NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
21 reportsClear category filterMileage unknown · Aug 14, 2024
Structure
I was driving and I went to roll the sunroof down and it ejected itself and came off the whole glass and frame and broke in many pieces on the bridge if there would of been a car or person walking it would of hit them and caused a major accident its going to cosy over$2000.00 to get it replaced whicj I cant afford to do I feel l…
Read full complaint
I was driving and I went to roll the sunroof down and it ejected itself and came off the whole glass and frame and broke in many pieces on the bridge if there would of been a car or person walking it would of hit them and caused a major accident its going to cosy over$2000.00 to get it replaced whicj I cant afford to do I feel like the manufacturer should replace the part it wasnt my fault
NHTSA ODI #11608559
100,000 miles · Jul 3, 2019
Electrical SystemSeatsStructure
CHEVROLET HHR 2009, DOORS MECHANISM. DOOR LATCHES STOP WORKING AND CAN OPEN AT A TURN OR WHILE DRIVING. OR LATCH CAN LOCK YOU IN UNABLE TO GET OUT OF VEHICLE IN AN ACCIDENT AND OR EMERGENCY. I WAS DRIVING HOME AND BACK DOOR FLEW WIDE OPEN I HAD NOT OPENED IT AT ALL BUT WHEN DOORS LOCK AND OPEN THEY ALL DO SO THE BACK LATCH OPENE…
Read full complaint
CHEVROLET HHR 2009, DOORS MECHANISM. DOOR LATCHES STOP WORKING AND CAN OPEN AT A TURN OR WHILE DRIVING. OR LATCH CAN LOCK YOU IN UNABLE TO GET OUT OF VEHICLE IN AN ACCIDENT AND OR EMERGENCY. I WAS DRIVING HOME AND BACK DOOR FLEW WIDE OPEN I HAD NOT OPENED IT AT ALL BUT WHEN DOORS LOCK AND OPEN THEY ALL DO SO THE BACK LATCH OPENED NEVER CLOSING UNAWARE OF THIS THE DOOR FLEW OPEN ALMOST CAUSING AN ACCIDENT AT AN INTERSECTION.
NHTSA ODI #11229155
103,000 miles · Sep 6, 2017
Structure
TL* THE CONTACT OWNS A 2009 CHEVROLET HHR. THE CONTACT NOTICED WATER LEAKING FROM THE ROOF OF THE VEHICLE EACH TIME IT RAINED. THE LOCATION ON THE ROOF WHERE THE WATER WAS ENTERING COULD NOT BE DETERMINED. AS A RESULT, WATER SURROUNDED THE INTERIOR OF THE VEHICLE AROUND THE AIR BAGS AND ON THE FLOORBOARD. THE CONTACT STATED THAT…
Read full complaint
TL* THE CONTACT OWNS A 2009 CHEVROLET HHR. THE CONTACT NOTICED WATER LEAKING FROM THE ROOF OF THE VEHICLE EACH TIME IT RAINED. THE LOCATION ON THE ROOF WHERE THE WATER WAS ENTERING COULD NOT BE DETERMINED. AS A RESULT, WATER SURROUNDED THE INTERIOR OF THE VEHICLE AROUND THE AIR BAGS AND ON THE FLOORBOARD. THE CONTACT STATED THAT THE ELECTRICAL POWER SEATS AND THE POWER WINDOWS FAILED TO OPERATE AND THE WATER SHORTENED OUT THE RADIO. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 103,000.
