NHTSA owner reports · September 18, 2026 snapshot.
Wheels complaints
12 reportsClear category filter23,200 miles · Sep 27, 2015
Wheels
THE MORNING AFTER COMING BACK FROM A TRIP I WENT DOWN TO GET IN MY COLBALT AND FOUND MY LEFT FRONT TIRE FLAT. I GOT MY MANUAL OUT TO READ HOW TO CHANGE THE TIRE AND CHANGED IT. WE NOTICED THE SIZE DIFFERENCE IN THE TIRES RIGHT AWAY, REGULAR TIRE IS P205/55R16 H, THE SPARE IS A T115/70D15 M. THESE ARE THE ORIGINAL TIRES THAT CH…
Read full complaint
THE MORNING AFTER COMING BACK FROM A TRIP I WENT DOWN TO GET IN MY COLBALT AND FOUND MY LEFT FRONT TIRE FLAT. I GOT MY MANUAL OUT TO READ HOW TO CHANGE THE TIRE AND CHANGED IT. WE NOTICED THE SIZE DIFFERENCE IN THE TIRES RIGHT AWAY, REGULAR TIRE IS P205/55R16 H, THE SPARE IS A T115/70D15 M. THESE ARE THE ORIGINAL TIRES THAT CHEVROLET PUT ON THE CAR. THE MANUAL SAID WE COULD GO NORMAL SPEED. I DROVE A BLOCK TO GET THE TIRE FIXED AND TURNED AROUND AND WENT BACK HOME. THE CAR DIPPED HORRIBLE AND DRAGGED WHEN I PULLED BACK INTO MY DRIVE WAY. IT ALSO MADE RUBBING SOUNDS. IT DID NOT FILL SAFE TO DRIVE. WE TOOK THE TIRE IN AND HAD IT FIXED WITHOUT THE CAR, BROUGHT IT HOME AND PUT IT BACK ON CAR. I HAVE BEEN IN CONTACT WITH CHEVROLET SINCE THEN TO SEE IF IT WAS AN ERROR ON THE SPARE. THEY HAVE TOLD ME THAT IT IS THE RIGHT SPARE, ALTHOUGH A COUPLE OF THE PEOPLE THAT I HAVE TALKED TO THOUGHT IT WAS BAD TO HAVE A 15 INCH SPARE WITH 16 INCH TIRES. THEY ALSO TOLD ME THAT WHAT I NEED TO DO IS IF THE FLAT IS ON THE FRONT I'M SUPPOSE TO CHANGE TWO TIRES. THEY TOLD ME TO PUT A BACK TIRE ON THE FRONT AND THE SPARE ON THE BACK, WHICH IS NOT THE DIRECTION IN THE MANUAL. THEY TOLD ME I CAN GO 50 MPH AND GET THE TIRE FIXED AS SOON AS POSSIBLE. SO NOW OUT ON A BUSY HIGHWAY THEY WANT ME TO CHANGE TWO TIRES AND HAVE THE BACK OF MY CAR DIP HORRIBLY. I FEEL THIS SPARE IS UNSAFE BECAUSE IT IS SMALLER THEN THE TIRES IT IS REPLACING. IT MAKES THE CAR TILT SO YOU CAN'T DRIVE AT SAFE SPEEDS NOT TO SAY THE DAMAGE YOU CAN DO TO YOUR CAR. I LEAVE IN A RURAL AREA AND SOME OF THE ROADS DON'T HAVE ENOUGH SHOULDER TO CHANGE ONE SPARE LET ALONE TWO.
NHTSA ODI #10777934
67,642 miles · Jul 14, 2015
Wheels
WHEEL BEARINGS ON THE LEFT FRONT WENT OUT IN FEB, 2012 THEN IN JULY, 2015 THE RIGHT ONE WENT OUT. IN ALL OF OUR OTHER CARS WE HAVE OWNED WE NEVER HAD TO REPLACE A WHEEL BEARING LET ALONE TWO SO WE ASSUME THERE MUST BE A DEFECT.
