TL* THE CONTACT OWNS A 2004 CHEVROLET IMPALA. THE HEADLIGHTS WERE ILLUMINATED AND AS THE LOW BEAMS WERE SWITCHED TO HIGH BEAMS, THE INTERIOR AND EXTERIOR LIGHTS FAILED. AS THE LOW BEAMS WERE ENGAGED, THE INTERIOR AND EXTERIOR LIGHTS CAME BACK ON THE FAILURE RECURRED WHENEVER THE EXTERIOR LIGHTING WAS SWITCHED FROM LOW BEAMS …
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET IMPALA. THE HEADLIGHTS WERE ILLUMINATED AND AS THE LOW BEAMS WERE SWITCHED TO HIGH BEAMS, THE INTERIOR AND EXTERIOR LIGHTS FAILED. AS THE LOW BEAMS WERE ENGAGED, THE INTERIOR AND EXTERIOR LIGHTS CAME BACK ON THE FAILURE RECURRED WHENEVER THE EXTERIOR LIGHTING WAS SWITCHED FROM LOW BEAMS TO HIGH BEAMS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 82,000. UPDATED 05/04/11 *BF UPDATED 05/11/11
NHTSA ODI #10390039
94,700 miles · Dec 22, 2010
Electrical SystemInterior Lighting
THE LIGHT SWITCH, PART NUMBER 10283776, ON MY CAR DEVELOPED AN ELECTRICAL SHORT CIRCUIT AND BURNED OUT THE PUSH-ON ELECTRICAL CONNECTOR FOR THE POWER SUPPLY WIRE TO THE LIGHTS IN THE INSTRUMENT CLUSTER. ENOUGH HEAT WAS GENERATED TO DAMAGE THE PLASTIC CONNECTOR, PART NUMBER 12129431. THE FUSE DID NOT BLOW. I REPLACED THE LIGHT S…
Read full complaint
THE LIGHT SWITCH, PART NUMBER 10283776, ON MY CAR DEVELOPED AN ELECTRICAL SHORT CIRCUIT AND BURNED OUT THE PUSH-ON ELECTRICAL CONNECTOR FOR THE POWER SUPPLY WIRE TO THE LIGHTS IN THE INSTRUMENT CLUSTER. ENOUGH HEAT WAS GENERATED TO DAMAGE THE PLASTIC CONNECTOR, PART NUMBER 12129431. THE FUSE DID NOT BLOW. I REPLACED THE LIGHT SWITCH AND CONNECTOR. *TR
NHTSA ODI #10372021
101,000 miles · Dec 28, 2009
Electrical SystemInterior Lighting
HEADLIGHTS AND INTERIOR LIGHTS WENT OFF WHILE DRIVING. *TR
NHTSA ODI #10297139
Mileage unknown · Feb 12, 2009
Exterior LightingInterior Lighting
MY 2004 IMPALA HAS PROBLEMS WITH IT'S LIGHT/DIMMER SWITCH. ONE HAS TO CLICK THE HANDLE TWICE IN ORDER TO DIM/BRIGHTEN THE LIGHTS. A COUPLE OF TIME THE DASH LIGHTS AND HEADLIGHTS ALL WENT COMPLETELY OUT WHEN I TRIED TO DIM/BRIGHTEN THE LIGHTS. THIS IS A HAZARD. THERE SHOULD BE A RECALL!!!!! *TR
NHTSA ODI #10258456
116,900 miles · Oct 31, 2008
Electrical SystemInterior LightingTires
I BOUGHT A USED 2004 IMPALA IN AUG. 2008 AND BASICALLY SINCE THE FIRST DAY I GOT IT I HAVE HAD PROBLEMS WITH THE SPEEDOMETER. THE DEALER PROMISED TO HAVE IT REPAIRED, BUT HAS YET TO DO SO. THEY KEEP GIVING ME THE RUN AROUND, AND NOW FOR THE PAST MONTH MY STEREO HAS STOPPED WORKING. YESTERDAY MY FUEL GAUGE STARTED GOING HAYWIRE…
Read full complaint
I BOUGHT A USED 2004 IMPALA IN AUG. 2008 AND BASICALLY SINCE THE FIRST DAY I GOT IT I HAVE HAD PROBLEMS WITH THE SPEEDOMETER. THE DEALER PROMISED TO HAVE IT REPAIRED, BUT HAS YET TO DO SO. THEY KEEP GIVING ME THE RUN AROUND, AND NOW FOR THE PAST MONTH MY STEREO HAS STOPPED WORKING. YESTERDAY MY FUEL GAUGE STARTED GOING HAYWIRE. THE INTERIOR LIGHTS ONLY WORK SOMETIMES. THE LOW TIRE PRESSURE WARNING LIGHT WONT RESET. THIS IS A SAFETY PROBLEM THAT NEEDS TO BE