IllustrationA DEFECTIVE WINDSHIELD WIPER WAS REPAIRED PRIOR TO RECALL C01014-S, THE CONSUMER IS NOW REQUESTING REIMBURSEMENT FROM THE MANUFACTURER FOR THE COST OF REPAIRING THE WINDSHIELD WIPER, CONSUMER WAS DENIED REIMBURSEMENT BECAUSE SHE COULD NOT PROVIDE THE ORIGINAL REPAIR BILL.*YH *JB
1998 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 1998 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 223 of 976 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 347 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 144 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 130 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
34 crash reports5 fire reports18 injury reports
Visibility complaints
63 reportsI FILED A COMPLAINT WITH NHTSA AND GM CASE # C04015874 IN APRIL 01. GM TOLD ME TO SEND IN COPIES OF MY SALES CONTRACT AND OTHER PURCHASE INFO TO PROVE I PURCHASED IT IN NY I DID THAT IMMEDIATELY. THEY ALSO TOLD ME TO TAKE THE CAR TO A DEALER AND HAVE IT INSPECTED AND GIVE THEM THE BROKEN PIVOT PART. I THEN WAS TOLD AT THE END O…
Read full complaint
I FILED A COMPLAINT WITH NHTSA AND GM CASE # C04015874 IN APRIL 01. GM TOLD ME TO SEND IN COPIES OF MY SALES CONTRACT AND OTHER PURCHASE INFO TO PROVE I PURCHASED IT IN NY I DID THAT IMMEDIATELY. THEY ALSO TOLD ME TO TAKE THE CAR TO A DEALER AND HAVE IT INSPECTED AND GIVE THEM THE BROKEN PIVOT PART. I THEN WAS TOLD AT THE END OF THE YEAR AFTER ALL THIS MISINFORMATION GIVEN TO ME THAT THEY WEREN'T GOING TO REINBURSE ME FOR THE PART I HAD TO BUY TO REPAIR THE CAR. THE RECALL SAID THE SNOW FALL CAUSES THE PART TO BREAK AND THAT'S WHAT HAPPENED-BUT THEY WON'T HONOR IT. CAN YOU DO SOMETHING FOR ME, THE PART COST $100. DOLLARS.*AK
PRIOR TO RECALL 01V068, THE PASSENGER SIDE WIPER PIVOT HOUSING CRACKED AND THE WIPERS FAILED TO OPERATE, VEHICLE WAS TAKEN IN FOR REPAIR AND CONSUMER WAS INFORMED THAT THE PART WAS ON BACK ORDER, CONSUMER THEN RECEIVED THE RECALL NOTIFICATION REQUEST AND THEN REQUESTED A REFUND SINCE HE HAD ALREADY EXPERIENCED THE PROBLEM, HOW…
Read full complaint
PRIOR TO RECALL 01V068, THE PASSENGER SIDE WIPER PIVOT HOUSING CRACKED AND THE WIPERS FAILED TO OPERATE, VEHICLE WAS TAKEN IN FOR REPAIR AND CONSUMER WAS INFORMED THAT THE PART WAS ON BACK ORDER, CONSUMER THEN RECEIVED THE RECALL NOTIFICATION REQUEST AND THEN REQUESTED A REFUND SINCE HE HAD ALREADY EXPERIENCED THE PROBLEM, HOWEVER WHEN HE RECEIVED THE REFUND CHECK IT WAS ONLY FOR $64.00 NOT EVEN HALF THE AMOUNT THAT HE PAID.*YD
PIVOT HOUSING BROKE, CAUSING DAMAGE TO WINSHIELD WIPER TRANSMISSION. BOTH PARTS WERE REPLACED AT CUSTOMER EXPENSE.*AK
WINDSHIELD WIPERS ARE NOT CLEARING THE WINDOW. BLADES ARE NOT TOUCHING THE WINDOW PROPERLY. CONSUMER HAS BEEN TO DEALER, AND HAD WINDSHIELD WIPERS REPLACED 3 TIMES. BUT, PROBLEM IS STILL PRESENT. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
