NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
127 reportsClear category filter185,000 miles · Apr 19, 2023
Steering
The contact owns a 2009 Chevrolet HHR. The contact stated that while starting the vehicle, the power steering warning light, the ESC service, the ESC off, and the traction control warning lights illuminated, followed by the loss of power steering functionality. The vehicle was taken to the dealer and the dealer stated that the p…
Read full complaint
The contact owns a 2009 Chevrolet HHR. The contact stated that while starting the vehicle, the power steering warning light, the ESC service, the ESC off, and the traction control warning lights illuminated, followed by the loss of power steering functionality. The vehicle was taken to the dealer and the dealer stated that the power steering assist motor and the power steering assist module needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and the manufacturer stated that the VIN was not included in a recall or TSB. The failure mileage was 185,000.
NHTSA ODI #11517820
Mileage unknown · Jul 17, 2022
Electrical SystemSteeringSuspension
When driving my 2009 HHR the steering wheel shakes & vibrate at different intervals. Usually while slowing down to a stop & sometimes after during high speeds. Recently the noise it made was frightening. I had to use my emergency flashers & drive 50 mi per hr. on the freeway to arrive home safely. I took my car to Mark Chevrolet…
Read full complaint
When driving my 2009 HHR the steering wheel shakes & vibrate at different intervals. Usually while slowing down to a stop & sometimes after during high speeds. Recently the noise it made was frightening. I had to use my emergency flashers & drive 50 mi per hr. on the freeway to arrive home safely. I took my car to Mark Chevrolet & reported it on 08/02/2021. The car's mileage was 133344. The car is not an everyday vehicle that is driven often. I received the car on 08/17/2021 after the steering column & shaft were replaced along with resurfacing front brake rotors & rear brake job. On August 18, 2021 while driving on the freeway I went to blow my horn at a hazardous situation & discovered none of the steering wheels controls were working, horn & etc. I immediately returned my car to Mark Chevrolet & reported their negligence & how they had risk my life to release the car without these functions working. They supposedly corrected the problem. On 07/05/2022 I had to return my car to Mark Chevrolet because I was experiencing the identical problem with my steering wheel vibrating & make noise. My cars mileage was only 137641 less than a year later with just 4,297 miles driven. They claimed to have tightened something up in the column & returned my car on 07/12/2022. As I was driving on 07/16/2022 again the steering wheel started vibrating & making strange loud noises. I felt so unsafe & tried to make it home safely driving at a reduced speed. I plan to return the car this week back to Mark Chevrolet and am asking for support to rectify this situation. I understand there was a recall on Chevrolet HHR 2009 Steering Electric Power Assist System. I don't know if this issue is related to that. I never received communication from General Motors stating that my vehicle was affected but apparently there is a problem. Please Help!
NHTSA ODI #11474383
Mileage unknown · Mar 9, 2022
Fuel/propulsion SystemSteeringVisibility/wiper
Something with steering and ESC problem unknown for now. The fuel line leaked and needed replacement. The drivers wiper is in visibility
NHTSA ODI #11455791
105,000 miles · Apr 8, 2021
Electrical SystemSteering
MY STEERING WHEEL BEGINS TO VIOLENTLY SHAKE, ONSET ABOUT 10 MINUTES INTO DRIVING, SPEEDING UP OR BRAKING HAS NO EFFECT ON THE FREQUENCY OR LEVEL OF SHAKE. MY STEERING WHEEL WILL BE NORMAL, ABOUT 10 MINUTES INTO THE DRIVE, GOING THE SAME SPEED WILL BEGIN TO SHAKE. I CAN STOP AND PARK THE CAR, RESTART IT, WILL NOT SHAKE UNTIL I A…
Read full complaint
MY STEERING WHEEL BEGINS TO VIOLENTLY SHAKE, ONSET ABOUT 10 MINUTES INTO DRIVING, SPEEDING UP OR BRAKING HAS NO EFFECT ON THE FREQUENCY OR LEVEL OF SHAKE. MY STEERING WHEEL WILL BE NORMAL, ABOUT 10 MINUTES INTO THE DRIVE, GOING THE SAME SPEED WILL BEGIN TO SHAKE. I CAN STOP AND PARK THE CAR, RESTART IT, WILL NOT SHAKE UNTIL I AM DRIVING AGAIN ABOUT 10 MINUTES INTO THE DRIVE. WHILE SHAKING, IT BECOMES VERY DIFFICULT TO MOVE THE STEERING WHEEL EVEN TO GET INTO THE NEXT LANE. THIS HAS HAPPENED WHILE CITY DRIVING, I AM TOO AFRAID TO TAKE IT ON THE HIGHWAY OR GO OVER 40 MPH AS I FEEL LIKE I HAVE NO CONTROL OF THE VEHICLE WHEN THE STEERING WHEEL SHAKES.