RECALLED. BECAUSE OF MY SPEEDOMETER NOT WORKING I ALMOST WENT OFF THE SIDE OF A FREEWAY ON RAMP FROM NOT BEING ABLE TO TELL HOW FAST I WAS GOING. I JUST HAD TO PRAY THAT I HAD SLOWED DOWN ENOUGH TO MAKE THE CURVE. IS SOMEONE GOING TO HAVE TO BE SERIOUSLY INJURED OR DIE BEFORE THERE IS A RECALL ON THIS. I HAVE BEEN TO SEVERAL WEBSITES RESEARCHING THE 2004 IMPALA AND THERE ARE HUNDREDS OF COMPLAINTS ALL SAYING THE SAME THING. ITS TIME THAT GM TAKES RESPONSIBILITY AND DOES SOMETHING ABOUT IT. I AM NOT ABLE TO HAVE MY CAR REPAIRED BECAUSE OF THE COST. IT'S WAY TO EXPENSIVE. I WILL NEVER BUY ANOTHER GM VEHICLE. *TR
NHTSA ODI #10247326
50,000 miles · Nov 8, 2007
Fuel System, GasolineInterior Lighting
TL*THE CONTACT OWNS A 2004 CHEVROLET IMPALA. THE CONTACT SMELLED GASOLINE IN THE VEHICLE. THE DEALER STATED THAT THE FUEL SYSTEM REGULATOR WAS LEAKING. SHE SMELLED GASOLINE FOR OVER A MONTH AND TOOK THE VEHICLE TO A MECHANIC. SHE THOUGHT THE FAILURE HAD BEEN REPAIRED; HOWEVER, THE ODOR REMAINED. THE CONTACT THEN TOOK THE VE…
Read full complaint
TL*THE CONTACT OWNS A 2004 CHEVROLET IMPALA. THE CONTACT SMELLED GASOLINE IN THE VEHICLE. THE DEALER STATED THAT THE FUEL SYSTEM REGULATOR WAS LEAKING. SHE SMELLED GASOLINE FOR OVER A MONTH AND TOOK THE VEHICLE TO A MECHANIC. SHE THOUGHT THE FAILURE HAD BEEN REPAIRED; HOWEVER, THE ODOR REMAINED. THE CONTACT THEN TOOK THE VEHICLE TO A GENERAL MOTORS DEALER AND THEY MADE THE REPAIR. THERE IS A SAFETY RECALL ON THE VEHICLE, BUT THE RECALL NUMBER WAS UNKNOWN. THE POWERTRAIN WAS UNKNOWN AS WELL. THE CURRENT MILEAGE WAS 60,899 AND FAILURE MILEAGE WAS 50,000. *UPDATED 12/12/07 *BF THE DEALER STATED REPAIRED TRUNK LIGHT. UPDATED 12/12/07 *TR
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.
Consequence & remedy
Consequence: The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.
Remedy: GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1-800-521-7300, Pontiac customer service at 1-800-762-2737 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14574.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH LOWER THAN SPECIFIED TORQUE ON BOTH FRONT BRAKE CALIPER TO STEERING KNUCKLE ATTACHMENT BOLTS. WITH IMPROPER TORQUE, THE CLAMP LOAD AT THE JOINT MAY NOT BE ADEQUATE TO PREVENT MOVEMENT BETWEEN THE CALIPER BRACKET AND KNUCKLE.
Consequence & remedy
Consequence: DEPENDING ON WHETHER ONE OR BOTH BOLTS BACKS OUT OR FRACTURES, THE RESULT CAN BE LOCKING OF THE AFFECTED WHEEL DURING BRAKING AND AN ABRUPT STEERING INPUT IN THE DIRECTION OF THE LOCKED WHEEL, REDUCED BRAKING AND NOISE FROM THE AFFECTED WHEEL, OR SEVERING OF A BRAKE HOSE, INCREASED BRAKE PEDAL TRAVEL, AND REDUCED STEERING CONTROL. REDUCED BRAKING OR STEERING CONTROL COULD CAUSE A CRASH.
Remedy: DEALERS ARE TO TIGHTEN BOTH BOLTS TO THE SPECIFIED TORQUE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT CHEVROLET 1-800-630-2438 OR PONTIAC 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2004 Chevrolet Impala Problems, Complaints & Recalls | Skip That Year
Illustration