IllustrationMY 2006 CHEVY IMPALA CONTINUES TO HAVE BRAKE ROTOR PROBLEMS. I HAVE TO CHANGE THEM EVERY SIX MONTHS DUE TO OVERHEATING WHICH CAUSES DANGEROUS BRAKING TO OCCUR. *TR
2006 Chevrolet Impala
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Impala years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
550–25K
7125–50K
7650–75K
7475–100K
87100–150K
41150K+
404 reports with mileage · 120 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 135 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 124 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 108 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
58 crash reports22 fire reports35 injury reports
What owners actually said
524 reportsTL* THE CONTACT OWNS A 2006 CHEVROLET IMPALA. THE CONTACT STATED THAT THE SUN VISOR WOULD NOT REMAIN IN THE UPWARD POSITION AND WOULD CONTINUOUSLY FALL INTO THE DRIVER'S VIEW OF THE ROADWAY. THE SUN VISOR WOULD HANG EXTREMELY LOW. THE CONTACT STATED THE BEEN FAILURE PRESENTED ITSELF SHORTLY AFTER PURCHASING THE VEHICLE. THE DEA…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET IMPALA. THE CONTACT STATED THAT THE SUN VISOR WOULD NOT REMAIN IN THE UPWARD POSITION AND WOULD CONTINUOUSLY FALL INTO THE DRIVER'S VIEW OF THE ROADWAY. THE SUN VISOR WOULD HANG EXTREMELY LOW. THE CONTACT STATED THE BEEN FAILURE PRESENTED ITSELF SHORTLY AFTER PURCHASING THE VEHICLE. THE DEALER ADVISED THAT THE SUN VISOR WOULD NEED TO BE REPLACED BUT THE VEHICLE WOULD FIRST NEED TO BE DIAGNOSED. THE VEHICLE WAS NEITHER REPLACED NOR REPAIRED. THE FAILURE MILEAGE WAS 44,000 AND THE CURRENT MILEAGE WAS 82,000.
2006 CHEVROLET IMPALA 8 MONTHS AGO THE LEFT BACK DOOR WOULD NOT OPEN, A COUPLE MONTHS LATER THE RIGHT BACK DOOR WILL NOT OPEN. I WAS UNABLE TO GET MY GRANDSON OUT OF THE CAR SEAT I HAD TO CLIMB OVER THE FRONT SEATS TO UNLOCK THE CAR SEAT UNDO THE SEAT BELT CLIMB BACK OVER AND THAN LIFT HIM OUT THROUGH THE FRONT SEAT. IF THERE…
Read full complaint
2006 CHEVROLET IMPALA 8 MONTHS AGO THE LEFT BACK DOOR WOULD NOT OPEN, A COUPLE MONTHS LATER THE RIGHT BACK DOOR WILL NOT OPEN. I WAS UNABLE TO GET MY GRANDSON OUT OF THE CAR SEAT I HAD TO CLIMB OVER THE FRONT SEATS TO UNLOCK THE CAR SEAT UNDO THE SEAT BELT CLIMB BACK OVER AND THAN LIFT HIM OUT THROUGH THE FRONT SEAT. IF THERE WOULD HAVE BEEN AN ACCIDENT I WOULD NOT HAVE BEEN ABLE TO GET HIM OUT THROUGH THE BACK DOORS. THERE IS A SAFETY ISSUE WITH THIS PROBLEM. *TR
THE GAS CAPS OF 2006 CHEVROLET IMPALAS HAVE A DESIGN DEFECT IN THE GAS CAPS WHICH ALLOW FOR THE CAP TO FAIL AND THE EVAP SOLENOID TO FAIL. *TR
