IllustrationLEFT SIDE, REAR COIL SPRING BROKEN. ONE MONTH LATER, RIGHT FRONT COIL SPRING BREAKS CAUSING COIL SPRING TO RUB ON INSIDE OF TIRE RESULTING IN TIRE DAMAGE. *TR
1998 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 1998 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 223 of 976 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 347 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 144 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 130 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
34 crash reports5 fire reports18 injury reports
What owners actually said
976 reportsMY CAR IS A 1998 MALIBU LS. IT HAS 49,500 ORIGINAL MILES ON IT. IN 2006 I HAD PROBLEMS WITH THE TRANSMISSION, IT DIDN'T WANT TO SWITCH GEARS RIGHT AWAY. I TOOK IT TO OUR GM DEALER AS I HAD A WARRANTY. THEY PUT IT ON A COMPUTER, COULDN'T FIND ANYTHING, THEY STATED IT WAS DOING THE THINGS I SAID, BUT THOUGHT IT WAS JUST A GLICH …
Read full complaint
MY CAR IS A 1998 MALIBU LS. IT HAS 49,500 ORIGINAL MILES ON IT. IN 2006 I HAD PROBLEMS WITH THE TRANSMISSION, IT DIDN'T WANT TO SWITCH GEARS RIGHT AWAY. I TOOK IT TO OUR GM DEALER AS I HAD A WARRANTY. THEY PUT IT ON A COMPUTER, COULDN'T FIND ANYTHING, THEY STATED IT WAS DOING THE THINGS I SAID, BUT THOUGHT IT WAS JUST A GLICH AND WOULD GO AWAY. 5-17-07, SOMETHING FINALLY HAPPENED TO THE TRANSMISSION,THE CAR DIDN'T WANT TO GO ANYWHERE. I COASTED MY CAR TO THE GM DEALER AND TOLD THEM WHAT HAPPENED. THEY CALLED AND STATED THEY OPENED THE TRANSMISSION AND FOUND IT WAS A STUCK BODY VALVE. I TOLD THEM TO FIX IT AS IT WAS STILL UNDER WARRANTY. THEY ALREADY HAD THE TRANSMISSION OPENED UP, THEY CALLED ME BACK AND SAID THE WARRANTY COMPANY SAID MY WARRANTY HAD EXPIRED 1-14-07. CAN'T BE, I HAD TILL AUGUST. I CALLED THE WARRANTY COMPANY. I BOUGHT MY CAR 8-8-98, I PURCHASED THE EXTENDED WARRANTY (5 YEARS) I HAD TILL 8-8-93. IN JANUARY OF 93, I GOT CALLS FROM MVP (MOTOR VEHICLE PROTECTION CORP) TELLING ME THAT I SHOULD START THINKING ABOUT A NEW WARRANTY AS MINE WAS TO EXPIRE THAT YEAR. I TOLD THEM I WAS OKAY TILL AUGUST. A GAL NAMED ABBEY TOLD ME THAT I COULD SIGN UP FOR THE WARRANTY AND THEY WOULD NOTE MY ACCOUNT, PUT ON HOLD TILL AUGUST WHEN MY WARRANTY WITH GMAC RAN OUT. I NOW COULD MAKE PAYMENTS ON THE NEW WARRANTY, IT WOULD BE PAID FOR BY AUGUST. I AGREED. NOW THIS COMPANY IS DENYING ME COVERAGE FOR THE REPAIRS TO MY CAR. THEY STATE THE WARRANTY EXPIRED 4 YEARS FROM THE DAY I MADE MY FIRST PAYMENT TO THE WARRANTY COMPANY. THAT WAS NOT WHAT ABBEY TOLD ME. SHE SAID THAT IT WOULD NOT GO INTO EFFECT UNTIL MY GMAC WARRANTY WAS DONE. NOW I HAVE TO PAY $1,300 FOR AN REM VALVE THAT WENT BAD IN MY TRANSMISSION PLUS LABOR. I FEEL I HAVE BEEN TAKEN BY THE DEALERSHIP AND WARRANTY COMPANY AND NO ONE WILL HELP ME. I'VE TRIED TALKING TO THE DEALERSHIP THEY SAY THERE IS NOTHING THEY CAN DO, I HAVE TO PAY IT. THE WARRANTY COMPANY IS RUDE TO ME & I FEEL THIS IS FRAUD.
