IllustrationTAKATA RECALL - WHILE DRIVING HOME FROM WORK AT NIGHT MY DAUGHTER (SOLE OCCUPANT) HEARD A LOUD EXPLOSION AND WINDSHIELD SHATTERED. SHE LOOKED TO RIGHT AND SAW THAT THE PASSENGER AIRBAG HAD DEPLOYED. SHE HAD NOT HIT ANYTHING INCLUDING BUMPS OR POT-HOLE. NOT SURE IF IT'S A TAKATA BUT DEPLOYMENT COULD OF COST HER LIFE. *TR
1998 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 1998 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 223 of 976 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 347 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 144 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 130 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
34 crash reports5 fire reports18 injury reports
Air Bags complaints
40 reportsTL* THE CONTACT OWNS A 1998 CHEVROLET MALIBU. WHILE THE VEHICLE WAS AT A COMPLETE STOP, THE FRONT PASSENGER AND DRIVER SIDE AIR BAGS DEPLOYED WITHOUT WARNING AND SHATTERED THE FRONT PASSENGER SIDE OF THE WINDSHIELD. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPRO…
Read full complaint
TL* THE CONTACT OWNS A 1998 CHEVROLET MALIBU. WHILE THE VEHICLE WAS AT A COMPLETE STOP, THE FRONT PASSENGER AND DRIVER SIDE AIR BAGS DEPLOYED WITHOUT WARNING AND SHATTERED THE FRONT PASSENGER SIDE OF THE WINDSHIELD. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 113,751.
TL* THE CONTACT OWNS A 1998 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT A LOW SPEED, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE AIR BAG, ABS, AND CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON…
Read full complaint
TL* THE CONTACT OWNS A 1998 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT A LOW SPEED, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE AIR BAG, ABS, AND CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS 54,000.
TL* THE CONTACT OWNS A 1998 CHEVROLET MALIBU. WHILE DRIVING 5 MPH, THE CONTACT'S VEHICLE STALLED AND WAS STRUCK ON THE DRIVER SIDE BY ANOTHER VEHICLE. MOST OF THE AIR BAGS DEPLOYED; HOWEVER, ONE AIR BAG DID NOT, WHICH CAUSED INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VIN WAS INCLUDED IN NHTSA CAMPAI…
Read full complaint
TL* THE CONTACT OWNS A 1998 CHEVROLET MALIBU. WHILE DRIVING 5 MPH, THE CONTACT'S VEHICLE STALLED AND WAS STRUCK ON THE DRIVER SIDE BY ANOTHER VEHICLE. MOST OF THE AIR BAGS DEPLOYED; HOWEVER, ONE AIR BAG DID NOT, WHICH CAUSED INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM) AND MANUFACTURER RECALL NUMBER: N140350. THE FAILURE MILEAGE WAS UNKNOWN.
MY GRANDDAUGHTER WAS 18 YEARS OLD AND HAD RECENTLY GRADUATED HIGH SCHOOL. SHE WAS DRIVING TO WORK ON A TUESDAY MORNING, THE WEATHER WAS CLEAR AND THE ROAD WAS DRY. AS SHE ROUNDED A SMALL CURVE, HER STEERING WENT OUT. THE CAR'S RIGHT FRONT WHEEL WENT OFF THE ROAD, SENDING THE CAR OUT OF CONTROL. WHEN MY GRANDDAUGHTER TRIED TO…
Read full complaint
MY GRANDDAUGHTER WAS 18 YEARS OLD AND HAD RECENTLY GRADUATED HIGH SCHOOL. SHE WAS DRIVING TO WORK ON A TUESDAY MORNING, THE WEATHER WAS CLEAR AND THE ROAD WAS DRY. AS SHE ROUNDED A SMALL CURVE, HER STEERING WENT OUT. THE CAR'S RIGHT FRONT WHEEL WENT OFF THE ROAD, SENDING THE CAR OUT OF CONTROL. WHEN MY GRANDDAUGHTER TRIED TO STEER BACK ONTO THE ROAD, THE CAR SLID ON THE PAVEMENT, SPUN AROUND, WAS THROWN OVER A DITCH, HIT A TREE AND LANDED BACK ON THE ROAD. THE AIRBAG DID NOT DEPLOY, AND MY GRANDDAUGHTER'S SMALL BODY (98 POUNDS) WAS THROWN ACROSS THE