2006 CHEVY IMPALA SEEMS TO HAVE HOT HEAT NEAR THE PASSENGER FRONT BY WERE YOUR FEET REST ,AND I HAVE ALREADY FIXED THE TRANSMISSION TWICE AND FOR SOME REASON IT IS AGAIN MAKING THIS REAL LOUD NOISE WHEN I TAKE IT OFF OF PARK IT IS REALLY HARD TO MOVE IT IN TO PARK MODE AND WHEN IT DOES IT JERKS REALLY HARD. *TR
TL*THE CONTACT OWNS A 2006 CHEVROLET IMPALA. WHILE APPLYING THE BRAKES APPROXIMATELY 15 MPH, THERE WAS EXCESSIVE RESISTANCE WITHIN THE STEERING WHEEL. AN AUTHORIZED DEALER INFORMED THE CONTACT THAT THE FAILURE WAS A NORMAL OCCURRENCE FOR HIS YEAR, MAKE AND MODEL VEHICLE. THE CONTACT STATED THAT THE FAILURE HAD BECOME PROGRESSI…
Read full complaint
TL*THE CONTACT OWNS A 2006 CHEVROLET IMPALA. WHILE APPLYING THE BRAKES APPROXIMATELY 15 MPH, THERE WAS EXCESSIVE RESISTANCE WITHIN THE STEERING WHEEL. AN AUTHORIZED DEALER INFORMED THE CONTACT THAT THE FAILURE WAS A NORMAL OCCURRENCE FOR HIS YEAR, MAKE AND MODEL VEHICLE. THE CONTACT STATED THAT THE FAILURE HAD BECOME PROGRESSIVELY WORSE WITHIN A YEAR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE CONTINUED TO OCCUR WHENEVER THE BRAKES WERE APPLIED OR WHEN THE VEHICLE CAME TO A COMPLETE STOP. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 60,000.
THE CAR WAS PARKED IN FRONT OF OUR HOME. I SAW FLAMES ON DRIVER'S SIDE, WHICH QUICKLY CONSUMED THE ENTIRE INTERIOR. 911 WAS CALLED AND OUR LOCAL FIRE DEPARTMENT PUT IT OUT. THE FIREMAN BELIEVES IT WAS CAUSED BY THE ELECTRICAL SYSTEM. *TR
TRANSMISSION LUNGES FROM A DEAD STOP UPON ACCELERATION. DOES NOT MOVE WITH INCREASED RPMS UNTIL TORQUE CONVERTER BANGS. PROBLEM HAS EXISTED SINCE PURCHASE IN 2006 WITH 11,000 MILES. TAKEN TO DEALER MULTIPLE TIMES WITH NO PROBLEM FOUND. MULTIPLE COMPLAINTS WITH THIS PER INTERNET SEARCH. CHEVROLET EVIDENTLY WILL NOT OWN UP TO THIS…
Read full complaint
TRANSMISSION LUNGES FROM A DEAD STOP UPON ACCELERATION. DOES NOT MOVE WITH INCREASED RPMS UNTIL TORQUE CONVERTER BANGS. PROBLEM HAS EXISTED SINCE PURCHASE IN 2006 WITH 11,000 MILES. TAKEN TO DEALER MULTIPLE TIMES WITH NO PROBLEM FOUND. MULTIPLE COMPLAINTS WITH THIS PER INTERNET SEARCH. CHEVROLET EVIDENTLY WILL NOT OWN UP TO THIS PROBLEM. *TR
TL* THE CONTACT OWNS A 2006 CHEVROLET IMPALA. THE CONTACT STATED WHEN DRIVING THE VEHICLE AT ANY POINT WHERE THE ENGINE WOULD BECOME WARM, THE ENGINE WOULD REMAIN WARM FOR APPROXIMATELY THREE HOURS AFTER SHUTTING OFF. THE CONTACT BELIEVED THERE TO BE A DEFECT IN THE WIRING OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRE…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET IMPALA. THE CONTACT STATED WHEN DRIVING THE VEHICLE AT ANY POINT WHERE THE ENGINE WOULD BECOME WARM, THE ENGINE WOULD REMAIN WARM FOR APPROXIMATELY THREE HOURS AFTER SHUTTING OFF. THE CONTACT BELIEVED THERE TO BE A DEFECT IN THE WIRING OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 52,000.
