE SOME SORT OF H…
Read full complaint
I OWN A 1998 CHEVROLET MALIBU AND MY COMPLAINT IS THAT THE TRUNK DOES NOT STAY UP IN THE AIR ON WINDY DAYS OR SOMETIMES BY JUST PUTTING GROCERIES INTO THE TRUNK. I CAN NOT RECALL THE AMOUNT OF TIMES MYSELF OR ANOTHER PERSON HAS BEEN HIT ON THE HEAD WITH THE TRUNK LID. I FIND THIS TO BE VERY DANGEROUS AND THINK THE SOME SORT OF HYDRAULICS (LIKE IN MOST HATCHBACKS) SHOULD BE INSTALLED. *JB
NHTSA ODI #10060644
88,000 miles · Jan 6, 2004
StructureInjury
TRUNK STRUTS WORE OUT, AND CAUSED THE TRUNK LID TO FALL ON THE CONSUMER. CONSUMERS SUSTAINED NECK/BACK OF THE HEAD INJURIES. DEALERSHIP WAS NOTIFIED , BUT WAS UNABLE TO RESOLVE THE PROBLEM. *AK *MR
NHTSA ODI #10053438
58,000 miles · Sep 22, 2003
Electrical SystemEngine And Engine CoolingEquipment
WHILE DRIVING, THE VEHICLE LOST ITS RACK AND PINION STEERING AND ALL POWER OF THE STEERING WHEEL. DEALER NOTIFIED. *AK THE POWER WINDOW CONTROL PANEL ON THE DRIVER SIDE ARM REST POPPED OUT, THE VEHICLE PULLED SEVERELY TO THE RIGHT (DEALER COULDN'T FIND THE PROBLEM). THE DEALER FINALLY REPLACED THE LOWER CONTROL ARMS, BRAKE…
Read full complaint
WHILE DRIVING, THE VEHICLE LOST ITS RACK AND PINION STEERING AND ALL POWER OF THE STEERING WHEEL. DEALER NOTIFIED. *AK THE POWER WINDOW CONTROL PANEL ON THE DRIVER SIDE ARM REST POPPED OUT, THE VEHICLE PULLED SEVERELY TO THE RIGHT (DEALER COULDN'T FIND THE PROBLEM). THE DEALER FINALLY REPLACED THE LOWER CONTROL ARMS, BRAKE ROTORS, 2 SETS OF TIRES/ALMOST COMPLETELY BALD AT THE TIME ONLY 13K MILES. THE RIMS HAD TO BE FORCED OFF, THE FRONT ROTORS HAD BECOME RUSTED AT 20K MILES, THE IGNITION WIRE HARNESS HAD COME APART, THE POWER STEERING HOSES HAD COME LOOSE, LOST FLUID AND POWER STEERING WHILE IN MOTION, THE TRUNK LEAKED, THE ABS LIGHT HAD COME ON TWICE A WEEK, THE FRONT END SQUEAKED AND RATTLED, THE ANTENNA WIRE WAS LOOSE, THE RIGHT HEAD LAMP HAD PERMANENT MOISTURE WITH NO CRACK, THE A/C WOULD SHUT ON/OFF INTERMITTENTLY, THE ALTERNATOR FAILED AT 60K MILES AND THE WANING LIGHT HAD COME ON FOR ONLY FIVE MINUTES, THE ENGINE LEAKED OIL, AND THE RIGHT WINDSHIELD WIPER PIVOT HOUSING HAD BROKEN. *SCC *JB
NHTSA ODI #10022685
Mileage unknown · Feb 21, 2002
Electrical SystemStructure
THEFT PREVENTION LIGHT COMES ON INTERMITTENTLY, UNABLE TO START VEHICLE AT THAT TIME. DEALER REPLACED PASSENGER'S LOCK SENSOR/CYLINDER, AND SWITCH TWICE. AT THIS TIME LIGHT COMES ON WHILE DRIVING. *AK DEALER HAS ALSO REPLACED THE PASSLOCK SYSTEM AND OXYGEN SENSOR. *JB
NHTSA ODI #8004336
Mileage unknown · Jun 14, 2001
Structure
FRONT TRANSMISSION MOUNT FAILED. *YH
NHTSA ODI #785024
Mileage unknown · May 25, 2001
Engine And Engine CoolingService Brakes, HydraulicStructure
A DESIGN FLAW IN THE BRAKING SYSTEM CAUSED THE BRAKE PADS AND ROTORS TO WEAR PREMATURELY, THE NEW DESIGN CREATES TOO MUCH HEAT FOR THE ROTORS TO DISSIPATE THEREFORE THE ROTORS WARP PREMATURELY, THIS DESIGN FLAW ALSO CAUSES VIBRATION WHEN BRAKING FROM HIGH SPEEDS. NLM
NHTSA ODI #561340
Mileage unknown · Apr 28, 2001
Electrical SystemEquipmentPower Train
AIR CONDITOIN PANEL HAS GONE OUT TWICE AND HAS BEEN REPLACED NOW IT IS GOING OUT A THIRD TIME. @ HAD REPLACE BRAKES TWICE IN ONE YEAR AND ALSO REPLACE THE ROTERS, REAR SUSPENSION MAKES A NOISE A CRAKING SOUNS LIKE THE SHOCKS ARE BAD. TRANSMISSION PROBLEMS ,CAR WILL NOT SHIFT OUT OR CHANGE GEAR. IT HAS BEEN PUT ON THE COMPUTER …
Read full complaint
