Illustration1998 CHEVY MALIBU: FAULTY INTAKE MANIFOLD GASKET RESULTING IN COOLANT LEAK, GASKET HAS BEEN REPLACED TWICE WITHIN 100,000 MILES (MAY BE RELATED TO MANDATED USAGE OF DEXCOOL ANTIFREEZE IN VEHICLE PER MANUFACTURER). *NM
1998 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 1998 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 223 of 976 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 347 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 144 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 130 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
34 crash reports5 fire reports18 injury reports
Engine And Engine Cooling complaints
144 reportsTHE OIL LIGHT CAME ON ONE MINUTE THE NEXT MINUTE THE CAR CUT OFF. I HAD THE CAR TOWED TO CURTIS CHEVROLET IN WASHINGTON, DC AND WAS TOLD THAT THE ENGINE SEIZED DUE TO THE OIL REGULATOR AND FILTER EXPLODED. THE CAR HAS ONLY 57500 ORIGINAL MILES, SERVICED MAINLY BY CURTIS CHEVROLET...OIL RECENTLY CHANGED BY CURTIS YET I WAS TOLD…
Read full complaint
THE OIL LIGHT CAME ON ONE MINUTE THE NEXT MINUTE THE CAR CUT OFF. I HAD THE CAR TOWED TO CURTIS CHEVROLET IN WASHINGTON, DC AND WAS TOLD THAT THE ENGINE SEIZED DUE TO THE OIL REGULATOR AND FILTER EXPLODED. THE CAR HAS ONLY 57500 ORIGINAL MILES, SERVICED MAINLY BY CURTIS CHEVROLET...OIL RECENTLY CHANGED BY CURTIS YET I WAS TOLD THAT TO REPLACE THE ENGINE WOULD BE $6,000. THE CAR IS CURRENTLY CONSIDERED TOTALED. *JB
1. I CHECKED THE COOLANT LEVEL IN THE RESERVOIR AND NOTICED COOLANT WAS NEEDED. I PUT WATER INTO THE RESERVOIR (CAR WAS ON) AND EVERYTHING SEEMED TO BE FINE. I DROVE THE CAR ABOUT 10 MILES. I STOPPED TO PUT GAS IN AND NOTICED WATER/COOLANT COMING FROM UNDER THE CAR. I REPLACED THE WATER AND DROVE TO A MECHANIC. THE MECHANIC…
Read full complaint
1. I CHECKED THE COOLANT LEVEL IN THE RESERVOIR AND NOTICED COOLANT WAS NEEDED. I PUT WATER INTO THE RESERVOIR (CAR WAS ON) AND EVERYTHING SEEMED TO BE FINE. I DROVE THE CAR ABOUT 10 MILES. I STOPPED TO PUT GAS IN AND NOTICED WATER/COOLANT COMING FROM UNDER THE CAR. I REPLACED THE WATER AND DROVE TO A MECHANIC. THE MECHANIC TOLD ME THAT MY INTAKE GASKET NEEDED TO BE REPLACED; HE SHOWED ME THE LEAKAGE COMING FROM THE SIDE OF THE ENGINE. HE ALSO STATED, THIS IS A COMMON PROBLEM WITH THIS TYPE OF CAR. SIMILAR COMMENTS HAD BEEN MADE TO ME IN THE PAST IN REGARDS TO THE INTAKE GASKET; MECHANICS, AUTO PART SALES MEN AND THE DEALER WHERE I GET MY CAR SERVICED HAD ALL BEEN CONCERNED IN THE PAST FOR THIS AREA OF MY CAR, BUT UNTIL NOW EVERYTHING HAD BEEN FINE; 2. FAILURE OF THE INTAKE GASKET PREVENTED THE ENGINE COOLANT FROM MAINTAINING THE PROPER COOLANT LEVEL, THE CONSEQUENCE WAS THAT I NEEDED TO TAKE TIME OUT OF MY DAY TO INQUIRE ABOUT THIS MATTER AND SEEK ADVICE IN PREVENTING FURTHER DAMAGE; 3. I HAVE AN APPOINTMENT TO FIX THE PROBLEM ON TUESDAY (9/6/05). I WILL NOT HAVE MY CAR FOR A FULL DAY DUE TO THIS PROBLEM AND THE ESTIMATE TO FIX THE CAR WAS 550.00 TO 600.00 DOLLARS. *JB
