Electrical System. Review the 681 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

44 crash reports21 fire reports34 injury reports

Visibility/wiper complaints

4 reports

Clear category filter

110,000 miles · Feb 3, 2015

Visibility/wiper

TL*THE CONTACT OWNS A 2004 CHEVROLET IMPALA. THE CONTACT STATED WHILE DRIVING AT 25 MPH, THE REAR WINDSHIELD EXPLODED. THERE WERE NO INJURIES. THE CONTACT MENTIONED THAT THE FAILURE HAD OCCURRED ONCE BEFORE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS…

Read full complaint

NHTSA ODI #10680810

Mileage unknown · Jun 30, 2014

Electrical SystemVisibility/wiper

I LEASED THE CAR 5/10/2014 AND I HAD SEVEN OCCASIONS WHERE THE CAR SIMPLY WOULDN'T START AND THE CHECK ENGINE LIGHT CAME ON OVER NIGHT ON ITS OWN WHICH CAUSED THE BATTERY TO DIE. *TR

NHTSA ODI #10607219

200,000 miles · Jan 21, 2014

Electrical SystemEngineVisibility/wiper

Read full complaint

ENGINE HESITATES,STALLS, AND SHIFTS HARD. HAD TO REPLACE IGNITION SWITCH AND LOCK CYLINDER, HEAT SENSOR, FUEL CAP, REPROGRAM ANTITHEFT, WATER PUMP, ALWAYS GETTING BUBBLES IN TIRES, GAUGES DNT WORK, PUDDLE ON PASS SIDE, HEATER CORE, 2 SETS OF WARPED ROTORS, TRACTION CONTROL(ABS) KEEPS GOING OFF, FOUND WIRES UNDER HOOD CHAFFED( BY RUBBING ON BELT I BELIEVE)WHICH CAUSED NO START. NEW PROBLEMS ARE LIGHTS ON DASH AND HEAD LIGHTS WILL TURN OFF AT NIGHT WHILE DRIVING, I HAVE A COOLANT LEAK WHICH I THINK ITS DUE TO BLOWN GASKET, AND TONIGHT I AM DRIVING IN FOG AND MY FRONT WINDOW FOGS UP IN 2 SECONDS. I WIPED W HAND AND REALIZED I WAS HEADING TOWARDS A PERSON WALKN. WAY TO DANGEROUS!!!!! I HAVE HAD CAR FOR ONLY 2 YRS. I AM DIVORCED W 3 KIDS AND 1 SPECIAL NEEDS CHILD W LOTS OF APPTS. I NEED A RELIABLE CAR, CANT AFFORD NEW CAR OR A SHOP TO FIX CAR. I HAVE HAD TO BECOME A MECHANIC CAUSE OF THIS CAR AND I HAVE NO TIME FOR THAT, THANK GOD FOR INTERNET, I WNT TAKE KIDS IN CAR AFTER DARK, IT UNRELIABLE AND THATS SAD. PLEASE LOOK INTO ISSUES. *TR

NHTSA ODI #10560740

Mileage unknown · Sep 30, 2013

Electrical SystemExterior LightingVisibility/wiper

Read full complaint

THE HEATER COMPLETELY STOPPED WORKING BUT WAS FINALLY ABLE TO GET THE PASSENGER SIDE TO WORK (IT HAS DUAL TEMP. CONTROLS). THE TURN SIGNALS WORK JUST WHEN THEY WANT TO AND THE WINDSHIELD WIPERS DO THE SAME. THEY JUST STOP WORKING WITH NO WARNING WHAT SO EVER. HAVE TAKEN IT TO SEVERAL DIFFERENT PLACES TO HAVE IT LOOKED AT BUT NOBODY CAN DETERMINE THE CAUSE OF THESE PROBLEMS. HOWEVER, UPON THE RESEARCH I'VE DONE SINCE THESE PROBLEMS BEGAN I'VE FOUND I'M NOT THE ONLY ONE EXPERIENCING THESE SAME ISSUES YET THERE HAS BEEN NO KIND OF RECALLS TO FIX IT. *TR

NHTSA ODI #10546241

Official recalls

15V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Oct 26, 2015

General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.

Consequence & remedy

Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Additional source detail variants (2)

Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Engine And Engine Cooling:engine

Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

15V201000 · Engine And Engine Cooling:engine

Apr 6, 2015

General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.

Consequence & remedy

Consequence: The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.

Remedy: GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1-800-521-7300, Pontiac customer service at 1-800-762-2737 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14574.

14V400000 · Electrical System:ignition

Jul 3, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Consequence & remedy

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

04V287000 · Service Brakes, Hydraulic

Jun 23, 2004

CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH LOWER THAN SPECIFIED TORQUE ON BOTH FRONT BRAKE CALIPER TO STEERING KNUCKLE ATTACHMENT BOLTS. WITH IMPROPER TORQUE, THE CLAMP LOAD AT THE JOINT MAY NOT BE ADEQUATE TO PREVENT MOVEMENT BETWEEN THE CALIPER BRACKET AND KNUCKLE.

Consequence & remedy

Consequence: DEPENDING ON WHETHER ONE OR BOTH BOLTS BACKS OUT OR FRACTURES, THE RESULT CAN BE LOCKING OF THE AFFECTED WHEEL DURING BRAKING AND AN ABRUPT STEERING INPUT IN THE DIRECTION OF THE LOCKED WHEEL, REDUCED BRAKING AND NOISE FROM THE AFFECTED WHEEL, OR SEVERING OF A BRAKE HOSE, INCREASED BRAKE PEDAL TRAVEL, AND REDUCED STEERING CONTROL. REDUCED BRAKING OR STEERING CONTROL COULD CAUSE A CRASH.

Remedy: DEALERS ARE TO TIGHTEN BOTH BOLTS TO THE SPECIFIED TORQUE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT CHEVROLET 1-800-630-2438 OR PONTIAC 1-800-620-7668.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.