WHILE DRIVING DURING ICE STORMS IN JANUARY 2007 THE WINDSHIELD WIPERS QUIT WORKING DUE TO A BROKEN PIVOT HOUSING ON THE PASSENGER'S SIDE. THE SAME DEFECT WAS COVERED IN NHTSA RECALL CAMPAIGN 01V068000. HOWEVER, BECAUSE I LIVED OUTSIDE THE SALT BELT,CHEVROLET WILL NOT COVER THE REPAIR OF THIS MANUFACTURER'S DEFECT. I AM FEAR…
Read full complaint
WHILE DRIVING DURING ICE STORMS IN JANUARY 2007 THE WINDSHIELD WIPERS QUIT WORKING DUE TO A BROKEN PIVOT HOUSING ON THE PASSENGER'S SIDE. THE SAME DEFECT WAS COVERED IN NHTSA RECALL CAMPAIGN 01V068000. HOWEVER, BECAUSE I LIVED OUTSIDE THE SALT BELT,CHEVROLET WILL NOT COVER THE REPAIR OF THIS MANUFACTURER'S DEFECT. I AM FEARFUL, BUT FORCED TO, DRIVE IN RAIN STORMS WITHOUT WORKING WINDSHIELD WIPERS. THE MANUFACTURER HAS BEEN COMPLETELY ARROGANT ABOUT HELPING IN THIS SITUATION FOR THE LAST 5 MONTHS.*AK
TL*THE CONTACT OWNS A 1998 CHEVROLET MALIBU. THE CONTACT DROVE THE VEHICLE APPROXIMATELY 150 YARDS WHEN A POPPING NOISE WAS HEARD. WHILE DRIVING 10 MPH THE DRIVER'S SIDE OF THE VEHICLE COLLAPSED TO THE GROUND. THE CONTACT DISCOVERED THAT THE FRONT COIL SPRING FAILED AND CUT THE TIRE FROM THE WHEEL. THE VEHICLE WAS TOWED TO T…
Read full complaint
TL*THE CONTACT OWNS A 1998 CHEVROLET MALIBU. THE CONTACT DROVE THE VEHICLE APPROXIMATELY 150 YARDS WHEN A POPPING NOISE WAS HEARD. WHILE DRIVING 10 MPH THE DRIVER'S SIDE OF THE VEHICLE COLLAPSED TO THE GROUND. THE CONTACT DISCOVERED THAT THE FRONT COIL SPRING FAILED AND CUT THE TIRE FROM THE WHEEL. THE VEHICLE WAS TOWED TO THE DEALER, AND THE COIL SPRING WAS REPLACED. THE CONSUMER STATED THAT THE CAUSE OF FAILURE WAS DUE TO A BATCH OF COIL SPRINGS THAT WERE IMPROPERLY HEAT TREATED. THERE WAS A DEFECT INVESTIGATION FOR THIS FAILURE , PE 03031. THE CONTACT STILL POSSESSED THE FAILED COIL SPRING AND TIRE. THE CURRENT AND FAILURE MILEAGES WERE 98,000. *AK THE CONSUMER HAS PROVIDED PICTURES OF THE DEFECT. UPDATE 05/04/07*TR UPDATED 06/20/07. *JB
PASSENGER SIDE FRONT COIL SPRING BROKE, FOLLOWED BY DRIVER'S SIDE FRONT COIL SPRING. PASSENGER SIDE SPRING BEGAN RUBBING INTO TIRE, MELTED SIDE WALL OF TIRE. TIRE DESTROYED. REPLACED SPRINGS AND TIRE. *AK
MY CAR HAD TO HAVE THE THERMOSTAT, PLENINUM GASKET, INTAKE GASKET, EGR GASKET, VALVE COVER GASKETS REPLACED FOR THE SECOND TIME SINCE I HAVE HAD THIS CAR. I WAS TOLD THAT IT WAS BECAUSE OF THE DEX-COOL ANTIFREEZE THAT IS USED IN THESE CARS WARPS THE GASKETS AND SEALS. I AM VERY DISAPPOINTED THAT THIS HAS HAPPENED TO MY CAR. I DO…
Read full complaint
MY CAR HAD TO HAVE THE THERMOSTAT, PLENINUM GASKET, INTAKE GASKET, EGR GASKET, VALVE COVER GASKETS REPLACED FOR THE SECOND TIME SINCE I HAVE HAD THIS CAR. I WAS TOLD THAT IT WAS BECAUSE OF THE DEX-COOL ANTIFREEZE THAT IS USED IN THESE CARS WARPS THE GASKETS AND SEALS. I AM VERY DISAPPOINTED THAT THIS HAS HAPPENED TO MY CAR. I DO NOT HAVE THE MONEY TO BE REPLACING THESE GASKETS TWICE. I WOULD LIKE GM TO REIMBURSE ME SOME OF MY FINANCES THAT HAVE COST TO HAVE THIS PROBLEM FIXED FOR THE SECOND TIME. THIS TIME IT COST ME $222.00 FOR A RENTAL CAR AND $976.00 FOR REPAIRS. *JB