NHTSA ODI #11021697
46,000 miles · Jan 12, 2017
Electrical SystemStructure
TL* THE CONTACT OWNS A 2009 CHEVROLET HHR. THE CONTACT STATED THAT THE KEY FOB WOULD INADVERTENTLY FUNCTION WHEN SHE ATTEMPTED TO OPEN THE VEHICLE DOORS. ALSO, THE HYDRAULIC FOR THE HATCHBACK WOULD CAUSE IT TO INDEPENDENTLY OPEN. THE CONTACT HAD TO USE A STICK TO KEEP THE HATCHBACK FROM CLOSING. THE VEHICLE WAS NOT DIAGNOSED OR …
Read full complaint
TL* THE CONTACT OWNS A 2009 CHEVROLET HHR. THE CONTACT STATED THAT THE KEY FOB WOULD INADVERTENTLY FUNCTION WHEN SHE ATTEMPTED TO OPEN THE VEHICLE DOORS. ALSO, THE HYDRAULIC FOR THE HATCHBACK WOULD CAUSE IT TO INDEPENDENTLY OPEN. THE CONTACT HAD TO USE A STICK TO KEEP THE HATCHBACK FROM CLOSING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 46,000.
NHTSA ODI #10944643
139,000 miles · Dec 6, 2016
Latches/locks/linkagesStructure
DOOR LATCH - DRIVERS SIDE PASSENGER DOOR - FAILED TO ENGAGE - DOOR FLEW OPEN WHILE DRIVING. *TR
NHTSA ODI #10930246
Mileage unknown · Nov 2, 2015
Structure
TL* THE CONTACT OWNS A 2009 CHEVROLET HHR. THE CONTACT STATED THAT THE STORAGE BIN DOOR WAS BLOCKING HER VIEW. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V444000 (LATCHES, LOCKS, LINKAGES). THE VIN WAS NOT PROVIDED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE.
NHTSA ODI #10787611
30,000 miles · Jul 15, 2015
Structure
TL* THE CONTACT OWNS A 2009 CHEVROLET HHR. WHEN THE CONTACT ATTEMPTED TO OPEN THE VEHICLE WITH THE KEY, THE MASTER KEY OPENER WOULD NOT UNLOCK THE DOORS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND TOWED THE VEHICLE TO THE DEALER. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE OCCU…
Read full complaint
TL* THE CONTACT OWNS A 2009 CHEVROLET HHR. WHEN THE CONTACT ATTEMPTED TO OPEN THE VEHICLE WITH THE KEY, THE MASTER KEY OPENER WOULD NOT UNLOCK THE DOORS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND TOWED THE VEHICLE TO THE DEALER. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE OCCURRED SEVEN OTHER TIMES. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. UPDATED 10/29/15*LJ UPDATED 11/22/2017*CN
NHTSA ODI #10734279
1,000 miles · Feb 24, 2015
Electrical SystemStructure
TL* THE CONTACT OWNS A 2009 CHEVROLET HHR. WHEN THE KEY WAS REMOVED FROM THE IGNITION SWITCH, THE DOOR CHIME ACTIVATED AS IF THE CONTACT WERE EXITING THE VEHICLE. IN ADDITION, THE RADIO REMAINED OPERABLE FOR A SHORT PERIOD OF TIME. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER W…
Read full complaint
TL* THE CONTACT OWNS A 2009 CHEVROLET HHR. WHEN THE KEY WAS REMOVED FROM THE IGNITION SWITCH, THE DOOR CHIME ACTIVATED AS IF THE CONTACT WERE EXITING THE VEHICLE. IN ADDITION, THE RADIO REMAINED OPERABLE FOR A SHORT PERIOD OF TIME. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 1,000.