THE DEALER WON'T PAY FOR THE PARTS BECAUSE MY VIN# DON'T COME UP. THE CAR WAS PURCHASED AND IS REGISTERED IN NEW YORK ONE OF THE SNOW BELT STATES AFFECTED. ORIGINALLY, THE CAR WAS SOLD AND DELIVERED IN FLORIDA, AND THAT'S WHY MY VIN# ISN'T COMING UP. SOMEONE HAS TO TELL THEM THIS CAR WAS BOUGHT IN NY AND ISN'T BEING USED IN FLO…
Read full complaint
THE DEALER WON'T PAY FOR THE PARTS BECAUSE MY VIN# DON'T COME UP. THE CAR WAS PURCHASED AND IS REGISTERED IN NEW YORK ONE OF THE SNOW BELT STATES AFFECTED. ORIGINALLY, THE CAR WAS SOLD AND DELIVERED IN FLORIDA, AND THAT'S WHY MY VIN# ISN'T COMING UP. SOMEONE HAS TO TELL THEM THIS CAR WAS BOUGHT IN NY AND ISN'T BEING USED IN FLORIDA. MY WIFE ALMOST LOST CONTROL WHILE DRIVING BECAUSE THE DEFECTIVE PARTS BROKE WHILE THE WET SNOW CAME DOWN.I'VE JUST FOUND OUT THAT A PERSON AT MY INSURANCE CO, JUST GOT THERE RECALL AND THEIRS DIDN'T BREAK YET, WHILE MINE DID. PLEASE HELP. SINCERELY, [XXX]. *AK PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
PIVOT DRIVE ASSEMBLY SEIZED CAUSING THE WIPERS/ TRANSMISSION TO FAIL BUT THE DEALER STATED IT WAS NOT COVERED UNDER NHTSA CAMPAIGN ID NUMBER: 01V068000. *AK
CONSUMER STATES PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING IS FRACTURED AT THE BASE, RESULTING IN OPERATIVE WINDSHIELD WIPERS ON BOTH SIDES OF VEHICLE. *JB
FUSES FOR THE WINDSHIELD WIPERS CONTINUED TO BLOW. THEN, PASSENGER'S SIDE WINDSHIELD WIPER CRACKED AND BROKE, WHICH NECESSITED THE REPLACEMENT OF WIPER TRANSMISSION ASSEMBLY. CONSUMER WAS INFORMED THAT THIS VEHICLE WAS NOT INCLUDED IN NHTSA RECALL 01V068000 DUE TO VIN. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMEN…
Read full complaint
FUSES FOR THE WINDSHIELD WIPERS CONTINUED TO BLOW. THEN, PASSENGER'S SIDE WINDSHIELD WIPER CRACKED AND BROKE, WHICH NECESSITED THE REPLACEMENT OF WIPER TRANSMISSION ASSEMBLY. CONSUMER WAS INFORMED THAT THIS VEHICLE WAS NOT INCLUDED IN NHTSA RECALL 01V068000 DUE TO VIN. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS. *AK
I'M WAITING FOR PAPERS TO BE SENT TO ME FOR THIS COMPLAINT. WINDSHIELD WIPERS BROKE FROM THE SNOW, AND MY WIFE HAD TO SLAM ON THE BRAKES WHILE PULLING OVER CAUSE SHE COULDN'T SEE.*AK
Official recalls
314V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
03V527000 · Steering:rack And Pinion
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
01V068000 · Visibility:windshield Wiper/washer:linkages
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
EA00010 · Stop Lamp Assembly Overheat
Opened Mar 27, 2000 · Closed Aug 9, 2001
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE99071 · Stop Lamp
Opened Nov 17, 1999 · Closed Mar 27, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available