SEAT AND INTO THE FLOORBOARD ON THE PASSENGER SIDE. WHEN POLICE AND AMBULANCES ARRIVED, THERE WAS NOTHING THEY COULD DO. MY GRANDDAUGHTER DIED AT THE SCENE FROM HEAD TRAUMA AND INTERNAL INJURIES. HER IDENTICAL TWIN SISTER LOST HALF OF HER IDENTITY THAT DAY; THE TWO OF THEM WERE AS ONE. EMERGENCY TEAMS HAD TO USE THE JAWS OF LIFE TO RETRIEVE HER BODY FROM THE CAR. THIS ACCIDENT HAPPENED WITHIN ONE MILE FROM MY HOME. I COULD HEAR THE SIRENS IN THE DISTANCE BUT HAD NO IDEA THAT THEY WERE SOUNDING FOR MY GRANDDAUGHTER. THE MEMORY OF THOSE SIRENS STILL HAUNTS ME. *TR
THIS VEHICLE HAD A CRASH WITH FATALITIES IN 2006. GENERAL MOTORS NEVER ISSUED A UNINTENDED IGNITION TURNOFF ON THIS VEHICLE UNTIL AUG2014. THE CRASH BEGAN WITH AN UNCONTROLLABLE AND UNEXPECTED SPINOUT, THERE WAS NO ABILITY TO STEER, BRAKE AND AIR BAGS DID NOT DEPLOY. THESE ARE THE EXACT CONDITIONS LISTED IN THE GM RECALL. GM WIL…
Read full complaint
THIS VEHICLE HAD A CRASH WITH FATALITIES IN 2006. GENERAL MOTORS NEVER ISSUED A UNINTENDED IGNITION TURNOFF ON THIS VEHICLE UNTIL AUG2014. THE CRASH BEGAN WITH AN UNCONTROLLABLE AND UNEXPECTED SPINOUT, THERE WAS NO ABILITY TO STEER, BRAKE AND AIR BAGS DID NOT DEPLOY. THESE ARE THE EXACT CONDITIONS LISTED IN THE GM RECALL. GM WILL NOT ACCEPT A FILING FOR THIS MAKE AND MODEL VEHICLE AND SHOULD BE ADDED TO THE GM IGNITION FAILURE CLAIM PROGRAM. NHTSA DIDN'T ALL THE GM RECALL TO MALIBU'S BUT I HAVE NOTIFIED THEM OF THE OVERSIGHT. THIS SHOULD BE CORRECTED AND COMPENSATION PROVIDED BY GM. THIS IS THE EXACT WORDING ON THE GM RECALL WEBSITE: THE FOLLOWING RECALLS HAVE BEEN FOUND FOR YOUR 1998 CHEVROLET MALIBU RESULTS LAST UPDATED: SEP 16, 2014 GM RECALL #: N140350 NHTSA RECALL #: 14V400 DATE ISSUED: AUG 12, 2014 UNINTENDED IGNITION KEY ROTATION RECALL DESCRIPTION: GENERAL MOTORS HAS DECIDED THAT A DEFECT WHICH RELATES TO MOTOR VEHICLE SAFETY EXISTS IN 2000-2005 MY CHEVROLET IMPALA AND MONTE CARLO, 1997-2005 MY CHEVROLET MALIBU, 1999-2004 MY OLDSMOBILE ALERO, 1998-2002 MY OLDSMOBILE INTRIGUE, 1999-2005 MY PONTIAC GRAND AM, AND 2004-2008 MY PONTIAC GRAND PRIX VEHICLES. IF THE KEY RING IS CARRYING ADDED WEIGHT AND THE VEHICLE GOES OFF ROAD OR EXPERIENCES SOME OTHER JARRING EVENT, IT MAY UNINTENTIONALLY MOVE THE KEY AWAY FROM THE RUN POSITION. IF THIS OCCURS, ENGINE POWER, POWER STEERING AND POWER BRAKING MAY BE AFFECTED, INCREASING THE RISK OF A CRASH. SAFETY RISK DESCRIPTION: THE TIMING OF THE KEY MOVEMENT OUT OF THE RUN POSITION, RELATIVE TO THE ACTIVATION OF THE SENSING ALGORITHM OF THE CRASH EVENT, MAY RESULT IN THE AIRBAGS NOT DEPLOYING, INCREASING THE POTENTIAL FOR OCCUPANT INJURY IN CERTAIN KINDS OF CRASHES. *TR
DT*: THE CONTACT STATED WHILE TRAVELING 35 MPH, THE VEHICLE WAS INVOLVED IN A FRONT IMPACT CRASH, AND THE AIRBAGS DID NOT DEPLOY. ADDITIONALLY, THE CONTACT WAS WEARING A SEAT BELT, AND THE BUCKLE ASSEMBLY FRACTURED UPON INITIAL IMPACT. THERE WERE NO INJURIES SUSTAINED. THE VEHICLE SUSTAINED MODERATE DAMAGE TO THE FRONT END. …
Read full complaint
DT*: THE CONTACT STATED WHILE TRAVELING 35 MPH, THE VEHICLE WAS INVOLVED IN A FRONT IMPACT CRASH, AND THE AIRBAGS DID NOT DEPLOY. ADDITIONALLY, THE CONTACT WAS WEARING A SEAT BELT, AND THE BUCKLE ASSEMBLY FRACTURED UPON INITIAL IMPACT. THERE WERE NO INJURIES SUSTAINED. THE VEHICLE SUSTAINED MODERATE DAMAGE TO THE FRONT END. THE POLICE WERE ON THE SCENE, AND A REPORT WAS TAKEN. THE MANUFACTURER WAS ALERTED.