2006 CHEVY IMPALA INVOLVED IN ACCIDENT 6/7/10. AIRBAGS DID NOT DEPLOY. POINT OF COLLISION WAS PASSENGER FRONT AT AN IMPACT OF 30 MPH. *TR
Official recalls
114V355000 · Electrical System:ignition
Jun 23, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) is recalling certain model year 2005-2009 Buick LaCrosse, 2006-2011 Buick Lucerne, 2000-2005 Cadillac DeVille, 2006-2011 Cadillac DTS, 2006-2014 Chevrolet Impala, and 2006-2007 Chevrolet Monte Carlo vehicles. In the affected vehicles, the weight on the key ring and road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury. Additionally, a key knocked out of the run position will cause loss of engine power, power steering, and power braking, increasing the risk of a vehicle crash.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 23, 2014. Owners may contact General Motors customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), and 1-800-222-1020 (Chevrolet). GM's number for this recall is 14299.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE09025 · Power Steering Fluid Leaks - Fires
Opened May 13, 2009 · Closed Oct 2, 2009
Status: closed (inferred from source dates) · Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
GENERAL MOTORS (GM) INITIATED A CUSTOMER SATISFACTION CAMPAIGN IN OCTOBER OF 2006 TO ADDRESS A FAILURE OF THE POWER STEERING HOSE AND/OR CLAMPS THAT COULD OCCUR WHEN THE ENGINE IS STARTED IN VEHICLES PRIMARILY OPERATED IN THE FOLLOWING STATES THAT EXPERIENCE EXTREMELY COLD TEMPERATURES:ALASKA, MAINE, MINNESOTA, MONTANA, NEW HAMPSHIRE, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN AND WYOMING.AT THE TIME THIS PRELIMINARY EVALUATION (PE) WAS OPENED, ONLY 1 OF THE 33 COMPLAINTS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI) WAS FROM A STATE COVERED BY THE CUSTOMER SATISFACTION CAMPAIGN.IN RESPONSE TO AN INFORMATION REQUEST SENT BY THE ODI, GM PROVIDED INFORMATION THAT INCLUDED 6 ALLEGED FIRES AND 1 ALLEGED MINOR CRASH POTENTIALLY RELATED TO THE ALLEGED DEFECT. ONE OF THE ALLEGED FIRES IS A DUPLICATE OF A REPORT RECEIVED BY ODI.OF THE FIRE INCIDENTS, 2 OF THE 6 ALLEGED FIRE INCIDENTS OCCURRED AFTER THE REMEDY DETAILED IN THE CUSTOMER SATISFACTION PROGRAM WAS PERFORMED.ONE OF THE VEHICLES WAS TOTALED AS A RESULT OF THE INCIDENT.IT IS UNDETERMINED WHETHER THE INCIDENTS WERE RELATED TO THE ALLEGED DEFECT OR WERE A BY PRODUCT OF THE REPAIR.OF THE OTHER FOUR ALLEGED FIRE INCIDENTS, 1 INCIDENT INVOLVED SMOKE ONLY AND NO VISIBLE FLAMES.BASED ON THE INFORMATION PROVIDED, THE REMAINING 3 FIRE INCIDENTS WERE LOCALIZED EVENTS THAT PRIMARILY INVOLVED DAMAGE TO THE POWER STEERING COMPONENTS AND SURROUNDING