NHTSA owner reports · September 18, 2026 snapshot.
Wheels complaints
9 reportsClear category filter51,900 miles · Oct 18, 2007
Wheels
TL*THE CONTACT OWNS A 1998 CHEVROLET MALIBU. THE CONTACT STATED THAT THE SPARE WHEEL THAT CAME WITH THE VEHICLE DOES NOT FIT ONTO THE FRONT AXLE. HE NOTIFIED THE DEALER AND WAS INFORMED THAT THERE WERE NO RECALLS AND NO ASSISTANCE COULD BE PROVIDED. THE EXACT PURCHASE DATE WAS UNKNOWN; HOWEVER, THE YEAR WAS 1999. THE CURRENT…
Read full complaint
TL*THE CONTACT OWNS A 1998 CHEVROLET MALIBU. THE CONTACT STATED THAT THE SPARE WHEEL THAT CAME WITH THE VEHICLE DOES NOT FIT ONTO THE FRONT AXLE. HE NOTIFIED THE DEALER AND WAS INFORMED THAT THERE WERE NO RECALLS AND NO ASSISTANCE COULD BE PROVIDED. THE EXACT PURCHASE DATE WAS UNKNOWN; HOWEVER, THE YEAR WAS 1999. THE CURRENT MILEAGE WAS 52,000 AND FAILURE MILEAGE WAS 51,900. UPDATATTED 11/05/07. *JB
NHTSA ODI #10206239
65,000 miles · Jan 13, 2004
Wheels
ALUMINUM ALLOY TIRE RIMS: I OWN A 1998 CHEVROLET MALIBU, AND THE PROBLEM IS WITH THE RIMS. I AM ON MY THIRD PURCHASED REPLACEMENT RIM FOR THE VEHICLE. THE PROBLEM IS THAT WHEN THE TIRE GOES THROUGH A CHUCK OR POT HOLE IN THE ROAD THEY ARE CRACKING, CAUSING DEFLATION OF THE TIRE. I FEEL THAT THIS IS A PROBLEM SINCE THE DEALERSHI…
Read full complaint
ALUMINUM ALLOY TIRE RIMS: I OWN A 1998 CHEVROLET MALIBU, AND THE PROBLEM IS WITH THE RIMS. I AM ON MY THIRD PURCHASED REPLACEMENT RIM FOR THE VEHICLE. THE PROBLEM IS THAT WHEN THE TIRE GOES THROUGH A CHUCK OR POT HOLE IN THE ROAD THEY ARE CRACKING, CAUSING DEFLATION OF THE TIRE. I FEEL THAT THIS IS A PROBLEM SINCE THE DEALERSHIP WHERE I PURCHASED THE VEHICLE TELLS ME THAT THEY HAVE BEEN REPLACING ALOT OF THESE RIMS.
NHTSA ODI #10053014
58,000 miles · Sep 22, 2003
Electrical SystemEngine And Engine CoolingEquipment
WHILE DRIVING, THE VEHICLE LOST ITS RACK AND PINION STEERING AND ALL POWER OF THE STEERING WHEEL. DEALER NOTIFIED. *AK THE POWER WINDOW CONTROL PANEL ON THE DRIVER SIDE ARM REST POPPED OUT, THE VEHICLE PULLED SEVERELY TO THE RIGHT (DEALER COULDN'T FIND THE PROBLEM). THE DEALER FINALLY REPLACED THE LOWER CONTROL ARMS, BRAKE…
Read full complaint
WHILE DRIVING, THE VEHICLE LOST ITS RACK AND PINION STEERING AND ALL POWER OF THE STEERING WHEEL. DEALER NOTIFIED. *AK THE POWER WINDOW CONTROL PANEL ON THE DRIVER SIDE ARM REST POPPED OUT, THE VEHICLE PULLED SEVERELY TO THE RIGHT (DEALER COULDN'T FIND THE PROBLEM). THE DEALER FINALLY REPLACED THE LOWER CONTROL ARMS, BRAKE ROTORS, 2 SETS OF TIRES/ALMOST COMPLETELY BALD AT THE TIME ONLY 13K MILES. THE RIMS HAD TO BE FORCED OFF, THE FRONT ROTORS HAD BECOME RUSTED AT 20K MILES, THE IGNITION WIRE HARNESS HAD COME APART, THE POWER STEERING HOSES HAD COME LOOSE, LOST FLUID AND POWER STEERING WHILE IN MOTION, THE TRUNK LEAKED, THE ABS LIGHT HAD COME ON TWICE A WEEK, THE FRONT END SQUEAKED AND RATTLED, THE ANTENNA WIRE WAS LOOSE, THE RIGHT HEAD LAMP HAD PERMANENT MOISTURE WITH NO CRACK, THE A/C WOULD SHUT ON/OFF INTERMITTENTLY, THE ALTERNATOR FAILED AT 60K MILES AND THE WANING LIGHT HAD COME ON FOR ONLY FIVE MINUTES, THE ENGINE LEAKED OIL, AND THE RIGHT WINDSHIELD WIPER PIVOT HOUSING HAD BROKEN. *SCC *JB
