Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 8 of 35 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Visibility. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports4 fire reports1 injury reports
What owners actually said
35 reports
218,000 miles · Apr 14, 2007
Latches/locks/linkagesFire
I SMELLED SMOKE IN MY VEHICLE, SO I PULLED OVER. IT SEEMED TO BE COMING FROM THE VENT. MY FRIEND THOUGHT IT WAS ELECTICAL, SO HE STARTED PULLING FUSES TO STOP THE PROBLEM. I DISCERNED THAT THE PROBLEM WAS THE MOTOR THAT OPENED AND CLOSED THE AUTOMATIC DOOR OPENER ON THE VAN. I TOLD MY FRIEND TO JUST GET OUT AND I CALLED THE …
Read full complaint
I SMELLED SMOKE IN MY VEHICLE, SO I PULLED OVER. IT SEEMED TO BE COMING FROM THE VENT. MY FRIEND THOUGHT IT WAS ELECTICAL, SO HE STARTED PULLING FUSES TO STOP THE PROBLEM. I DISCERNED THAT THE PROBLEM WAS THE MOTOR THAT OPENED AND CLOSED THE AUTOMATIC DOOR OPENER ON THE VAN. I TOLD MY FRIEND TO JUST GET OUT AND I CALLED THE FIRE DEPARTMENT IMMEDIATELY, BUT BY THE TIME THEY HAD ARRIVED MY CAR WAS FULLY ENGULFED IN FLAMES. I AM THANKFUL THAT I DID NOT HAVE MY CHILDREN WITH ME AT THE TIME AS I DON'T KNOW IF I COULD HAVE GOTTEN THEM OUT IN TIME. MY THREE YEAR OLD WOULD HAVE BEEN IN THE BUILT-IN CAR SEAT WHICH IS NEXT TO THE DOOR. THE FIRE HAPPENED SO FAST. I MIGHT ADD I HAVE NEVER HAD ANY PROBLEMS WITH THE DOOR OR AUTOMATIC DOOR OPENER. MY CAR WAS TOTALED. *AK
NHTSA ODI #10187857
126,200 miles · Mar 26, 2005
Visibility
WINDSHIELD WIPER MOTOR FAILURE. WINDSHIELD WIPERS WORK INTERMITTENTLY AND SOMETIMES NOT AT ALL ! *AK
NHTSA ODI #10114808
Mileage unknown · Feb 8, 2005
Electrical SystemFire
LOUD TAPPING SOUND FROM ENGINE WHEN FIRST STARTED.*AK
NHTSA ODI #10110107
84,286 miles · Nov 26, 2004
Visibility
THE WINDSHIELD WIPERS FAILEED INTERMITTENTLY. DEALER STATED PROBLEM COULD NOT DUPLICATED. *AK
NHTSA ODI #10101699
Mileage unknown · Nov 5, 2004
Electrical SystemSteeringVisibility
EXPERIENCED INTERMITTENT OF POWER STEERING, LOST STEERING CONTROL OF THE VEHICLE. REPLACED RACK AND PINION. *BF THE VEHICELK RACK AND PINION FAIELD PRIOR TO RECEIVING THE RECALL NOTICE. THE DRIVER'S SIDE POWER WINDOW MOTOR FAILED, THE ALTERNATOR, AIR CONDITIONING AND WINDSHIELD WIPER ASSEMBLY ALSO FAILED. *NM
NHTSA ODI #10099926
91,000 miles · Jul 5, 2004
Engine And Engine Cooling
ENGINE OVERHEATED DUE TO INTAKE GASKET FAILURE. WIFE AND MINOR CHILD STUCK ON THE SIDE OF INTERSTATE AT 9:30 PM.,WITH STRANDED VEHICLE. *AK