WIRING.ALL 3 OF THESE VEHICLES WERE SUBSEQUENTLY REPAIRED.NONE OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS UNATTENDED.ODI IS AWARE OF 1 ADDITIONAL ALLEGED FIRE INCIDENT THAT WAS NOT INCLUDED IN GM'S INFORMATION REQUEST RESPONSE.BASED ON THE CONSUMER'S DESCRIPTION OF THE INCIDENT, THE FIRE WAS QUICKLY EXTINGUISHED BY A FRIEND AND THE VEHICLE WAS SUBSEQUENTLY REPAIRED AT A DEALERSHIP.IN TOTAL ODI IS AWARE OF 6 ALLEGED FIRE INCIDENTS WHERE THE CONSUMER ALLEGED FLAMES WERE VISIBLE.ALL OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS STILL ATTENDED. ODI IS AWARE 1 MINOR CRASH ALLEGED TO BE RELATED TO A POWER STEERING FLUID LEAK.THE CONSUMER ALLEGED A MINOR CRASH OCCURRED AS THE CONSUMER WAS ATTEMPTING TO PULL INTO A DRIVEWAY AND HAD DIFFICULTY NEGOTIATING THE TURN DUE TO EXPERIENCING HIGH POWER STEERING EFFORTS AND STRUCK A SNOW BANK.IN A LETTER DATED SEPTEMBER 21, 2009, GM INFORMED ODI THAT A CUSTOMER SATISFACTION PROGRAM WILL COMMENCE IN DECEMBER OF 2009 FOR THE ENTIRE US. AS A REMEDY THE POWER STEERING HOSE ASSEMBLY FOR VEHICLES WITH V8 ENGINES AND THE POWER STEERING RETURN HOSE AND CLAMPS FOR VEHICLES WITH V6 ENGINES WILL BE REPLACED WITH UPGRADED COMPONENTS.BASED ON THE LOW FREQUENCIES AND MINOR SEVERITIES OF THE ALLEGED FIRE INCIDENTS AND CRASH,NO SAFETY RELATED DEFECT TREND HAS BEEN IDENTIFIED IN THE SUBJECT VEHICLES.GM'S EXPANDED CUSTOMER SATISFACTION PROGRAM WILL PROVIDE FREE REPAIRS TO VEHICLES EXCLUDED FROM THE ORIGINAL CAMPAIGN.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (3)
Steering:hydraulic Power Assist:hose, Piping, And Connections
GENERAL MOTORS (GM) INITIATED A CUSTOMER SATISFACTION CAMPAIGN IN OCTOBER OF 2006 TO ADDRESS A FAILURE OF THE POWER STEERING HOSE AND/OR CLAMPS THAT COULD OCCUR WHEN THE ENGINE IS STARTED IN VEHICLES PRIMARILY OPERATED IN THE FOLLOWING STATES THAT EXPERIENCE EXTREMELY COLD TEMPERATURES:ALASKA, MAINE, MINNESOTA, MONTANA, NEW HAMPSHIRE, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN AND WYOMING.AT THE TIME THIS PRELIMINARY EVALUATION (PE) WAS OPENED, ONLY 1 OF THE 33 COMPLAINTS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI) WAS FROM A STATE COVERED BY THE CUSTOMER SATISFACTION CAMPAIGN.IN RESPONSE TO AN INFORMATION REQUEST SENT BY THE ODI, GM PROVIDED INFORMATION THAT INCLUDED 6 ALLEGED FIRES AND 1 ALLEGED MINOR CRASH POTENTIALLY RELATED TO THE ALLEGED DEFECT. ONE OF THE ALLEGED FIRES IS A DUPLICATE OF A REPORT RECEIVED BY ODI.OF THE FIRE INCIDENTS, 2 OF THE 6 ALLEGED FIRE INCIDENTS OCCURRED AFTER THE REMEDY DETAILED IN THE CUSTOMER SATISFACTION PROGRAM WAS PERFORMED.ONE OF THE VEHICLES WAS TOTALED AS A RESULT OF THE