I PURCHASED MY 1998 MALIBU, IT'S HAD NOTHING BUT PROBLEMS. SINCE I BOUGHT THIS CAR IN NOVEMBER OF 2001 WITH IN LESS THAN A WEEK OF PURCHASING I HAD TO TAKE THE CAR BACK TO DEALER AND HAVE THEM FIX A PROBLEM BECAUSE CHECK ENGINE LIGHT WAS ON, I AM UNSURE OF THE EXACT PROBLEM BUT I DO KNOW THE CAR DID NOT PASS EMISSIONS AND IF I H…
Read full complaint
I PURCHASED MY 1998 MALIBU, IT'S HAD NOTHING BUT PROBLEMS. SINCE I BOUGHT THIS CAR IN NOVEMBER OF 2001 WITH IN LESS THAN A WEEK OF PURCHASING I HAD TO TAKE THE CAR BACK TO DEALER AND HAVE THEM FIX A PROBLEM BECAUSE CHECK ENGINE LIGHT WAS ON, I AM UNSURE OF THE EXACT PROBLEM BUT I DO KNOW THE CAR DID NOT PASS EMISSIONS AND IF I HAD TO PAY FOR IT, IT WOULD HAVE COST ME OVER 500 DOLLARS, I HAVE REPLACED MY FRONT BRAKES ON 3 OCCASIONS, I HAVE FIXED THE LEAKING TRANSMISSION 2X, I HAVE REPLACED THE TAIL LIGHT BULBS ABOUT 4X, I REPLACED THE ALTERNATOR AND THE LINING IS COMING OFF THE TRUNK. THESE ARE ALL PROBLEMS I HAD IN LESS THEN 2 YEARS OF OWNING THE VEHICLE. SINCE MARCH 2004 I HAVE BEEN UNABLE TO DRIVE MY VEHICLE. I HAVE REPLACED THE FUEL PUMP, WATER PUMP, 2 OF THE INJECTORS AND THERE HAVE BEEN OTHER SMALL REPAIRS HERE AND THERE. EVERY TIME I FIX SOMETHING WITHIN LESS THEN A WEEK OF DRIVING IT THERE IS SOMETHING ELSE WRONG I AM UNABLE TO REPAIR IT UNTIL I CAN SAVE ENOUGH MONEY TO PUT MORE INTO IT. I AM CURRENTLY REPLACING THE INJECTORS WHICH I HAVE ALREADY PAID 600 DOLLARS AND HAVE 4 MORE TO GO. I AM WORRIED THAT AFTER I PUT THIS MONEY INTO IT I WILL STILL HAVE MORE PROBLEMS, I HAVE BEEN TOLD THAT THERE IS SOME ELECTRICAL PROBLEM IN THE DASH BUT THEY ARE UNSURE EXACTLY WHAT IT IS BECAUSE THE CAR WILL NOT RUN LONG ENOUGH TO FIGURE OUT. NOBODY CAN TELL ME EVERYTHING THAT IS WRONG WITH BECAUSE I NEED TO FIX ONE PROBLEM BEFORE THEY CAN BE SURE OF THE NEXT. THIS CAR WAS THE WORST PURCHASE I HAVE MADE. I WAS UNABLE TO REGISTER MY VEHICLE LAST YEAR DUE TO ALL THE PROBLEMS. I HAVE BEEN ON SEVERAL WEB SITES AND ABOUT THIS CAR AND EVERYONE IS HAVING SIMILAR PROBLEMS AND PUTTING OUT THOUSANDS OF DOLLARS IN REPAIRS. *NM
THE ENGINE LEAKED COOLANT AND OIL FROM THE BLOCK, WHICH IS NOT SUPPOSED TO HAPPEN. MY CAR THEN OVERHEATED ON THE ROAD WHICH LED TO MY COOLANT BURSTING OUT OF THE OVERFILL TANK. THE ENGINE THEN STARTED TO STEAM, AND ALL THE COOLANT LAID THERE ON THE ROAD. I WAS TOLD BY 3 DIFFERENT SHOPS THAT IT WAS THE HEAD GASKET THAT NEEDED TO …
Read full complaint
THE ENGINE LEAKED COOLANT AND OIL FROM THE BLOCK, WHICH IS NOT SUPPOSED TO HAPPEN. MY CAR THEN OVERHEATED ON THE ROAD WHICH LED TO MY COOLANT BURSTING OUT OF THE OVERFILL TANK. THE ENGINE THEN STARTED TO STEAM, AND ALL THE COOLANT LAID THERE ON THE ROAD. I WAS TOLD BY 3 DIFFERENT SHOPS THAT IT WAS THE HEAD GASKET THAT NEEDED TO BE REPLACED, WHICH COST ME $1000 IN PARTS AND LABOR.