AIR CONDITOIN PANEL HAS GONE OUT TWICE AND HAS BEEN REPLACED NOW IT IS GOING OUT A THIRD TIME. @ HAD REPLACE BRAKES TWICE IN ONE YEAR AND ALSO REPLACE THE ROTERS, REAR SUSPENSION MAKES A NOISE A CRAKING SOUNS LIKE THE SHOCKS ARE BAD. TRANSMISSION PROBLEMS ,CAR WILL NOT SHIFT OUT OR CHANGE GEAR. IT HAS BEEN PUT ON THE COMPUTER 2 TIMES AND NO CODE IS SHOWING UP IN THE TRANSMISSION. PLEASE HELP I HAVE HAD PROBLEMS WITH THIS CAR SINCE DAY ONE. AND I HAVE NO EXTENDED WARRENTY.*AK
NHTSA ODI #744692
Mileage unknown · Feb 22, 2001
Engine And Engine CoolingExterior LightingSeat Belts
SQUEAKING NOISE CAME FROM STEERING, DEALER REPLACED STEERING RACK ASSEMBLY AND POWER STEERING HOSES. RIGHT FRONT SHOULDER BELT WOULD NOT ADJUST UP OR DOWN, SEATBELT STOP BUTTON WAS MISSING, LEFT SIDE DRIVER'S SHOULDER BELT RETRACTS SLOWLY, RIGHT FRONT SHOULDER BELT RETRACTS SLOWLY AND JAMS AT TIMES. REAR BUMPER COVER AT LEFT S…
Read full complaint
SQUEAKING NOISE CAME FROM STEERING, DEALER REPLACED STEERING RACK ASSEMBLY AND POWER STEERING HOSES. RIGHT FRONT SHOULDER BELT WOULD NOT ADJUST UP OR DOWN, SEATBELT STOP BUTTON WAS MISSING, LEFT SIDE DRIVER'S SHOULDER BELT RETRACTS SLOWLY, RIGHT FRONT SHOULDER BELT RETRACTS SLOWLY AND JAMS AT TIMES. REAR BUMPER COVER AT LEFT SIDE AT TAIL LIGHT OPENING HAS POOR FIT. EXCESSIVE WIND NOISE AT THE LEFT FRONT DOOR GLASS OPENING WHILE TRAVELING HIGHWAY SPEEDS. STEERING SHIMMIES WHILE BRAKING, DEALER FOUND WARPED ROTORS. IDLE QUALITY IN GEAR AT STOP IS POOR, TRANSMISSION MOUNTS WERE WEAK, ENGINE RUNS ROUGH AT TIMES. FRONT HEAD LIGHT FOGGED UP, DELAER FOUND INSIDE LENS CRACKED. RATTLE NOISE HEARD UNDER VEHICLE WHILE TRAVELING ON ROUGH ROADS. *SLC
NHTSA ODI #881160
Mileage unknown · Aug 17, 2000
Electrical SystemEquipmentService Brakes, Hydraulic
WHILE APPLYING BRAKES, THE CAR PULSATES AND JUMPS WHEN COMING TO A STOP. THE CAR WAS TAKEN IN SEVERAL TIMES TO HAVE THE ROTARS TURNED, THEN LATER REPLACED, THEN REPLACED AGAIN WITH 99 MODEL ROTARS, THE BRAKES ARE STILL PULSATING TO CURRENT DATE. THE ALTERNATOR WENT OUT WHILE DRIVING, LOST ALL POWER TO BRAKES, ABS SYSTEM, AND A…
Read full complaint
WHILE APPLYING BRAKES, THE CAR PULSATES AND JUMPS WHEN COMING TO A STOP. THE CAR WAS TAKEN IN SEVERAL TIMES TO HAVE THE ROTARS TURNED, THEN LATER REPLACED, THEN REPLACED AGAIN WITH 99 MODEL ROTARS, THE BRAKES ARE STILL PULSATING TO CURRENT DATE. THE ALTERNATOR WENT OUT WHILE DRIVING, LOST ALL POWER TO BRAKES, ABS SYSTEM, AND AIR BAGS. THE ALTERNATOR WAS REPLACED. LATER HAD TO HAVE BATTERY REPLACED DUE TO ALTERNATOR KILLING IT. THE A/C LIGHT WOULD BLINK ON AND OFF, THE COMPRESSOR WOULD CUT ON AND OFF. HAD TO EVENTUALLY REPLACE THE PANEL ON THE INSIDE OF THE CAR AFTER HAVING A NEW COMPRESSOR PUT ON. THE A/C PANEL SEEMED TO HAVE DONE THE TRICK, THOUGH IS HAS SOME NEW PROBLEMS FROM THE BEGINNING. THE BUSHINGS SQUEAK AND SQWAUK WHILE DRIVING OVER BUMPS, THEY HAVE NOW STARTED IN THE REAR OF THE CAR.
NHTSA ODI #728313
Mileage unknown · Mar 15, 2000
Electrical SystemEngine And Engine CoolingSeat Belts
ENGINE IDLING ROUGHLY DUE TO FAULTY ENGINE MOUNT. NLM
NHTSA ODI #551405
Official recalls
3Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
EA00010 · Stop Lamp Assembly Overheat
Opened Mar 27, 2000 · Closed Aug 9, 2001
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE99071 · Stop Lamp
Opened Nov 17, 1999 · Closed Mar 27, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
Illustration