INCIDENT.IT IS UNDETERMINED WHETHER THE INCIDENTS WERE RELATED TO THE ALLEGED DEFECT OR WERE A BY PRODUCT OF THE REPAIR.OF THE OTHER FOUR ALLEGED FIRE INCIDENTS, 1 INCIDENT INVOLVED SMOKE ONLY AND NO VISIBLE FLAMES.BASED ON THE INFORMATION PROVIDED, THE REMAINING 3 FIRE INCIDENTS WERE LOCALIZED EVENTS THAT PRIMARILY INVOLVED DAMAGE TO THE POWER STEERING COMPONENTS AND SURROUNDING WIRING.ALL 3 OF THESE VEHICLES WERE SUBSEQUENTLY REPAIRED.NONE OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS UNATTENDED.ODI IS AWARE OF 1 ADDITIONAL ALLEGED FIRE INCIDENT THAT WAS NOT INCLUDED IN GM'S INFORMATION REQUEST RESPONSE.BASED ON THE CONSUMER'S DESCRIPTION OF THE INCIDENT, THE FIRE WAS QUICKLY EXTINGUISHED BY A FRIEND AND THE VEHICLE WAS SUBSEQUENTLY REPAIRED AT A DEALERSHIP.IN TOTAL ODI IS AWARE OF 6 ALLEGED FIRE INCIDENTS WHERE THE CONSUMER ALLEGED FLAMES WERE VISIBLE.ALL OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS STILL ATTENDED. ODI IS AWARE 1 MINOR CRASH ALLEGED TO BE RELATED TO A POWER STEERING FLUID LEAK.THE CONSUMER ALLEGED A MINOR CRASH OCCURRED AS THE CONSUMER WAS ATTEMPTING TO PULL INTO A DRIVEWAY AND HAD DIFFICULTY NEGOTIATING THE TURN DUE TO EXPERIENCING HIGH POWER STEERING EFFORTS AND STRUCK A SNOW BANK.IN A LETTER DATED SEPTEMBER 21, 2009, GM INFORMED ODI THAT A CUSTOMER SATISFACTION PROGRAM WILL COMMENCE IN DECEMBER OF 2009 FOR THE ENTIRE US. AS A REMEDY THE POWER STEERING HOSE ASSEMBLY FOR VEHICLES WITH V8 ENGINES AND THE POWER STEERING RETURN HOSE AND CLAMPS FOR VEHICLES WITH V6 ENGINES WILL BE REPLACED WITH UPGRADED COMPONENTS.BASED ON THE LOW FREQUENCIES AND MINOR SEVERITIES OF THE ALLEGED FIRE INCIDENTS AND CRASH,NO SAFETY RELATED DEFECT TREND HAS BEEN IDENTIFIED IN THE SUBJECT VEHICLES.GM'S EXPANDED CUSTOMER SATISFACTION PROGRAM WILL PROVIDE FREE REPAIRS TO VEHICLES EXCLUDED FROM THE ORIGINAL CAMPAIGN.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Steering:hydraulic Power Assist:power Steering Fluid
GENERAL MOTORS (GM) INITIATED A CUSTOMER SATISFACTION CAMPAIGN IN OCTOBER OF 2006 TO ADDRESS A FAILURE OF THE POWER STEERING HOSE AND/OR CLAMPS THAT COULD OCCUR WHEN THE ENGINE IS STARTED IN VEHICLES PRIMARILY OPERATED IN THE FOLLOWING STATES THAT EXPERIENCE EXTREMELY COLD TEMPERATURES:ALASKA, MAINE, MINNESOTA, MONTANA, NEW HAMPSHIRE, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN AND WYOMING.AT THE TIME THIS PRELIMINARY EVALUATION (PE) WAS OPENED, ONLY 1 OF THE 33 COMPLAINTS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI) WAS FROM A STATE COVERED BY THE CUSTOMER SATISFACTION CAMPAIGN.IN RESPONSE TO AN INFORMATION REQUEST SENT BY THE ODI, GM PROVIDED