NHTSA ODI #10022685
Mileage unknown · Apr 18, 2001
Wheels
FRONT WHEELS DEVELOPED GRINING NOISE. DEALER SAYS ITS WORN OUT HUBS AND BEARING ON BOTH SIDES AND CLAIMS ITS FROM POTHOLES. I DON'T HIT MANY POTHOLES. I MAKE A CONSCIENCE EFFORT TO AVOID POTHOLES. REPAIR IS COSTING ME $1000. I THINK I'M BEING TAKEN.*AK
NHTSA ODI #744241
Mileage unknown · Nov 8, 2000
Service Brakes, HydraulicVisibilityWheels
PREMATURE FAIL OF FRONT ROTORS DEALER WILL REPLACE ROTORS BUT WILL CHARGE FOR PADS AND ADDITIONAL LABOR. WHEEL CENTER COVERS PRESENT A CONDITION (ALL 4) THAT MAY CAUSE THEN TO COME OFF DUE TO FATIGUE OF SUPPORTING BRACKETS. REAR GLASS WEATHERSTRIPE SHRINK ABNORMALY CAUSING WATER TO ENTER INSIDE. *AK
NHTSA ODI #735994
Mileage unknown · Mar 17, 2000
Wheels
DUE TO A FLAT TIRE A TOW TRUCK HAD TO BE CALLED TO TRY TO GET THE WHEEL COVERS OFF. THE LUG NUTS CAN NOT BE LOOSENED WITHOUT FIRST GETTING THE WHEEL COVERS OFF. THE TOW TRUCK WAS UNSUCCESSFULL IN GETTING THE WHEEL COVERS OFF AND VEHICLE HAD TO BE BROUGHT TO THE DEALERSHIP TO GET THE WHEEL COVER AND TIRE OFF. THE SERVICE DEPAR…
Read full complaint
DUE TO A FLAT TIRE A TOW TRUCK HAD TO BE CALLED TO TRY TO GET THE WHEEL COVERS OFF. THE LUG NUTS CAN NOT BE LOOSENED WITHOUT FIRST GETTING THE WHEEL COVERS OFF. THE TOW TRUCK WAS UNSUCCESSFULL IN GETTING THE WHEEL COVERS OFF AND VEHICLE HAD TO BE BROUGHT TO THE DEALERSHIP TO GET THE WHEEL COVER AND TIRE OFF. THE SERVICE DEPARTMENT ADMITTED THAT THERE IS A DEFECT IN THE PLASTIC COMPONENTS OF THE WHEELCOVER THAT FASTEN TO THE LUG NUTS. IF THIS HAD HAPPENED ON THE HIGHWAY IT COULD HAVE RESULTED IN A VERY SERIOUS SITUATION. MYSELF, 3 MALE CO-WORKERS AND THE TOW TRUCK DRIVER COULD NOT GET THIS WHEEL COVER OFF TO CHANGE THE FLAT. SOMETHING NEEDS TO BE DONE TO RECTIFY THIS SITUATION. THE DEALER DID GIVE ME A NEW WHEEL COVER , BUT THAT DOESN'T SOLVE FUTURE PROBLEMS. *AK
NHTSA ODI #720256
Mileage unknown · Feb 16, 2000
Exterior LightingWheels
DUE TO THE DESIGN OF THE LUGS: NUTS,THE ONLY WAY TO REMOVE THE LUGS:NUTS IS BY BREAKING THEM OFF WITH A HAMMER CONSUMER CONTACTED DEALER. DEALER STATED NORMAL REMOVAL STANDARD. ALSO, CONSUMER WAS HAVING PROBLEMS WITH THE MOUNTED STOP LAMP ASSEMBLY WORKING INTERMITTENTLY, PE99071. PLEASE PROVIDE ANY FURTHER DETAILS. *AK
NHTSA ODI #857024
Mileage unknown · Mar 17, 1999
Wheels
TWO FRONT WHEEL HUBS MELTED OFF WHEEL, CAUSING THE HUBS TO FLY AWAY WHICH MAY CAUSE INJURIES. BUT BOLTS ARE STILL ON THE WHEEL. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #835917
Mileage unknown · Feb 1, 1999
Wheels
LEFT FRONT WHEEL RIM CRACKED RESULTING IN VERY SLOW AIR LEAK. YH
NHTSA ODI #609319
Official recalls
3Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
EA00010 · Stop Lamp Assembly Overheat
Opened Mar 27, 2000 · Closed Aug 9, 2001
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE99071 · Stop Lamp
Opened Nov 17, 1999 · Closed Mar 27, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
Illustration