NHTSA ODI #10734079
119,000 miles · Jan 31, 2015
Fuel/propulsion SystemWheels
I BEGAN TO SMELL GAS AFTER EXITING THE VEHICLE. I TRACED THE SMELL TO AN APPARENT LEAK COMING FROM THE TOP OF THE TANK WHERE THE LINES FROM THE FUEL FILTER ARE ROUTED OVER THE TOP OF THE TANK. I DISCOVERED THE RECALL FOR FUEL PUMP PLASTIC PART FAILURES IN WARM WEATHER STATES, ALSO 2009 COBALT, BUT, GEORGIA IS NOT LISTED (I'LL …
Read full complaint
I BEGAN TO SMELL GAS AFTER EXITING THE VEHICLE. I TRACED THE SMELL TO AN APPARENT LEAK COMING FROM THE TOP OF THE TANK WHERE THE LINES FROM THE FUEL FILTER ARE ROUTED OVER THE TOP OF THE TANK. I DISCOVERED THE RECALL FOR FUEL PUMP PLASTIC PART FAILURES IN WARM WEATHER STATES, ALSO 2009 COBALT, BUT, GEORGIA IS NOT LISTED (I'LL TELL YOU IT IS A WARM WEATHER STATE). ALSO, IN REGARDS TO ANOTHER INDIVIDUAL'S COMPLAINT NHTSA ID NUMBER: 10668977, I DISCOVERED MY TPMS WERE BACKWARDS ABOUT THREE YEARS AGO WHEN I HAD AN UNEXPECTED FLAT. THE LOW PRESSURE INDICATED BY THE TPMS DIRECTED ME TO THE WRONG TIRE. ONE OF THE TPMS STOPPED WORKING WITHIN DAYS OF DRIVING THE CAR OFF THE LOT. OTHER ISSUES: 1) MULTIPLE TIMES I HAVE PLACED A SMALL ITEM LIKE A PHONE IN THE PASSENGER SEAT AND THE PASSENGER AIR BAG TURNS OFF - SEEMS HYPER SENSITIVE, NOT NEARLY THE WEIGHT OF AN INFANT 2) MY FRONT SPEAKERS DON'T PLAY UNLESS THE WEATHER IS WARM (WIRING HARNESS/CONNECTORS?) *TR
NHTSA ODI #10680187
Mileage unknown · Dec 8, 2014
TiresWheels
MY TIRES CONSISTENTLY LOSE AIR AT AN ACCELERATED RATE. DESPITE REPLACING ALL TIRES, THIS PROBLEM PERSISTS. I HAVE BEEN TOLD THAT REPLACING THE RIMS WILL RESOLVE THE ISSUE. I FEEL THAT THIS RECOMMENDATION IS PREMATURE GIVEN THE AGE OF THE CAR. THE RIMS SHOULD NOT HAVE CORRODED SO MUCH TO THE POINT WHERE I HAVE TO REPLACE THEM AFT…
Read full complaint
MY TIRES CONSISTENTLY LOSE AIR AT AN ACCELERATED RATE. DESPITE REPLACING ALL TIRES, THIS PROBLEM PERSISTS. I HAVE BEEN TOLD THAT REPLACING THE RIMS WILL RESOLVE THE ISSUE. I FEEL THAT THIS RECOMMENDATION IS PREMATURE GIVEN THE AGE OF THE CAR. THE RIMS SHOULD NOT HAVE CORRODED SO MUCH TO THE POINT WHERE I HAVE TO REPLACE THEM AFTER 5 YEARS. I HAVE TO PUMP AIR INTO MY TIRES 2 TIMES A WEEK TO MAINTAIN A SAFE PRESSURE FOR DRIVING. *TR
NHTSA ODI #10663003
100,000 miles · Oct 24, 2014
Electrical SystemSteeringWheelsCrash
I WAS ON MY WAY HOME AND IT WAS RAINING ON THE EXPRESSWAY BUT BY THE TIME I GOT TO THE CITY I LIVE IT HAD STOP. I WAS EXITING THE EXPRESSWAY AND WAS TURNING A LEFT ON THE STREET I LIVE ON. I HAD MADE MY TURN AT ABOUT 30 MPH AND AFTER I HAD MADE MY TURN THE CAR WAS STRAIGHT FOR AWHILE THEN ALL THE SUDDEN THE CAR ACTED UP AND THE …
Read full complaint