NHTSA ODI #11407079
189,000 miles · Mar 18, 2021
Electrical SystemSteering
MY CAR'S POWER STEERING HAS DANGEROUSLY DISAPPEARED WHILE I WAS DRIVING ON THE HIGHWAY. THE POWER STEERING CAME ON ON THE DASHBOARD AND I HAD TO STIR THE CAR WITH SO MUCH FORCE TO GET OFF THE HIGHWAY. I HAD MY 10-YEAR-OLD SON WITH ME ON HIS WAY TO SCHOOL. NO ONE KNOWS WHY THIS HAPPENED AND I CAN'T DRIVE IT WITH A 10-YEAR-OLD BOY…
Read full complaint
MY CAR'S POWER STEERING HAS DANGEROUSLY DISAPPEARED WHILE I WAS DRIVING ON THE HIGHWAY. THE POWER STEERING CAME ON ON THE DASHBOARD AND I HAD TO STIR THE CAR WITH SO MUCH FORCE TO GET OFF THE HIGHWAY. I HAD MY 10-YEAR-OLD SON WITH ME ON HIS WAY TO SCHOOL. NO ONE KNOWS WHY THIS HAPPENED AND I CAN'T DRIVE IT WITH A 10-YEAR-OLD BOY WHO I HAVE TO GET TO SCHOOL AND MYSELF AND MY WIFE TO WORK. MECHANIC AFTER MECHANIC NO ONE CAN TELL WHY THE POWER STEERING WONT WORK. PLEASE HELP!
NHTSA ODI #11403627
141,000 miles · Jan 12, 2021
Air BagsSteering
TL* THE CONTACT OWNS A 2009 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE AIR BAG MESSAGE DISPLAYED ON THE INSTRUMENT PANEL BEFORE THE POWER STEERING MALFUNCTIONED CAUSING THE STEERING WHEEL TO BECOME VERY DIFFICULT TO TURN IN EITHER DIRECTION. THE VEHICLE THEN STARTED TO STALL. AFTER TURNING OFF AN…
Read full complaint
TL* THE CONTACT OWNS A 2009 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE AIR BAG MESSAGE DISPLAYED ON THE INSTRUMENT PANEL BEFORE THE POWER STEERING MALFUNCTIONED CAUSING THE STEERING WHEEL TO BECOME VERY DIFFICULT TO TURN IN EITHER DIRECTION. THE VEHICLE THEN STARTED TO STALL. AFTER TURNING OFF AND RESTARTING THE VEHICLE, THE VEHICLE OPERATED NORMALLY. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE CAUSE OF THE FAILURE WAS NOT YET DETERMINED. THE LOCAL DEALER WADE CHEVROLET LOCATED AT 1670 HILTON DR, ST. GEORGE, UT 84770 WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 141,000.
NHTSA ODI #11387680
130,000 miles · Jun 17, 2020
Steering
TL* THE CONTACT OWNS A 2009 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE STEERING WHEEL WAS LOOSE. THE CONTACT STATED THAT AFTER MAKING A TURN, THE STEERING WHEEL FAILED TO RETURN TO THE CENTER. THE CONTACT MANUALLY RETURNED THE WHEEL BACK TO CENTER. THE VEHICLE WAS PREVIOUSLY REPAIRED AT SOU…
Read full complaint
TL* THE CONTACT OWNS A 2009 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE STEERING WHEEL WAS LOOSE. THE CONTACT STATED THAT AFTER MAKING A TURN, THE STEERING WHEEL FAILED TO RETURN TO THE CENTER. THE CONTACT MANUALLY RETURNED THE WHEEL BACK TO CENTER. THE VEHICLE WAS PREVIOUSLY REPAIRED AT SOUTH HAVEN CHEVROLET BUICK GMC (10159 M-140 SOUTH HAVEN MI 49090, (269)906-9558), AND REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE CONTACT WAS INFORMED THAT THE RECALL REPAIR WAS A ONE TIME FREE REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.