INFORMATION THAT INCLUDED 6 ALLEGED FIRES AND 1 ALLEGED MINOR CRASH POTENTIALLY RELATED TO THE ALLEGED DEFECT. ONE OF THE ALLEGED FIRES IS A DUPLICATE OF A REPORT RECEIVED BY ODI.OF THE FIRE INCIDENTS, 2 OF THE 6 ALLEGED FIRE INCIDENTS OCCURRED AFTER THE REMEDY DETAILED IN THE CUSTOMER SATISFACTION PROGRAM WAS PERFORMED.ONE OF THE VEHICLES WAS TOTALED AS A RESULT OF THE INCIDENT.IT IS UNDETERMINED WHETHER THE INCIDENTS WERE RELATED TO THE ALLEGED DEFECT OR WERE A BY PRODUCT OF THE REPAIR.OF THE OTHER FOUR ALLEGED FIRE INCIDENTS, 1 INCIDENT INVOLVED SMOKE ONLY AND NO VISIBLE FLAMES.BASED ON THE INFORMATION PROVIDED, THE REMAINING 3 FIRE INCIDENTS WERE LOCALIZED EVENTS THAT PRIMARILY INVOLVED DAMAGE TO THE POWER STEERING COMPONENTS AND SURROUNDING WIRING.ALL 3 OF THESE VEHICLES WERE SUBSEQUENTLY REPAIRED.NONE OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS UNATTENDED.ODI IS AWARE OF 1 ADDITIONAL ALLEGED FIRE INCIDENT THAT WAS NOT INCLUDED IN GM'S INFORMATION REQUEST RESPONSE.BASED ON THE CONSUMER'S DESCRIPTION OF THE INCIDENT, THE FIRE WAS QUICKLY EXTINGUISHED BY A FRIEND AND THE VEHICLE WAS SUBSEQUENTLY REPAIRED AT A DEALERSHIP.IN TOTAL ODI IS AWARE OF 6 ALLEGED FIRE INCIDENTS WHERE THE CONSUMER ALLEGED FLAMES WERE VISIBLE.ALL OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS STILL ATTENDED. ODI IS AWARE 1 MINOR CRASH ALLEGED TO BE RELATED TO A POWER STEERING FLUID LEAK.THE CONSUMER ALLEGED A MINOR CRASH OCCURRED AS THE CONSUMER WAS ATTEMPTING TO PULL INTO A DRIVEWAY AND HAD DIFFICULTY NEGOTIATING THE TURN DUE TO EXPERIENCING HIGH POWER STEERING EFFORTS AND STRUCK A SNOW BANK.IN A LETTER DATED SEPTEMBER 21, 2009, GM INFORMED ODI THAT A CUSTOMER SATISFACTION PROGRAM WILL COMMENCE IN DECEMBER OF 2009 FOR THE ENTIRE US. AS A REMEDY THE POWER STEERING HOSE ASSEMBLY FOR VEHICLES WITH V8 ENGINES AND THE POWER STEERING RETURN HOSE AND CLAMPS FOR VEHICLES WITH V6 ENGINES WILL BE REPLACED WITH UPGRADED COMPONENTS.BASED ON THE LOW FREQUENCIES AND MINOR SEVERITIES OF THE ALLEGED FIRE INCIDENTS AND CRASH,NO SAFETY RELATED DEFECT TREND HAS BEEN IDENTIFIED IN THE SUBJECT VEHICLES.GM'S EXPANDED CUSTOMER SATISFACTION PROGRAM WILL PROVIDE FREE REPAIRS TO VEHICLES EXCLUDED FROM THE ORIGINAL CAMPAIGN.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Steering:hydraulic Power Assist System