I BOUGHT MY 1998 CHEVY MALIBU WITH 51,133 MILES ON IT. IT STARTED TO LEAK ANTI FREEZE SHORTLY AFTER I BOUGHT THE CAR (73,753 MILES). IT ENDED UP BEING A REPLACEMENT OF THE CAMSHAFT SENSOR, REPLACE WATER PUMP, REPLACE RT.C.V SHAFT AND REPLACE SEAL SLEEVE. THE EGR GASKET WAS ALSO REPLACED. THE TOTAL COST OF THIS REPAIR WAS 874.5…
Read full complaint
I BOUGHT MY 1998 CHEVY MALIBU WITH 51,133 MILES ON IT. IT STARTED TO LEAK ANTI FREEZE SHORTLY AFTER I BOUGHT THE CAR (73,753 MILES). IT ENDED UP BEING A REPLACEMENT OF THE CAMSHAFT SENSOR, REPLACE WATER PUMP, REPLACE RT.C.V SHAFT AND REPLACE SEAL SLEEVE. THE EGR GASKET WAS ALSO REPLACED. THE TOTAL COST OF THIS REPAIR WAS 874.52 LABOR AND PARTS INCLUDED. *JB
THE FRONT TWO (2) METAL LATCHES THAT SECURE THE DRIVER'S SEAT TO THE SLIDING RAIL FAILED RESULTING IN THE SEAT ROTATING ON THE REAR LATCHES WITH THE DRIVER LAYING ON THEIR BACK PARTIALLY IN THE BACK SEAT. BOTH FRONT LATCHES FAILED WITH THE METAL CRACKED AND SHEARED. THE ENTIRE FRONT SEAT WILL HAVE TO BE REMOVED. *AKFORTUNATEL…
Read full complaint
THE FRONT TWO (2) METAL LATCHES THAT SECURE THE DRIVER'S SEAT TO THE SLIDING RAIL FAILED RESULTING IN THE SEAT ROTATING ON THE REAR LATCHES WITH THE DRIVER LAYING ON THEIR BACK PARTIALLY IN THE BACK SEAT. BOTH FRONT LATCHES FAILED WITH THE METAL CRACKED AND SHEARED. THE ENTIRE FRONT SEAT WILL HAVE TO BE REMOVED. *AKFORTUNATELY, THE VEHICLE WAS NOT INOPERATION AT THE TIME.
SERVERAL TIMES (5+) THE LEFT REAR TAIL LIGHT WOULD BURN OUT. I REPLACED THE BULB MYSELF AND NOTE THAT THE CONNECTION AND BULB HAD OVERHEATED. CURRENT, ON GOING PROBLEM IS THE DASH/INSTRUMENT CLUSTER LIGHTING. THE INSTRUMENT LIGHTS GO ON AND OFF, AS THEY FEEL LIKE IT. THE LIGHTS CURRENTLY ARE OUT. I CHECKED ALL FUSES AND BREAKE…
Read full complaint
SERVERAL TIMES (5+) THE LEFT REAR TAIL LIGHT WOULD BURN OUT. I REPLACED THE BULB MYSELF AND NOTE THAT THE CONNECTION AND BULB HAD OVERHEATED. CURRENT, ON GOING PROBLEM IS THE DASH/INSTRUMENT CLUSTER LIGHTING. THE INSTRUMENT LIGHTS GO ON AND OFF, AS THEY FEEL LIKE IT. THE LIGHTS CURRENTLY ARE OUT. I CHECKED ALL FUSES AND BREAKERS. ALL TESTED OKAY. I REALLY HATE THIS CAR AND NO MORE GM PRODUCTS FOR ME, EVER!
ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT CONTROLLER THE ANTI- THEFT SYSTEM DISABLED THE ENGINE WHILE THE VEHICLE WAS BEING TURNED STARTED. THIS ANTI-THEFT SYSTEM HAS PROHIBITED THE CAR FROM STARTING TWO DIFFERENT TIMES. HAD TO DISABLE THE ANTI-THEFT SYSTEM IN ORDER TO START CAR. DEALER COULD NOT FIX THIS PROBLEM. *NM
Official recalls
314V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
03V527000 · Steering:rack And Pinion
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
01V068000 · Visibility:windshield Wiper/washer:linkages
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
EA00010 · Stop Lamp Assembly Overheat
Opened Mar 27, 2000 · Closed Aug 9, 2001
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE99071 · Stop Lamp
Opened Nov 17, 1999 · Closed Mar 27, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available