NHTSA ODI #11329416
69,000 miles · Feb 17, 2020
Steering
THE VEHICLE HAS STARTED LOSING POWER STEERING AT LOW SPEEDS INTERMITTENTLY. IN RESEARCHING THE PROBLEM, A RECALL ON THE ELECTRONIC POWER STEERING FOR THIS 2009 HHR WAS FOUND. IN ADDITION, I FOUND THAT GM ISSUED A BULLETIN (14119) UNDER RECALL N140115, STATING THAT FOR MODEL YEAR 2006-2008 AND EARLY PRODUCTION 2009 HHRS, TO PROVI…
Read full complaint
THE VEHICLE HAS STARTED LOSING POWER STEERING AT LOW SPEEDS INTERMITTENTLY. IN RESEARCHING THE PROBLEM, A RECALL ON THE ELECTRONIC POWER STEERING FOR THIS 2009 HHR WAS FOUND. IN ADDITION, I FOUND THAT GM ISSUED A BULLETIN (14119) UNDER RECALL N140115, STATING THAT FOR MODEL YEAR 2006-2008 AND EARLY PRODUCTION 2009 HHRS, TO PROVIDE EPS MOTOR REPLACEMENT FOR THE LIFE OF THE VEHICLE. SINCE I HAVE NOT HAD THIS VEHICLE SINCE 2009, I CONTACTED THE DEALERSHIP TO LOOK UP THE RECALL HISTORY AND FOUND THE EPS MOTOR WAS REPLACED ONCE ALREADY. HOWEVER, THIS LATE 2008 PRODUCTION/MID-2009 DELIVERY HHR IS LOSING POWER STEERING AT LOW SPEEDS AGAIN. WHILE MYSELF AND TEENAGE DAUGHTER HAVE DRIVEN IT ON THE ROAD. THE DEALERSHIP COULD GET NO DIAGNOSTIC CODE OF THIS AND HAS TOLD ME THERE IS NO OPEN RECALL ON THIS VEHICLE AND WE ARE RESPONSIBLE FOR PAYING FOR THE MOTOR REPLACEMENT. I AM VERY DISTURBED THAT THIS PROBLEM 1. GENERATES NO CODE, 2. IS BEING UNACKNOWLEDGED BY GM, AND 3. SEEMS TO BE AN ON-GOING THREAT TO SAFETY FOR MANY HHR DRIVERS. GM HAS MADE A MISTAKE IN NOT INCLUDING MY MAKE/MODEL (OR SO IT SEEMS) IN THE BULLETIN PERTAINING TO REPLACING THE EPS MOTOR FOR LIFE AND IS FAILING TO ACKNOWLEDGE THAT THEY MAY HAVE ADDITIONAL VEHICLES ON THE ROAD NEEDING TO BE SERVICED, ESPECIALLY WHEN THE DRIVER STATES THERE IS A PROBLEM POSING A SERIOUS SAFETY CONCERN. NOTE, THE PRODUCTION OF MY HHR BEING IN 2008, DELIVERED IN 2009 AND FAILURE BY GM TO ACKNOWLEDGE UNDER BULLETIN 14119.
NHTSA ODI #11309656
Mileage unknown · Oct 18, 2019
Seat BeltsService BrakesSteering
I HAVE HAD MY HHR 2009 FOR A YEAR NOW AND I'VE CHANGED THE BRAKES TWICE WITHIN TWO WEEKS..THE FIRST SET WAS STILL NEW BUT IT KEPT MAKING GRINDING NOISES AND ROARING NOISES WHEN I PRESS DOWN ON BRAKES... MY STEERING WHEEL SHAKES LIKE CRAZY I REALLY DO LOVE MY CAR AND I WANNA GET THE PROBLEM RESOLVED ASAP.
NHTSA ODI #11269354
100,000 miles · Oct 15, 2019
SteeringSuspension
HAVE OWNED 1- 2008 & 1-2009 HHR SS WITH 2.0L TURBO CHARGER AND MANUAL 5 SPEED TRANS,AND RIGHT AT 100,000 MILES THE FRONT SUSPENSION MAKES A HORRENDOUS NOISE LIKE THE FRONT SUSPENSION IS GOING FALL OUT FROM UNDER IT WHEN HITTING SMALL BUMPS . ALSO IF YOU MOVE THE STEERING WHEEL BACK AND FORTH IT WILL MAKE A VERY SIMILAR NOISE. T…
Read full complaint
HAVE OWNED 1- 2008 & 1-2009 HHR SS WITH 2.0L TURBO CHARGER AND MANUAL 5 SPEED TRANS,AND RIGHT AT 100,000 MILES THE FRONT SUSPENSION MAKES A HORRENDOUS NOISE LIKE THE FRONT SUSPENSION IS GOING FALL OUT FROM UNDER IT WHEN HITTING SMALL BUMPS . ALSO IF YOU MOVE THE STEERING WHEEL BACK AND FORTH IT WILL MAKE A VERY SIMILAR NOISE. THE 2008 GOT TOTALED FROM A LADY PULLING OUT IN FRONT OF ME HAD CHANGED THE SWAY BAR END LINKS PRIOR TO ACCIDENT MADE NO CHANGE. MEETING THE SAME MILEAGE ON THE 2009 AND ALREADY MAKING THE SAME EXACT NOISE . ALMOST AFRAID TO DRIVE IT ON THE FREEWAY FOR FEARING OF LOOSING THE STEERING AND KILLING ANYONE. I HAVE READ UP ON THIS CONCERN AND HAVE SEEN ALOT OF PEOPLE WITH SAME NOISE AND HAVE SPENT 1,000S OF DOLLARS AND NOISE STILL THERE. YOU WOULD THINK SOMEONE WOULD HAVE BEEN ABLE TO CORRECT THE PROBLEM BEFORE THERE ARE DEATHS INVOLVED BUT EVEN THE DEALERSHIP CAN'T FIND THE FIX. REALLY FEEL LIKE THIS SHOULD BE INVESTIGATED AT ONCE, CAN'T BELIEVE THAT THERE HASN'T BEEN A RECALL DONE YET.
NHTSA ODI #11268797
Official recalls
4Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Mar 6, 2009
GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".
Consequence & remedy
Consequence: THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE20011 · Fuel Line Leak
Opened Jul 5, 2020 · Closed Aug 17, 2023
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings; Fuel/propulsion System
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Additional source detail variants (3)
Fuel/propulsion System
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Fuel System, Gasoline
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Illustration