NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
108 reportsClear category filter58,000 miles · Oct 8, 2003
Electrical SystemEngine And Engine CoolingPower Train
WATER IS LEAKING INTO ENGINE FROM THE HEAD GASKET. WATER PUMP STARTED SEEPING AFTER HEAD GASKET WAS REPLACED. THE FRONT BRAKES WAS REPLACED SEVERAL TIMES WITH FINALLY THE ONES MENTIONED ON THE BULLETIN. FIRST THE LEFT SIDE WHEEL BEARING/ SPEED SENSOR ASSEMBLY CHANGED THEN A COUPLE OF THOUSAND OF MILES LATER THE RIGHT SIDE. AIR…
Read full complaint
WATER IS LEAKING INTO ENGINE FROM THE HEAD GASKET. WATER PUMP STARTED SEEPING AFTER HEAD GASKET WAS REPLACED. THE FRONT BRAKES WAS REPLACED SEVERAL TIMES WITH FINALLY THE ONES MENTIONED ON THE BULLETIN. FIRST THE LEFT SIDE WHEEL BEARING/ SPEED SENSOR ASSEMBLY CHANGED THEN A COUPLE OF THOUSAND OF MILES LATER THE RIGHT SIDE. AIR CONDITION WAS GOING ON AND OFF INTERMITTENTLY. *LA
NHTSA ODI #10041485
Mileage unknown · Jul 28, 2003
Suspension
CONSUMER STATES THAT WHILE DRIVING THE VEHICLE AND NO WARNING THE FRONT SUSPENSION COLLAPSED. DEALER NOTIFIED.*AK
NHTSA ODI #10030211
Mileage unknown · Jun 12, 2003
Suspension
WHILE STANDING OUTSIDE OF VEHICLE AND WITHOUT ANY INDICATION VCOIL SPRING BROKE. DEALER HAS BEEN CONTACTED. *AK
NHTSA ODI #10022919
61,000 miles · Jun 4, 2003
Electrical SystemService Brakes, HydraulicSuspension
DEFECTS IN 1998 CHEVROLET MALIBU. I HAVE SPENT OVER $1000 TRYING TO REPAIR THE ABS SYSTEM (INCLUDING REPLACING THE WIRING HARNESS FOR WHAT GM CALL AN "UPDATED WIRING HARNESS," REPLACING LEFT AND RIGHT WHEEL BARONS, AND REPLACING THE ABS RELAY). THE BRAKES CONSISTENTLY HAVE TROUBLE AND PULSE WHEN TRYING TO STOP THE VEHICLE. I AM …
Read full complaint
DEFECTS IN 1998 CHEVROLET MALIBU. I HAVE SPENT OVER $1000 TRYING TO REPAIR THE ABS SYSTEM (INCLUDING REPLACING THE WIRING HARNESS FOR WHAT GM CALL AN "UPDATED WIRING HARNESS," REPLACING LEFT AND RIGHT WHEEL BARONS, AND REPLACING THE ABS RELAY). THE BRAKES CONSISTENTLY HAVE TROUBLE AND PULSE WHEN TRYING TO STOP THE VEHICLE. I AM ALSO EXPERIENCING CONSIDERABLE TROUBLE WITH THE COMPUTER SYSTEM IN THE CAR. THE ANTI THEFT LIGHT AND AIR BAG LIGHTS COME ON AND STAY ON, CREATING CODES IN THE COMPUTER, WITH NO VISIBLE REASONS FOR THE CODES. THE GAS PEDAL HAS ALSO BEEN REPAIRED TWICE AS IT HAS A TENDENCY TO STICK. THE LEFT REAR STRUT MOUNTS HAVE ALSO BROKEN AND HAVE HAD TO BE REPAIRED (QUITE COSTLY). I AM BECOMING INCREASINGLY CONCERNED FOR SAFETY WHILE DRIVING THIS CAR. *NLM
NHTSA ODI #10021020
Mileage unknown · Apr 25, 2003
Engine And Engine CoolingPower TrainSuspension
THE VEHICLE VIBRATED ALL THE TIME. THE VEHICLE WAS TAKEN TO A MECHANIC WHO REPAIRED THE MOTOR MOUNTS AND THE TRANSMISSION MOUNTS. THE WHEEL BEARINGS NEEDED TO BE REPLACED, BUT THE PARTS WERE ON BACK ORDER. *JB
NHTSA ODI #10017570
Mileage unknown · Mar 23, 2003
Service Brakes, HydraulicSuspension
BRAKE PADS, ROTORS, AND CALIPERS CONTINUALLY FAILED ON CHEVROLET MALIBU. THIS HAS BEEN GOING ON SINCE CAR WAS NEW. PADS, ROTORS, CALIPERS, AND BALL JOINTS HAVE ALL BEEN REPLACED - PADS AND ROTORS AS OFTEN AS EVERY 6000 TO 12000 MILES. DEALERS AND INDEPENDENTS HAVE WORKED ON IT WITH THE SAME RESULT: MORE FAILURES. THERE ARE …