I WAS DRIVING SOUTHBOUND ON STATE RD. 1 AFTER WORK AT APPROXIMATELY 10:15 P.M. I CROSSED RAILROAD TRACKS AT ABOUT 32 MPH AND BOTH OF MY AIRBAGS INADVERTENTLY DISCHARGED. THIS FORCED MY REAR VIEW MIRROR INTO THE WINDSHIELD AND CRACKED THE WINDSHIELD. ALSO MY DASHBOARD LIGHTS ARE NOW ACTING ERRATICALLY AND FUNCTIONS FAIL TO WOR…
Read full complaint
I WAS DRIVING SOUTHBOUND ON STATE RD. 1 AFTER WORK AT APPROXIMATELY 10:15 P.M. I CROSSED RAILROAD TRACKS AT ABOUT 32 MPH AND BOTH OF MY AIRBAGS INADVERTENTLY DISCHARGED. THIS FORCED MY REAR VIEW MIRROR INTO THE WINDSHIELD AND CRACKED THE WINDSHIELD. ALSO MY DASHBOARD LIGHTS ARE NOW ACTING ERRATICALLY AND FUNCTIONS FAIL TO WORK PROPERLY. THE SHOCK OF THE RAILROAD TRACKS IS MUCH LESS THAN THAT OF A SPEED BUMP AT 3 MPH. G.M. HAS FAILED TO SEND ANYONE TO INSPECT THE VEHICLE EVEN AFTER LETTING IT SIT AT A DEALERSHIP FOR 7 DAYS BECAUSE THEY ORIGINALLY STATED THEY WOULD. G.M. TWO DIFFERENT DEALERSHIPS HAVE INSPECTED THE VEHICLE EXTENSIVELY ON SEVERAL OCCASIONS AND BOTH WERE UNABLE TO DETERMINE THE CAUSE OF THE DEPLOYMENT. I HAVE CONTACTED G.M. SEVERAL TIMES AND THEY ARE BRUSHING THIS OFF LIKE IT IS NOTHING TO WORRY ABOUT. *NM
CONSUMER COMPLAINED ABOUT A HORN PROBLEM. CONTACTED THE DEALER AND MANUFACTURER, AND NEITHER WAS WILLING TO ASSIST. CONSUMER WAS INFORMED BY THE DEALER THAT THE HORN WAS DEFECTIVE BECAUSE OF THE AIR BAG COMPONENTS BEING PRESSED AGAINST THE WIRING OF THE HORN. VEHICLE WAS NEVER IN AN ACCIDENT. *AK
VEHICLE WAS IN A LOW SPEED, LOW IMPACT COLLISION. HOWEVER, THE FRONT AIR BAGS DEPLOYED. VEHICLE WAS MOVING ABOUT 10 MPH. *AK
Official recalls
314V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
03V527000 · Steering:rack And Pinion
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
01V068000 · Visibility:windshield Wiper/washer:linkages
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
EA00010 · Stop Lamp Assembly Overheat
Opened Mar 27, 2000 · Closed Aug 9, 2001
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE99071 · Stop Lamp
Opened Nov 17, 1999 · Closed Mar 27, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available