NHTSA ODI #10690196
99,998 miles · Aug 25, 2014
Electrical SystemStructureSuspension
2009 HHR. WE HAVE HAD SO MUCH TROUBLE WITH IS CAR, I DON'T HAVE THE SPACE TO TELL YOU ALL THE COMPLAINTS. THIS IS THE LATEST HAPPENING; WIFE CALLS ME FROM TOWN, CANT GET OUT OF THE CAR, DOOR WONT OPEN. FINALLY HAD TO CRAWL OVER THE CONSOLE AND EXIT ON THE PASSENGER SIDE. QUIET A FEAT FOR A 260 LB 72 YEAR OLD LADY. NOW I READ ON …
Read full complaint
2009 HHR. WE HAVE HAD SO MUCH TROUBLE WITH IS CAR, I DON'T HAVE THE SPACE TO TELL YOU ALL THE COMPLAINTS. THIS IS THE LATEST HAPPENING; WIFE CALLS ME FROM TOWN, CANT GET OUT OF THE CAR, DOOR WONT OPEN. FINALLY HAD TO CRAWL OVER THE CONSOLE AND EXIT ON THE PASSENGER SIDE. QUIET A FEAT FOR A 260 LB 72 YEAR OLD LADY. NOW I READ ON THE INTERNET THIS IS A ONGOING PROBLEM FOR HHR GOING ALL THE WAY BACK TO 2007. ONE PERSON SAID THE DEALER CHARGED $450.00, BECAUSE THE WHOLE DOOR PANEL HAD TO BE REPLACED. GM IS CERTAINLY AWARE OF THE DEFECTIVE DOOR LOCKS AND LATCHES ON THE HHR. WHEN SOME GETS BURNED ALIVE BECAUSE THEY CANT GET OUT OF THE CAR GM CANNOT SAY THE WERE NOT AWARE OF THE FAILURES OF THE DOOR LATCHES BECAUSE THERE ARE HUNDREDS OF COMPLAINTS ABOUT THE DOORS FAILING TO OPEN. THIS IS JUST THE LATEST PROBLEM WE HAVE WITH THIS CAR.,BUT RIGHT NOW THIS IS THE MOST IMPORTANT THING FOR ME TO REGISTER THIS COMPLAINT IN CASE MY WIFE IS TRAPPED IN THIS CAR AGAIN AND SUSTAINS INJURY. *TR
NHTSA ODI #10628297
40,103 miles · Jul 11, 2014
Structure
PULLED IN TO DRIVEWAY AND WENT TO EXIT VEHICLE. THE PLASTIC DRIVER'S DOOR HANDLE BROKE OFF IN MY HAND. THIS BASICALLY LEFT ME STUCK IN THE VEHICLE UNLESS I CRAWLED OVER THE CENTER CONSOLE OR UNLESS I WAS ABLE TO ROLL DOWN THE ELECTRIC WINDOW, PIVOT IN THE SEAT, AND REACH THE OUTSIDE DOOR HANDLE. OBVIOUSLY IN AN ACCIDENT, OR VEHI…
Read full complaint
PULLED IN TO DRIVEWAY AND WENT TO EXIT VEHICLE. THE PLASTIC DRIVER'S DOOR HANDLE BROKE OFF IN MY HAND. THIS BASICALLY LEFT ME STUCK IN THE VEHICLE UNLESS I CRAWLED OVER THE CENTER CONSOLE OR UNLESS I WAS ABLE TO ROLL DOWN THE ELECTRIC WINDOW, PIVOT IN THE SEAT, AND REACH THE OUTSIDE DOOR HANDLE. OBVIOUSLY IN AN ACCIDENT, OR VEHICLE FIRE, THE EXTRA TIME NEEDED TO EXIT, IF THE DOOR HANDLE BROKE OFF, IS UNACCEPTABLE. A VERY BASIC INTERNET SEARCH SHOWS THAT THIS IS A VERY COMMON PROBLEM WITH THIS VEHICLE MODEL. AN INCONVENIENCE FOR A YOUNGER DRIVER BUT THIS COULD BE A CATASTROPHIC FAILURE FOR AN OLDER, LESS PHYSICAL DRIVER. *TR
NHTSA ODI #10609867
Official recalls
4Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Mar 6, 2009
GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".
Consequence & remedy
Consequence: THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE20011 · Fuel Line Leak
Opened Jul 5, 2020 · Closed Aug 17, 2023
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings; Fuel/propulsion System
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Additional source detail variants (3)
Fuel/propulsion System
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Fuel System, Gasoline
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Illustration