IN MARCH OF '05 TOOK CAR IN FOR SEVICE ENGINE WAS TICKING WHILE IDLE AT ONE POINT ONCE CAR WAS WARMED UP THE TICKING STOPED BUT NOW THE TICKING IS STILL HEARD WHILE DRIVING AND AT ACCELEARTION. TOOK CAR IN THE BOB MCGUIRE CHEVROLET IN BORDENTOWN, NJ WAS TOLD THAT I HAD A HEAD GASKET LEAK THAT HAD ALREADY MIXED WITH THE ENGINE O…
Read full complaint
IN MARCH OF '05 TOOK CAR IN FOR SEVICE ENGINE WAS TICKING WHILE IDLE AT ONE POINT ONCE CAR WAS WARMED UP THE TICKING STOPED BUT NOW THE TICKING IS STILL HEARD WHILE DRIVING AND AT ACCELEARTION. TOOK CAR IN THE BOB MCGUIRE CHEVROLET IN BORDENTOWN, NJ WAS TOLD THAT I HAD A HEAD GASKET LEAK THAT HAD ALREADY MIXED WITH THE ENGINE OIL. HAD EVERYTHING FIXED AND THEY EVEN PUT IN HEAVY DUTY LIFTER CLEANER TO CLEAN THE LIFTERS ACCORDING TO MECANIC THAT WAS WERE THE TICK WAS COMING FROM BUT WHEN I PICKED UP THE CAR THE ENGINE WAS STILL TICKING WHEN IDLE AND THE NOISE HAD GOTTEN WORSE. WHEN I ASKED WHAT IT WOULD TAKE TO FIX THE TICKING I WAS TOLD THAT THE WHOLE JOB THAT WAS JUST PERFORMED ON THE CAR HAD TO BE PERFORMED AGAIN IN ORDER TO FIX THE LIFTERS THAT IS CAUSING THE TICKING.
FUEL PUMP, DISCONTINUED, BUT NOT RECALLED. *AK
NUMBER OF PROBLEMS SINCE THE CAR WAS PURCHASED NEW IN 1998. THE FRONT BRAKES HAVE BEEN AN ONGOING PROBLEM, THE COOLING SYSTEM HAS A LEAK AT THE INTAKE MANIFOLD AND NUMEROUS OTHER MAJOR PROBLEMS THAT EVERYONE I TALK TO OR READ ABOUT IS HAVING THE SAME PROBLEMS WITH THIS CAR. CHEVY WILL NOT DO ANYTHING ABOUT IT. *JB
1. VEHICLE LOSING COOLANT. 2. PROBLEM IS DUE TO FAILURE OF THE INTAKE MANIFOLD GASKET. 3. INTAKE GASKET NEEDS TO BE REPLACED. *JB
ENGINE LOCKED UP WHILE DRIVING AT HIGHWAY SPEED(70MPH) DUE TO FAILED INTAKE GASKET ON 1998 MALIBU 3.1 . ONE FLICKER OF OIL LIGHT (OIL HAD JUST BEEN CHANGED THAT MORNING BY MYSELF (EXPERIENCED AUTO TECHNICIAN) .ENGINE HAD 52,000 MILES, WAS 600 MILES FROM HOME(APPR), COST $750 TO TOW HOME, UPON DISASEMBLY FOUND FAILED INTAKE GASKE…
Read full complaint
ENGINE LOCKED UP WHILE DRIVING AT HIGHWAY SPEED(70MPH) DUE TO FAILED INTAKE GASKET ON 1998 MALIBU 3.1 . ONE FLICKER OF OIL LIGHT (OIL HAD JUST BEEN CHANGED THAT MORNING BY MYSELF (EXPERIENCED AUTO TECHNICIAN) .ENGINE HAD 52,000 MILES, WAS 600 MILES FROM HOME(APPR), COST $750 TO TOW HOME, UPON DISASEMBLY FOUND FAILED INTAKE GASKET, PURCHASED USED ENGINE,$600, $800 TO HAVE INSTALLED. GM CONTACTED IN EVERY FORUM AVAIL. REFUSED TO HELP IN ANY WAY. INSTALLED NEW GASKET ON USED ENGINE BEFORE INSTALLING, GM PARTS, NOW 37,000 MILES LATER HAVE INTAKE GASKET LEAK AGAIN.*AK
Official recalls
314V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
03V527000 · Steering:rack And Pinion
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
01V068000 · Visibility:windshield Wiper/washer:linkages
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
EA00010 · Stop Lamp Assembly Overheat
Opened Mar 27, 2000 · Closed Aug 9, 2001
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE99071 · Stop Lamp
Opened Nov 17, 1999 · Closed Mar 27, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available