I WAS ON MY WAY HOME AND IT WAS RAINING ON THE EXPRESSWAY BUT BY THE TIME I GOT TO THE CITY I LIVE IT HAD STOP. I WAS EXITING THE EXPRESSWAY AND WAS TURNING A LEFT ON THE STREET I LIVE ON. I HAD MADE MY TURN AT ABOUT 30 MPH AND AFTER I HAD MADE MY TURN THE CAR WAS STRAIGHT FOR AWHILE THEN ALL THE SUDDEN THE CAR ACTED UP AND THE STEERING WHEEL OR THE WHEELS OR SOMETHING HAPPEN THAT MADE MY CAR MAKE A SHARP U-TURN GOING IN FRONT OF ONGOING TRAFFIC. MY CAR WENT STRAIGHT IN FRONT OF A CAR AND SHE DIDN'T HAVE TIME TO STOP SO SHE HIT ME AND WE BOTH WENT ONTO THE ISLAND. I HAVE NO IDEA WHAT HAPPENED BUT LUCKILY WE WERE BOTH GOING SLOW THAT NONE OF US WERE HURT BUT OUR CARS WERE IN BAD CONDITIONS. I'M LOOKING AT 3,000 DAMAGE ON MY CAR, AND PROBABLY 4,000 DAMAGE TO HER CAR. I WANT TO SAY IT WAS BC OF THE RAIN, BUT THE ROAD WASN'T WET AND I JUST GOT NEW TIRES AND JUST GOT A OIL CHANGE. I MAINTAIN MY CAR VERY WELL SO I HAVE NO IDEA WHY THAT WOULD HAPPEN. *TR
NHTSA ODI #10649589
87,507 miles · Sep 8, 2014
Wheels
TL* THE CONTACT OWNS A 2009 CHEVROLET COBALT. THE CONTACT STATED THAT THE LUG NUTS ON THE FRONT DRIVER SIDE, FRONT PASSENGER SIDE, AND REAR PASSENGER SIDE SEPARATED WHEN THE WHEELS WERE BEING REPLACED. AN INDEPENDENT MECHANIC REPAIRED THE FRONT PASSENGER SIDE LUG NUT, BUT THEY CONTINUED TO DETACH ON THE OTHER WHEELS. THE DEALER …
Read full complaint
TL* THE CONTACT OWNS A 2009 CHEVROLET COBALT. THE CONTACT STATED THAT THE LUG NUTS ON THE FRONT DRIVER SIDE, FRONT PASSENGER SIDE, AND REAR PASSENGER SIDE SEPARATED WHEN THE WHEELS WERE BEING REPLACED. AN INDEPENDENT MECHANIC REPAIRED THE FRONT PASSENGER SIDE LUG NUT, BUT THEY CONTINUED TO DETACH ON THE OTHER WHEELS. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 87,507.
NHTSA ODI #10631558
41,000 miles · May 5, 2014
Electrical SystemPower TrainSteering
VEHICLE WAS BEING TOWED BEHIND CLASS A MOTORHOME. KEY WAS IN THE ACCESSORY POSITION; TRANSMISSION (AUTOMATIC) WAS IN THE NEUTRAL POSITION; FUSE BLOCK:8 (IGNITION SWITCH, PASS-KEY III+) WAS REMOVED TO PREVENT BATTERY DRAIN; PER VEHICLE MANUAL FOR DINGHY TOWING. TRAVELING ON INTERSTATE 45; 95 MILES SOUTH OF DALLAS, TX. NOTHING…
Read full complaint
VEHICLE WAS BEING TOWED BEHIND CLASS A MOTORHOME. KEY WAS IN THE ACCESSORY POSITION; TRANSMISSION (AUTOMATIC) WAS IN THE NEUTRAL POSITION; FUSE BLOCK:8 (IGNITION SWITCH, PASS-KEY III+) WAS REMOVED TO PREVENT BATTERY DRAIN; PER VEHICLE MANUAL FOR DINGHY TOWING. TRAVELING ON INTERSTATE 45; 95 MILES SOUTH OF DALLAS, TX. NOTHING WAS HIT WHEN TRAVELING. BOTH FRONT TIRES BLEW OUT, SUBSEQUENTLY RUINING BOTH FRONT TIRES AND WHEELS. THERE IS NO APPARENT REASON WHY THIS HAPPENED. WAS WONDERING IF THIS MAY BE CONNECTED WITH CURRENT SAFETY RECALL ON IGNITION PROBLEM ON CHEVROLET COBALT. THE KEY CHAIN HAD THREE KEYS AND THE KEY FOB ATTACHED. *TR
NHTSA ODI #10586671
111,766 miles · Mar 13, 2014
Service Brakes, HydraulicSteeringWheelsCrash
AS I WAS DRIVING DOWN THE STREET TO TURN INTO MY PARKING LOT I STARTED TURNING THE WHEEL LEFT WHEN I TURNED MY STEERING WHEEL AND BRAKES LOCKED UP AND DROVE OVER THE CURB OF MY APARTMENT COMPLEX CAUSING MY WHOLE RIGHT SIDE OF MY CAR $1300.00 WORTH OF DAMAGE THIS IS THE SECOND TIME THIS HAS HAPPENED TO ME FIRST TIME NO DAMAGE WAS…