NHTSA ODI #10080366
109,000 miles · Mar 18, 2004
Engine And Engine Cooling
WHILE DRIVING, THE ENGINE WILL CUT OUT, THEN RUN SMOOTH AGAIN, CAUSING THE CAR TO JERK. SEVERAL TIMES THE ENGINE WOULD DIE. THE CAR WOULD START BACK UP, WHEN YOU PUT INTO GEAR AND PUSH THE GAS, THE ENGINE WOULD CUT OUT, THE CAR WOULD JERK AS THE ENGINE CUT OUT AND THEN REENGAGE, BUT EVENTUALLY THE ENGINE WOULD DIE. WE SENT T…
Read full complaint
WHILE DRIVING, THE ENGINE WILL CUT OUT, THEN RUN SMOOTH AGAIN, CAUSING THE CAR TO JERK. SEVERAL TIMES THE ENGINE WOULD DIE. THE CAR WOULD START BACK UP, WHEN YOU PUT INTO GEAR AND PUSH THE GAS, THE ENGINE WOULD CUT OUT, THE CAR WOULD JERK AS THE ENGINE CUT OUT AND THEN REENGAGE, BUT EVENTUALLY THE ENGINE WOULD DIE. WE SENT TO OUR LOCAL REPAIR SHOP, HE REPLACED THE SPARK PLUGS, MINOR TUNE, REPLACE AIR FILTER, CHECK FUEL PUMP - OK, AND REPLACE FUEL FILTER. CAR RAN FINE FOR THREE DAYS AND THEN REPEATED THE SAME PROBLEM. TOOK BACK INTO SHOP, REPLACED IGNITION SWITCH AND COILS. ENGINE RUNS OK, BUT WHEN ENGAGING INTO GEAR ENGINE DID NOT HAVE THE SAME RESPONSE AS BEFORE, IT FELT LIKE IT WAS RUNNING AT HALF SPEED. CAR IS NOW SLOW TO GAIN SPEED. TOP SPEED IS 65 MILES PER HOUR. NOW 'SERVICE ENGINE SOON' LIGHT IS ON, SOMETIMES FLASHING.*AK
NHTSA ODI #10062492
130,000 miles · Oct 16, 2003
Electrical SystemFire
MY 1996 LUMINA MINI VAN CAUGHT ON FIRE AT THE REAR RIGHT WHEEL WELL BECAUSE OF A WIRING SHORT. LUCKILY MY GRANDCHILDREN WERE IN THE STORE WHEN THEY CAME OUT THE FIRE DEPARTMENT WAS PUTTING THE FIRE OUT. BOTH THE SIDE AND BACK DOORS COULD NOT OPEN BECAUSE THE POWER LOCK MODULE HAD MELTED. IF ANYONE WOULD HAVE BEEN INSIDE THEY WOU…
Read full complaint
MY 1996 LUMINA MINI VAN CAUGHT ON FIRE AT THE REAR RIGHT WHEEL WELL BECAUSE OF A WIRING SHORT. LUCKILY MY GRANDCHILDREN WERE IN THE STORE WHEN THEY CAME OUT THE FIRE DEPARTMENT WAS PUTTING THE FIRE OUT. BOTH THE SIDE AND BACK DOORS COULD NOT OPEN BECAUSE THE POWER LOCK MODULE HAD MELTED. IF ANYONE WOULD HAVE BEEN INSIDE THEY WOULD NOT BEEN ABLE TO GET OUT OF THE VEHICLE SAFELY. *LA
NHTSA ODI #10043013
88,320 miles · Jul 6, 2003
Visibility
WINDSHIELD WIPER SWITCH WORKS INTERMITTENTLY.*AK
NHTSA ODI #10025479
Mileage unknown · Apr 16, 2003
SteeringCrash
AFTER RECALL FOR THE POWER STEERING ASSEMBLY 02 V 286 000 WAS PERFORMED THE POWER STEERING FAILED AGAIN. *NLM
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1996 Chevrolet Lumina Apv Problems, Complaints & Recalls | Skip That Year
Illustration