IllustrationAFTER THE VEHICLE HAD BEEN DRIVEN CONSUMER WOULD RETURN TO RESTART IT FROM MINUTES TO HOURS, AND VEHICLE WOULD NOT START. THIS HAPPENED INTERMITTENTLY, ABOUT SIX TIMES. AT THIS TIME NEITHER THE MANUFACTURER OR THE DEALERSHIP HAVE BEEN INFORMED. *AK
1999 Chevrolet Express
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Express years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 68 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports2 fire reports2 injury reports
What owners actually said
68 reportsTHE DOME LIGHT WENT OUT SUDDENLY, ALL BACK WIRES WERE MELTED. DEALER NOTIFIED.*AK
WIRING HARNESS UNDER FUSE BLOCK AT DRIVERS FEET NOT PROPERLY SECURED BY S-CLIP AND WIRES RUB AGAINST ACCESS HOLE IN SHEET METAL CAUSING SHORT IN TURN SIGNAL OR 4-WAY FLASHER CIRCUIT CAUSING FIRE. VEHICLE IS MARK III CONVERSION. *NLM
WHILE DRIVING BACK FROM A FIELD TRIP IN OUR 15-PASSENGER VAN FULL OF CHILDREN, THE STEELTEX R4S TIRE HAD A BLOWOUT AND TREAD SEPARATION. BY SOME SORT OF MIRACLE OUR DRIVER, GOING 55 MPH ON THE HIGHWAY, MANAGE TO KEEP CONTROL OF THE VEHICLE. THANKFULLY ALL THE CHILDREN ARE SAFE,BUT I AM EXTREMELY CONCERNED THAT I WAS UNAWARE OF…
Read full complaint
WHILE DRIVING BACK FROM A FIELD TRIP IN OUR 15-PASSENGER VAN FULL OF CHILDREN, THE STEELTEX R4S TIRE HAD A BLOWOUT AND TREAD SEPARATION. BY SOME SORT OF MIRACLE OUR DRIVER, GOING 55 MPH ON THE HIGHWAY, MANAGE TO KEEP CONTROL OF THE VEHICLE. THANKFULLY ALL THE CHILDREN ARE SAFE,BUT I AM EXTREMELY CONCERNED THAT I WAS UNAWARE OF OTHER COMPLAINTS REGARDING THESE TIRES. I WOULD HAVE NEVER LET THE CHILDREN RIDE IN THE VAN WITH THOSE TIRES IF I KNEW THE PROBLEMS WITH THEM. THERE WAS SOME DAMAGE TO THE DRIVE SHAFT DUE TO THE BLOWOUT, BUT THE VEHICLE IS STILL IN THE REPAIR, SO I DON'T KNOW HOW THE DAMAGE OCCURRED. *NLM
STEERING WHEEL SHAKES WHEN BRAKE ARE APPLIED. THIRD SET OF FRONT BRAKES IN 65,000 MILES. ROTORS TURNED EACH TIME. *NLM
THE SIDE DOOR DID NOT UNLOCK FROM INSIDE OR OUTSIDE DUE TO DAMAGED HINGE. *JB
THE RIGHT REAR TIRE EXPERIENCED TREAD SEPARATION. WHICH CAUSED THE TIRE TO BLOW OUT.*JB
THE CATALYTIC CONVERTER FAILED. *JB THIS WAS THE CONVERTER PLACED IN THIS VEHICLE. THE CONSUMER WAS TEST DRIVING WHEN HE FELT A SLUGGISHNESS AND HEARD A RATTLING NOISE WHICH OCCURRED UPON ACCELERATION AND IN THE EXHAUST. AFTER THE VEHICLE WAS REPAIRED, THE CONSUMER FELT THE SAME PROBLEM(S) AGAIN. THE DEALER STATED THAT THE …
Read full complaint
THE CATALYTIC CONVERTER FAILED. *JB THIS WAS THE CONVERTER PLACED IN THIS VEHICLE. THE CONSUMER WAS TEST DRIVING WHEN HE FELT A SLUGGISHNESS AND HEARD A RATTLING NOISE WHICH OCCURRED UPON ACCELERATION AND IN THE EXHAUST. AFTER THE VEHICLE WAS REPAIRED, THE CONSUMER FELT THE SAME PROBLEM(S) AGAIN. THE DEALER STATED THAT THE PART WAS DEFECTIVE. THE CONSUMER HAD TAKEN THE VEHICLE TO TWO OTHER DEALERS AND WAS TOLD THAT THE CONVERTER WAS NEVER CHANGED, ONLY THE DOUGHNUTS WERE REPLACED. THE CONVERTER WAS REPLACED BY LARRY H. MILLER. ALSO, THE BRAKES HAD BECOME INOPERATIVE AND WERE REPLACED. SCC
HINGES ON REAR SIDE DOOR STICKS. BAD DESIGN. UNABLE TO GREASE THOROUGHLY. I CAN ONLY IMAGINE THAT SOMEWHERE DOWN THE ROAD THIS WILL LOCK AND THE HINGE WILL DETACH FROM THE SIDE OF THE VAN. THIS IS THE SECOND OF THE TWO SIDE DOORS THE ONE CLOSER TO THE REAR OF THE VAN.
POSITIVE BATTERY BOLT CAME OUT OF BATTERY CAUSING LEAK AND RENDERING BATTERY USELESS. SOUNDS LIKE A MAJOR FACTORY DEFECT. (NOT CABLE FROM BOLT - BUT BOLT OUT OF BATTERY)
Official recalls
100V085000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Mar 16, 2000
VEHICLE DESCRIPTION: PASSENGER VANS EQUIPPED WITH A BRAKE WARNING INDICATOR. SOME OF THESE VEHICLES HAVE A POWER STEERING COOLER HOSE THAT CAN SEPARATE FROM THE POWER BRAKE BOOSTER FLUID FLOW SWITCH ASSEMBLY.
Consequence & remedy
Consequence: IF THIS OCCURS, POWER STEERING FLUID COULD FLOW ONTO HOT ENGINE PARTS AND AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT FOR THREE SCREW CLAMPS TO THE POWER STEERING HOSE JOINTS. IF THE CLAMPS ARE NOT THE SCREW TYPE, DEALERS WILL REPLACE THE CLAMPS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.