Read full complaint
AS I WAS DRIVING DOWN THE STREET TO TURN INTO MY PARKING LOT I STARTED TURNING THE WHEEL LEFT WHEN I TURNED MY STEERING WHEEL AND BRAKES LOCKED UP AND DROVE OVER THE CURB OF MY APARTMENT COMPLEX CAUSING MY WHOLE RIGHT SIDE OF MY CAR $1300.00 WORTH OF DAMAGE THIS IS THE SECOND TIME THIS HAS HAPPENED TO ME FIRST TIME NO DAMAGE WAS DONE THAT WAS BACK IN OCTOBER. *TR
NHTSA ODI #10569070
47,300 miles · Aug 8, 2013
Electrical SystemSteeringWheels
WHEN I DRIVE MY CAR OVER 60 I GET A SWAY SIDE TO SIDE AND I FEEL LIKE ITS GOING TO SWAY IN TO ANOTHER CAR WHEN I GO BY THEM. I HAD IT IN A CHEVY DEALERSHIP TO HAVE IT FIXED AND THEY DID NOTHING BUT PUT A PULL IN THE CAR AND IT SILL SWAYS. I THINK IT HAS TO DO WITH THE RACK IN THE CAR AND OR THE ELECTRICAL STEERING IN THE CAR. TH…
Read full complaint
WHEN I DRIVE MY CAR OVER 60 I GET A SWAY SIDE TO SIDE AND I FEEL LIKE ITS GOING TO SWAY IN TO ANOTHER CAR WHEN I GO BY THEM. I HAD IT IN A CHEVY DEALERSHIP TO HAVE IT FIXED AND THEY DID NOTHING BUT PUT A PULL IN THE CAR AND IT SILL SWAYS. I THINK IT HAS TO DO WITH THE RACK IN THE CAR AND OR THE ELECTRICAL STEERING IN THE CAR. THE DEALERSHIP SAYS " ITS BEEN FIXED IN THE FIRST RECALL" WELL I AM SAYING ITS NOT SO I THINK IT SHOULD BE RECALLED AGAIN AND FIXED RIGHT THIS TIME.... *TR
NHTSA ODI #10534401
10,000 miles · Jan 8, 2013
Wheels
TL* THE CONTACT OWNS A 2009 CHEVROLET COBALT. THE CONTACT STATED THAT ALL FOUR TIRES WERE DEFLATED. THE CONTACT ALSO STATED THAT THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE WHEELS WERE BENT, WHICH ALLOWED AIR TO ESCAPE PAST THE BEAD OF THE TIRE. THE MANUFACTURER WAS CONTACT…
Read full complaint
TL* THE CONTACT OWNS A 2009 CHEVROLET COBALT. THE CONTACT STATED THAT ALL FOUR TIRES WERE DEFLATED. THE CONTACT ALSO STATED THAT THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE WHEELS WERE BENT, WHICH ALLOWED AIR TO ESCAPE PAST THE BEAD OF THE TIRE. THE MANUFACTURER WAS CONTACTED BUT DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 10,000 AND THE CURRENT MILEAGE WAS 27,000......UPDATED 05/09/13 *BF UPDATED 05/31/2013 *JS
NHTSA ODI #10491808
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Mar 6, 2009
GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".
Consequence & remedy
Consequence: THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE20011 · Fuel Line Leak
Opened Jul 5, 2020 · Closed Aug 17, 2023
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings; Fuel/propulsion System
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Additional source detail variants (3)
Fuel/propulsion System
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Fuel System, Gasoline
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.
Illustration