GENERAL MOTORS (GM) INITIATED A CUSTOMER SATISFACTION CAMPAIGN IN OCTOBER OF 2006 TO ADDRESS A FAILURE OF THE POWER STEERING HOSE AND/OR CLAMPS THAT COULD OCCUR WHEN THE ENGINE IS STARTED IN VEHICLES PRIMARILY OPERATED IN THE FOLLOWING STATES THAT EXPERIENCE EXTREMELY COLD TEMPERATURES:ALASKA, MAINE, MINNESOTA, MONTANA, NEW HAMPSHIRE, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN AND WYOMING.AT THE TIME THIS PRELIMINARY EVALUATION (PE) WAS OPENED, ONLY 1 OF THE 33 COMPLAINTS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI) WAS FROM A STATE COVERED BY THE CUSTOMER SATISFACTION CAMPAIGN.IN RESPONSE TO AN INFORMATION REQUEST SENT BY THE ODI, GM PROVIDED INFORMATION THAT INCLUDED 6 ALLEGED FIRES AND 1 ALLEGED MINOR CRASH POTENTIALLY RELATED TO THE ALLEGED DEFECT. ONE OF THE ALLEGED FIRES IS A DUPLICATE OF A REPORT RECEIVED BY ODI.OF THE FIRE INCIDENTS, 2 OF THE 6 ALLEGED FIRE INCIDENTS OCCURRED AFTER THE REMEDY DETAILED IN THE CUSTOMER SATISFACTION PROGRAM WAS PERFORMED.ONE OF THE VEHICLES WAS TOTALED AS A RESULT OF THE INCIDENT.IT IS UNDETERMINED WHETHER THE INCIDENTS WERE RELATED TO THE ALLEGED DEFECT OR WERE A BY PRODUCT OF THE REPAIR.OF THE OTHER FOUR ALLEGED FIRE INCIDENTS, 1 INCIDENT INVOLVED SMOKE ONLY AND NO VISIBLE FLAMES.BASED ON THE INFORMATION PROVIDED, THE REMAINING 3 FIRE INCIDENTS WERE LOCALIZED EVENTS THAT PRIMARILY INVOLVED DAMAGE TO THE POWER STEERING COMPONENTS AND SURROUNDING WIRING.ALL 3 OF THESE VEHICLES WERE SUBSEQUENTLY REPAIRED.NONE OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS UNATTENDED.ODI IS AWARE OF 1 ADDITIONAL ALLEGED FIRE INCIDENT THAT WAS NOT INCLUDED IN GM'S INFORMATION REQUEST RESPONSE.BASED ON THE CONSUMER'S DESCRIPTION OF THE INCIDENT, THE FIRE WAS QUICKLY EXTINGUISHED BY A FRIEND AND THE VEHICLE WAS SUBSEQUENTLY REPAIRED AT A DEALERSHIP.IN TOTAL ODI IS AWARE OF 6 ALLEGED FIRE INCIDENTS WHERE THE CONSUMER ALLEGED FLAMES WERE VISIBLE.ALL OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS STILL ATTENDED. ODI IS AWARE 1 MINOR CRASH ALLEGED TO BE RELATED TO A POWER STEERING FLUID LEAK.THE CONSUMER ALLEGED A MINOR CRASH OCCURRED AS THE CONSUMER WAS ATTEMPTING TO PULL INTO A DRIVEWAY AND HAD DIFFICULTY NEGOTIATING THE TURN DUE TO EXPERIENCING HIGH POWER STEERING EFFORTS AND STRUCK A SNOW BANK.IN A LETTER DATED SEPTEMBER 21, 2009, GM INFORMED ODI THAT A CUSTOMER SATISFACTION PROGRAM WILL COMMENCE IN DECEMBER OF 2009 FOR THE ENTIRE US. AS A REMEDY THE POWER STEERING HOSE ASSEMBLY FOR VEHICLES WITH V8 ENGINES AND THE POWER STEERING RETURN HOSE AND CLAMPS FOR VEHICLES WITH V6 ENGINES WILL BE REPLACED WITH UPGRADED COMPONENTS.BASED ON THE LOW FREQUENCIES AND MINOR SEVERITIES OF THE ALLEGED FIRE INCIDENTS AND CRASH,NO SAFETY RELATED DEFECT TREND HAS BEEN IDENTIFIED IN THE SUBJECT VEHICLES.GM'S EXPANDED CUSTOMER SATISFACTION PROGRAM WILL PROVIDE FREE REPAIRS TO VEHICLES EXCLUDED FROM THE ORIGINAL CAMPAIGN.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.