Read full complaint
BRAKE PADS, ROTORS, AND CALIPERS CONTINUALLY FAILED ON CHEVROLET MALIBU. THIS HAS BEEN GOING ON SINCE CAR WAS NEW. PADS, ROTORS, CALIPERS, AND BALL JOINTS HAVE ALL BEEN REPLACED - PADS AND ROTORS AS OFTEN AS EVERY 6000 TO 12000 MILES. DEALERS AND INDEPENDENTS HAVE WORKED ON IT WITH THE SAME RESULT: MORE FAILURES. THERE ARE HUNDREDS OF COMPLAINTS ABOUT THESE PROBLEMS FOR MALIBU'S JUST FROM THIS YEAR'S MODEL AND MANY MORE FOR OTHER YEARS. NHTSA HAS NEVER INVESTIGATED EVEN THOUGH BRAKE FAILURE WOULD SEEM TO BE SIGNIFICANT. MY TAX MONEY IS NOT WORKING HARD ENOUGH. *JB
NHTSA ODI #10010900
50,000 miles · Feb 13, 2003
Suspension
I HAVE A 1998 CHEVY MALIBU WITH 60,000 MILES. THE PROBLEM STARTED AT ABOUT 50,000 MILES. BOTH FRONT LOWER CONTROL ARMS STARTED TO RATTLE OVER CRACKS AND BUMPS AROUND JULY 2001. IT HAS STEADILY BECOME WORSE AND IS TO THE POINT I CAN HEAR A LOUD CLUNK EVEN OVER EXPANSION JOINTS OR WHEN IT SHIFTS GEARS DURING ACCELERATION. I HAVE H…
Read full complaint
I HAVE A 1998 CHEVY MALIBU WITH 60,000 MILES. THE PROBLEM STARTED AT ABOUT 50,000 MILES. BOTH FRONT LOWER CONTROL ARMS STARTED TO RATTLE OVER CRACKS AND BUMPS AROUND JULY 2001. IT HAS STEADILY BECOME WORSE AND IS TO THE POINT I CAN HEAR A LOUD CLUNK EVEN OVER EXPANSION JOINTS OR WHEN IT SHIFTS GEARS DURING ACCELERATION. I HAVE HEARD FROM SEVERAL OTHER OWNERS WHO HAVE EXPERIENCED THE SAME PROBLEM, SOME WITH FEWER MILES. IN ALL CASES CHEVROLET REFUSES TO TAKE ANY RESPONSIBILITY AND SAYS WE HAVE TO REPLACE WITH NEWLY DESIGNED CONTROL ARMS AT OUR OWN COST. I AM GOING TO REPLACE THEM FOR FEAR THAT THE BOLTS ARE GOING TO BREAK FROM THE EXCESSIVE MOVEMENT ALLOWED BY THE INFERIOR BUSHINGS USED IN THE ORIGINAL PART, BUT I THINK GM'S DECISION TO NOT RECALL THIS OBVIOUS SAFETY HAZARD SHOULD BE QUESTIONED. THEY HAVE ADMITTED THERE WAS A DESIGN FLAW BY PRODUCING A REDISIGNED PART, WHY SHOULD THEY NOT RECALL IT?
NHTSA ODI #10005788
2,241 miles · Jan 24, 2003
Engine And Engine CoolingFuel System, OtherSuspension
THE CONSUMER HAS EXPERIENCED THE FOLLOWING: THE FRONT END SUSPENSION ARM NEEDS CHANGING, RACK PINION ASSEMBLY IS LEAKING OIL AND INTERNAL NOISES, THE PUMP CAP HAS BEEN CHANGED TWICE (THE PRESSURE OIL RETURNS TO THE CAP), AND THE REAR CRANKSHAFT SEAL IS LEAKING. SCC
NHTSA ODI #10003715
2,241 miles · Jan 14, 2003
Engine And Engine CoolingSteeringSuspension
THE VEHICLE HAS EXPERIENCED THE FOLLOWING PROBLEM: THE FRONT END/LOWER SUSPENSION ARMS NEED CHANGING, THE RACK AND PINION ASSEMBLY IS LEAKING CONSTANTLY AND HAS BEEN CHANGED TWICE, AND THE REAR CRANKSHAFT SEAL IS LEAKING OIL. *SCC *NLM
NHTSA ODI #10002109
Mileage unknown · Aug 12, 2002
Suspension
RIGHT FRONT COIL SPRINT BROKE. A BROKEN END GOUGED THE INSIDE SIDEWALL OF THE TIRE, MAKING A POTENTIALLY DANGEROUS SITUATION.*AK
NHTSA ODI #765550
Official recalls
3Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
EA00010 · Stop Lamp Assembly Overheat
Opened Mar 27, 2000 · Closed Aug 9, 2001
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE99071 · Stop Lamp
Opened Nov 17, 1999 · Closed Mar 27, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
Illustration